Table of Contents
Related Manuals for Schwank SCH-90 Series
Summary of Contents for Schwank SCH-90 Series
- Page 1 INSTALLATION / OWNER’S MANUAL SCH-90 & IC-90 SERIES CONSTRUCTION GAS FIRED INFRA RED HEATERS CAUTION: Read all instructions before use Retain this manual for further reference. GP-MCH9-BX-10A SCH-90 / IC-90 Manual R.D: SEPT 2005 Page 1 RL:10...
- Page 2 Waynesboro,Georgia, L4W 2A6 Phone: 1-866-INFRASV (463-7278) Phone: (905) 712-4766 Fax: 1-866-724-9265 http://www.infrasave.com Fax: (905) 712-8336 1-866-361-0417 e-mail: info@infrasave.com PO Box 988, 2 Schwank Way Waynesboro, Georgia, USA 30830 Phone: (706) 554-6191 Fax: (706) 554 9390 1-877-446-3727 e-mail: info@schwankheaters.com http://www.schwankheaters.com GP-MCH9-BX-10A SCH-90 / IC-90 Manual R.D: SEPT 2005...
-
Page 3: Table Of Contents
TABLE OF CONTENTS — INFORMATION AND SAFETY LABELS INSTALLATION REQUIREMENTS GENERAL INSTRUCTIONS GAS SUPPLY LINE/GAS PRESSURE VENTILATION REQUIREMENTS CLEARANCES TO COMBUSTIBLES MOUNTING INSTRUCTIONS LIGHTING/SHUTDOWN INSTRUCTIONS LIGHTING/SHUTDOWN INSTRUCTIONS THERMOSTATIC CONTROL 2.0 MAINTENANCE 3.0 REPLACEMENT PARTS 3.1 SCH-90 / IC-90-N/L 3.2 SCH-90-M / IC-90-M-N/L 4.0 WARRANTY TECHNICAL SPECIFICATIONS Input (BTU) - Normal Altitude:... - Page 4 GP-MCH9-BX-10A SCH-90 / IC-90 Manual R.D: SEPT 2005 Page 4 RL:10...
- Page 5 For Your Information and Safety … Please read the following warning labels. WARNING WARNING FOR YOUR SAFETY Failure to comply with the precautions and instructions provided with this heater can result in death, serious bodily injury and property loss, DO NOT store or use gasoline or other damage from hazards of fire explosion, burn, flammable vapors and liquids in the vicinity of asphyxiation / carbon monoxide poisoning.
-
Page 6: Installation Requirements
WARNING DO NOT use heater in living or office areas. DO NOT store or use gasoline or other flammable vapors or liquids in the vicinity of this Approved for heating buildings or structures or any other appliance. under construction, alteration or repair. DO NOT use this heater if any part has been Use only in well ventilated areas. -
Page 7: Ventilation Requirements
1.2 GAS SUPPLY & PRESSURE INFORMATION All piping and hose must be installed according to local code, and must be of adequate size and construction. Natural gas models must have the supply line limited to 14 inches (maximum) water column. If the line pressure will go above 14 inches water column at any time, a separate regulator must be used. -
Page 8: Mounting Instructions
1.5 MOUNTING INSTRUCTIONS FIGURE 1: SUSPENDED FROM CEILING FIGURE 1: SUSPENDED FROM CEIL- Heater may be suspended from ceiling using chain and mounting hardware. When hanging from joists / beams the 24” clearance to combustibles must be maintained, and measured from the bottom underside of the joist or beam as per drawing, and NOT from the suspension anchoring point of the chain. -
Page 9: Lighting/Shutdown Instructions
1.6 LIGHTING / SHUTDOWN INSTRUCTIONS 1. Pre-purge gas line prior to lighting. 2. Place knob in the OFF position, rotate knob 1 notch, or “click” counter-clockwise. Depress and hold the control knob. Light pilot through porthole. Release knob after sixty seconds. Pilot burns, main burner is off. -
Page 10: Maintenance
1.8 LIGHTING / SHUTDOWN INSTRUCTIONS 1. Pre-purge gas line prior to lighting. 2. Turn the knob counterclockwise to PILOT position, push the knob down and hold in position. The pilot valve opens and allows gas to flow to the pilot burner. 3. - Page 11 Replace filter at least: - once every 2 weeks FILTER RETAINER - minimum once a day when sanding drywall - each time when connecting heater at different location FILTER RETAINER & FILTER * Clean burner screen with each filter change; ( see next window ) Filter replacement: FILTER...
-
Page 12: Replacement Parts
3.0 REPLACEMENT PARTS 3.1 REPLACEMENT PARTS FOR SCH 90-N/L / IC-90-N/L TABLE 3: REPLACEMENT PARTS LIST (REFERENCE PAGE 9) ITEM NO. PART NAME SCH-90-N SCH-90-L SHROUD JH-0613-XX JH-0613-XX WIRE GUARD JH-0610-XX JH-0610-XX UPPER RING PORTION OF GUARD Only JH-0610-TP JH-0610-TP LOWER LEGS PORTION OF GUARD Only JH-0610-BM JH-0610-BM... - Page 13 FIGURE 4: REPLACEMENT PARTS DIAGRAM FOR SCH 90-N/L / IC-90-N/L GP-MCH9-BX-10A SCH-90 / IC-90 Manual R.D: SEPT 2005 Page 13 RL:10...
- Page 14 3.1 REPLACEMENT PARTS FOR SCH 90-M- N/L / IC-90-M-N/L TABLE 3: REPLACEMENT PARTS LIST (REFERENCE PAGE 9) ITEM NO. PART NAME SCH-90-N SCH-90-L SHROUD JH-0613-XX JH-0613-XX WIRE GUARD JH-0610-XX JH-0610-XX UPPER RING PORTION OF GUARD Only JH-0610-TP JH-0610-TP LOWER LEGS PORTION OF GUARD Only JH-0610-BM JH-0610-BM MANTLE...
- Page 15 FIGURE 5: REPLACEMENT PARTS DIAGRAM FOR SCH 90-M- N/L / IC-90-M-N/L GP-MCH9-BX-10A SCH-90 / IC-90 Manual R.D: SEPT 2005 Page 15 RL:10...
- Page 16 GP-MCH9-BX-10A SCH-90 / IC-90 Manual R.D: SEPT 2005 Page 16 RL:10...
-
Page 17: Warranty
This warranty gives you specific legal rights. You may also have other rights which vary by each jurisdiction. 5285 BRADCO BLVD. MISSISSAUGA, ON, L4W 2A6 2 SCHWANK WAY, WAYNESBORO, GEORGIA. 30830-8336 GP-DCHX-BX-03A SCH / IC WARRANTY AUGUST 2005 SCHWANK INC.