Napoleon HD81 Installation And Operation Instructions Manual
  1. Manuals
  2. Brands
  3. Napoleon Manuals
  4. Burner
  5. HD81
  6. Installation and operation instructions manual
Napoleon HD81 Installation And Operation Instructions Manual

Napoleon HD81 Installation And Operation Instructions Manual

Log burner assembly
Hide thumbs Also See for HD81:
Table of Contents

Advertisement

Quick Links

Download this manual
CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS: CSA 2.33, ANSI Z21.88 FOR VENTED GAS FIREPLACE HEATERS.
LOG BURNER
ASSEMBLY
Certified for Canada and United States using ANSI/CSA Methods.
SAFETY INFORMATION
!
If the information in these instructions are not
followed exactly, a fire or explosion may result
causing property damage, personal injury or loss
of life.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
- WHAT TO DO IF YOU SMELL GAS:
● Do not try to light any appliance.
● Do not touch any electrical switch; do not use
any phone in your building.
● Immediately call your gas supplier from a
neighbour's phone. Follow the gas supplier's
instructions.
● If you cannot reach your gas supplier, call the
fire department.
- Installation and service must be performed by a
qualified installer, service agency or the supplier.
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON L4M 4Y8 Canada • (705)721-1212 • fax(705)722-6031
$10.00
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
OPERATION INSTRUCTIONS
HD81
B81NL
NATURAL GAS
B81PL
PROPANE
WARNING
www.napoleonfireplaces.com • ask@napoleon.on.ca
INSTALLATION
APPLY BURNER IDENTIFICATION LABEL FROM CARTON
IDENTIFICATION
No.
AND
MODEL NO.
W415-0713 / 11.25.08
1

Advertisement

Table of Contents
loading

Related Manuals for Napoleon HD81

Summary of Contents for Napoleon HD81

  • Page 1 - Installation and service must be performed by a qualified installer, service agency or the supplier. IDENTIFICATION MODEL NO. Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON L4M 4Y8 Canada • (705)721-1212 • fax(705)722-6031 www.napoleonfireplaces.com • ask@napoleon.on.ca $10.00 W415-0713 / 11.25.08...

  • Page 2: Table Of Contents

    NOTE: Changes, other than editorial, are denoted by a line in the margin. 1.0 generAl InFOrmATIOn This burner and log assembly are approved for use in the HD81 gas fireplace only. They are not approved for use as a stand alone appliance or in conjunction with any other appliance.

  • Page 3: Bulkheads

    BulkheAds NOTE: Bulkhead covers need to be removed. 2.3.1 Connect the gas flex lines and the pilot line to the gas bulkheads located under the valve green access opening. Be sure to match up the gas dots manifold marked with a green dot with the center bulkhead, also marked with a green dot.

  • Page 4: Night Light™ Installation

    InsTAllATIOn your hd81 comes equipped with 2 “night lights™”. the lights have been pre-wired and are controlled from the remote control. Included with the burner assembly are the frames, lenses and gaskets that need to be installed as shown in FIGURE 2.4a...

  • Page 5: Log Placement

    lOg plAcemenT FIGURE 2.6.1 FIGURE 2.6.2 2.6.1 place the left middle log #1 onto the 2.6.2 slide log #2 from right to left on the middle log support creating a tight fit locating stud on the middle log support. make sure the hollow on the underside of between logs #1 and #2.

  • Page 6: Charcoal Lumps

    FIGURE 2.6.7 FIGURE 2.6.8 2.6.8 place the pin in log #8 into the locating 2.6.7 Slide the flat portion of log #7 under the second grate post. hole on log #1 and rest the bottom of the log on log #5. NOTE: logs 3, 4, 5, 6 and 7 are included twice.

  • Page 7: Adjustment

    3.0 AdjusTmenT FlAme chArAcTerIsTIcs It’s important to periodically perform a visual check of the pilot and burner flames. compare them to the illustrations provided. FIGURE 3.1.2 PILOT BURNER 3/8” - 1/2” ELECTRODE FLAME SENSOR FLAME MUST ENVELOP FIGURE 3.1.1 UPPER 3/8” TO 1/2” OF venTurI AdjusTmenT Closing the air shutter will cause a more yellow flame, but can lead to carboning.
  • Page 8 ● Description of part result in property damage or personal injury. ● Finish * IDENTIFIES ITEMS WHICH ARE NOT ILLUSTRATED. FOR FURTHER INFORMATION, CONTACT YOUR AUTHORIZED DEALER. cOmpOnenTs REF NO. hd81 dEsCRIpTION W280-0071 nIght lIght lens FrAme W290-0080 nIght lIght gAsket W300-0067...
  • Page 9 W415-0713 / 11.25.08...

  • Page 10: Notes

    NOTES 5.0 nOTes tp - nOtes W415-0713 / 11.25.08...

  • Page 11: Notes

    nOTes NOTES tp - nOtes W415-0713 / 11.25.08...

  • Page 12: Notes

    nOTes NOTES tp - nOtes W415-0713 / 11.25.08...

This manual is also suitable for:

B81nlB81pl

Table of Contents