DCW BedienA Pedelec_RZ5.qxd Dear customer: You have decided in favor of a Pedelec (Pedal Electric Cycle)- a bicycle that is equipped with an electric motor to give you additional assistance when riding. Properties 1. With this bicycle you can make better progress in headwinds, when transporting heavy loads or on steep slopes.
DCW BedienA Pedelec_RZ5.qxd Charging the battery The charging time given in this manual is the time that is necessary for charging after the capacity of the battery has been used up. This is indicated by the blinking of the battery charge status LED.
DCW BedienA Pedelec_RZ5.qxd Installing the battery . Place the battery in the battery mount, tilted outward on the left hand side by about 45°. 2. Use the guides on the side of the battery when inserting it into the battery holder. 3.
DCW BedienA Pedelec_RZ5.qxd available capacity operating field Battery 20 40 80 100 Check battery status Battery status Battery status indicator LED indicator LED All five (5) LEDs on 80-100% All three LEDs on means about 70-100% capacity Four LEDs on 60-80% remains Three LEDs on...
Page 6
DCW BedienA Pedelec_RZ5.qxd ● 10 minutes after the bicycle is brought to a halt, the current supply is automatically switched off (“Automatic cut off“). When you start riding again, repeat the procedure described above. The torque sensor of the bicycle is automatically reconfigured every time you change the riding mode.
DCW BedienA Pedelec_RZ5.qxd When necessary, set the accessory motor to high mode. If no pedalling is necessary when riding downhill, the accessory motor will switch off automatically. recommended gear recommended mode Level road Shift to 3 or 4th Set mode to Easy pedalling in 1 gear Uphill...
Page 8
DCW BedienA Pedelec_RZ5.qxd Battery tips The bicycle that you have purchased is operated with the following battery types: Model: Li-lon-battery (Ni-Li) NKY224B02 Capacity: 10 Ah This battery can be charged and discharged about 500 times. A battery should always be considered as a part which is subject to wear. This means that the initial capacity diminishes with increasing age and according to the frequency with which the battery is charged.
DCW BedienA Pedelec_RZ5.qxd Discharge characteristic curve (temperature) Possible discharge capacity at ordinary temperature Low temp. discharge curve Possible discharge capacity at low temperature (Time) Possible discharge capacity at ordinary temperature (Time) Discharge capacity (Ah) or hours required Regardless of whether it is a NiCd, NiMH or Li ion battery, charging is accomplished by a chemical reaction of the substances inside the battery.
DCW BedienA Pedelec_RZ5.qxd ● The charger can only be connected to a 220-230 V socket. ● Avoid prolonged direct skin contact with the charger during the charging process. During this time the device heats up to about 40-60°C. Risk of burns! ●...
Page 11
DCW BedienA Pedelec_RZ5.qxd Error Remark Blinking LEDs Blinking interval - a field corresponds to 0.5 sec Upper power diode Middle power diode Following this 1 to 3 diodes light up depending on the residual capacity Self configuration Lower power diode Directly after “High”...
Page 12
DCW BedienA Pedelec_RZ5.qxd Error search Problem Cause item to be checked Problem Cause item to be checked current cannot be 1) no remaining 1) check the battery Weak support 1) capacity drop due to 1) have the voltage on switched on battery capacity charge status indicator battery ageing...
Page 13
DCW BedienA Pedelec_RZ5.qxd Problem Cause Item to be checked Range is reduced 1) Aging, end of service 1) Check the useful life of life of battery the battery. 2) Overload (carrying 2) Are you driving with the heavy loads, climbing, bike when the gear is at gear use) “middle”...
DCW BedienA Pedelec_RZ5.qxd Technical data Drive Motor Motor type: Brushless pedal bearing motor Power output 250 W Control by a force sensor i.e. at assistance level 1:1, the drive feeds the same power into the system that the rider himself applies Battery Removable, rechargeable Lithium ion manganese battery 26 V 10 Ah (260 Wh)