Page 1
MODEL 463620208 • PRODUCT GUIDE THIS GRILL IS FOR OUTDOOR USE ONLY. CAUTION: WARNING: Read and follow all safety statements, assembly Failure to follow all manufacturer’s instructions instructions, and use and care directions before could result in serious personal injury and/or attempting to assemble and cook.
Page 2
CAUTION CAUTION CAUTION: Indicates a potentially hazardous situation or For residential use only. Do not use for commercial unsafe practice which, if not avoided, may result in minor cooking. or moderate injury. 2 • 463620208...
Registration Card ........23 modification to this assembly will void your warranty and create the risk of a gas leak and fire. Use only authorized replacement parts supplied by manufacturer. 463620208 • 3...
Page 4
• To remove gas from LP cylinder, contact an LP dealer or call a Retainer Strap by the sun. local fire department for assistance. Check the telephone • Do not store an LP cylinder in an area where children play. directory under “Gas Companies” for nearest certified LP dealers. 4 • 463620208...
Continued on next page. Nipple has to be centered into the LP cylinder valve. WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! 463620208 • 5...
• Do not use grill until leak-tested. • If a leak is detected at any time, STOP and call the fire department. • If you cannot stop a gas leak, immediately close LPcylinder valve and call LP gas supplier or your fire department! 6 • 463620208...
Page 7
Only use the pressure regulator and hose assembly supplied with this grill. Replacement pressure regulator and hose assemblies must be specified or supplied by Char-Broil, LLC. If you have a grill problem see the "Troubleshooting Section". If the regulator frosts, turn off grill and LP cylinder valve immediately.
Page 8
• Cooking surfaces: If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot. 8 • 463620208...
• Store grill indoors ONLY if LP cylinder is turned off and disconnected, removed from grill and stored outdoors. • When removing grill from storage, follow “Cleaning the Burner Assembly” instructions before starting grill. 463620208 • 9...
Page 10
For more information call: USDA Meat and Poultry Hotline at • When reheating takeout foods or fully cooked meats like hot 1-800-535-4555 In Washington, DC (202) 720-3333, 10:00 am- dogs, grill to 165° F, or until steaming hot. 4:00 pm EST. 10 • 463620208...
Design®, Sierra®, and TruFlame® are registered Trademarks of the W.C. Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates. Artisan Collection by Char-Broil ™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™, Grill 2 Go™, Grillin’ Stick™, Keeper of the Flame™, Keepers of the Flame™, Natural Grip™, Outdoor Cooking Collection and Design™, Patio Bistro™, PrecisionFlame™, Pro-Check™, QuickSet Grills and Design™, SmokerTents™, The Big Easy™, The Minute Grill™, The Edge™, The Tuscan...
ASSEMBLY – Model No. 463620208 Position leg assemblies as shown below. Hook tank exclusion wire into legs with longer wires to the left (A). Attach upper and lower back brace to legs with # 10-24 X1/2" machine screws and #10-24 flange nuts (B).
Page 14
(Install into hole In Axle Rod) Fig. A Wheel Bushing Axle Hole Attach control panel to front of cart with #10-24x1-1/4" machine screws and #10-24 flange nuts. #10-24 Flange Nuts Qty. 2 #10-24 X 1-1/4” Machine Screw Qty. 2 14 • 463620208...
#10-24X1/2" machine screws, fiber washers and #10-24 flange nuts (B). #10-24 Flange Nuts Qty. 4 #10-24 X ½” Fiber Washer Machine Screw Qty: 4 Qty. 4 Burner Tube Valve Correct burner-to-valve engagement Lid removed for clarity 463620208 • 15...
Page 16
Qty. 2 Machine Screw Qty. 2 Ignitor Wire to Ignitor Attach handle to front of lid using insulation washers, fiber washers and #10-24 wing nuts. Insulation Washer Handle Fiber Washer Qty:2 Qty: 2 #10-24 Wing Nut Qty: 2 16 • 463620208...
Page 17
#10-24 Flange Nut #10-24X1/2’ Qty: 8 Machine Screw Qty: 8 Place vaporiser bar onto the two pins on each side inside the firebox. Place cooking grate onto firebox. Attach knobs to valve stems. Cooking Grate Vaporiser Bar 463620208 • 17...
Page 18
Hang grease cup clip from bottom of firebox and place grease cup into grease clip CAUTION Failure to install grease cup clip and cup will cause hot grease to drip from bottom of grill with risk of fire or property damage. Grease Cup Clip Grease Cup 18 • 463620208...
Page 19
Correctly Installed LP cylinder. Regulator LP Cylinder (not included) Always keep LP cylinders in upright position during use, transport, and storage. 463620208 • 19...
• Clean wire and/or electrode with rubbing alcohol and clean swab. cooking residue. • Wires are loose or disconnected. • Reconnect wires or replace electrode/wire assembly. • Wires are shorting (sparking) between • Replace ignitor wire/electrode assembly. ignitor and electrode. 20 • 463620208...
Page 21
Use and Care. Unable to fill LP • Some dealers have older fill nozzles • The worn nozzles don’t have enough “bite” to engage the valve. Try cylinder. with worn threads. a second LP dealer. 463620208 • 21...
Consumer returns will not be accepted unless a valid Return Authorization is first acquired by calling 1-800-241-7548 and then clearly marked on the outside of the package and the package is shipped freight/postage pre-paid to the address above. 22 • 463620208...
Please register your grill online at: WWW.GRILLREGISTRATION.COM (If you register online, you do not need to send in this registration card.) La parrilla estaba ensamblada Chimenea / Envíelo a: 463620208 • 23...
Page 24
Always ensure control knobs are in OFF position and regulator is attached to tank BEFORE opening tank valve to avoid low flames. Perform leak test regularly. Thank You for Your Purchase! Char-Broil, LLC • Columbus, GA 31902 • Printed in China...
Need help?
Do you have a question about the 463620208 and is the answer not in the manual?
Questions and answers