Page 1
Stainless Steel Gas Grill USE AND CARE GUIDE MODEL NO.: 720-0104-NG FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE...
TABLE OF CONTENTS SECTION ONE SECTION FIVE Safety Instructions………………………… Care & Maintenance of Side Burner……. Placement of the grill……………………… SECTION SIX SECTION TWO Lighting Illustrations………………………. Side Shelf Assembly………………………. Exploded View…………………………….. Side Shelf Handle Assembly……………… Parts List ………………………………….. Battery & Propane Tank Assembly……… Grilling Hints………………………………..
PRECAUTIONS SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. This can severely upset combustion air flow or trap excessive heat in the control area.
Page 4
PRECAUTIONS SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING: IMPORTANT! USING THE SIDE BURNER: Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present.
Page 5
SAFETY INSTRUCTIONS WARNING *** FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, immediately call your gas supplier or your fire department. FOR YOUR SAFETY 1.
Page 6
PRECAUTIONS SAFETY INSTRUCTIONS This outdoor cooking gas appliance is not intended WARNING to be installed in or on recreational vehicles and/or Do not try lighting this appliance without reading the boats. “LIGHTING INSTRUCTIONS” section of this manual. CHILDREN SHOULD NOT BE LEFT ALONE OR TESTED IN ACCORDANCE WITH ANSI Z21.58- UNATTENDED IN AN AREA WHERE THE GRILL 2002 CGA 1.6B-2002 and Z21.58a-2002 CGA...
THE GRILL. them periodically for optimum performance. The burners will only operate in one position and must The 720-0104-NG Grill is designed for optimum be mounted correctly for safe operation. performance without the use of briquettes. Do not place briquettes on the radiant as this will block off Clean the grill with caution.
SIDE SHELF ASSEMBLY The screws used to attach the side shelf are already screwed into the two-side panel (see the figure below). Remove the screws and flat washers from the two-side panel, align with the holes in the side shelf panel, and then re-screw into the holes on the two side panel of the grill.
SIDE SHELF HANDLE ASSEMBLY The screws used to attach the side shelf handle are already screwed into the side shelf handle (see the figure below). Remove the screws from the side shelf handle, align with the holes in the side shelf, and then secure into the holes on the right side shelf of the grill.
BATTERY & PROPANE TANK ASSEMBLY In order to install the battery, remove the ignition button housing. Please keep the positive pole facing toward you. Replace the ignition button housing after battery is installed.
TO MATCH LIGHT THE GRILL If the burner will not light after several attempts then the burner can be match lit. If you’ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible.
ROTISSERIE KIT ASSEMBLY The screws for rotisserie mount are already screwed into the right side of the grill. Remove the screws and install the rotisserie motor mount as shown in the figure below. Assemble the rotisserie skewer as shown in the figure below. Attach propane gas tank to regulator inlet fitting by turning the regulator clockwise(see figure below).
CONNECTION: Total gas consumption (per hour) of 720-0104-NG Your grill is equipped with gas supply orifices for grill with all burners on “HI”: use only with liquid propane gas. It is also equipped...
LEAK TESTING GENERAL Although all gas connections on the grill are leak the burners. The flames of the burners should be tested at the factory prior to shipment, a complete visually checked. gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit.
INSTALLER FINAL CHECK Specified clearance maintained 24” from Unit tested and free of leaks. combustibles. User informed of gas supply shut off valve All internal packaging removed. location. Knobs turn freely. Burners are tight and sitting properly on orifices. PLEASE RETAIN THESE INSTRUCTIONS FOR Pressure regulator connected and set for 11.2”...
OPERATING INSTRUCTION General use of the grill and rotisserie Each main burner is rated at 12,000 BTU/hr. The the stainless steel motor mount. The rotisserie main grill burners encompass the entire cooking motor must be electrically grounded in accordance area and are side ported to minimize blockage from with local codes or, in the absence of local codes, falling grease and debris.
LIGHTING INSTRUCTIONS these conditions exist call our customer service line. WARNING: IMPORTANT! If the flame is yellow, it indicates insufficient air. If the flame is noisy and tends to lift away from the BEFORE LIGHTING… burner, it indicates too much air. Inspect the gas supply hose prior to turning the gas (See “GAS FLOWCHECK”...
USING THE SIDE BURNER control knob counterclockwise to the “HI” position. If the burner does not light, turn the control knob to WARNING: IMPORTANT! “OFF”. If the smell of gas is detected and the igniter USING THE SIDE BURNER: is not functioning, immediately turn the control knob Inspect the gas supply hose prior to turning the gas “OFF”.
CARE & MAINTENANCE OF SIDE BURNER SIDE BURNER CLEANING: Clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off and clog the port. STAINLESS STEEL: There are many different stainless steel cleaners available.
LIGHTING ILLUSTRATIONS Main & Side Burner Lighting Illustration Rotisserie Burner Lighting Illustration 1. Make sure the lid is open 1. Push and turn the rotisserie knob to HIGH. 2. Push and turn one of main burner knob to HI position 2. Press the electric igniter 3 to 4 seconds to light the rotisserie burner 3.
MODEL 720-0104-NG PARTS LIST REF# DESCRIPTION Q’TY REF# DESCRIPTION Lid, Front Bottom Panel Heat Indicator Caster Name Plate Individual Shelf Heater Insulating Spacer Tower Rack Bracket Handle Assembly, Lid Tower Rack Cooking Grid, Side burner Door Hinge Side Burner Head...
GRILLING HINTS The doneness of meat, whether rare, medium, or Use a spatula instead of tongs or a fork to turn the well done, is affected to a large degree by the meat, as a spatula will not puncture the meat and thickness of the cut.
Page 26
FOOD WEIGHT FLAME APPROXIMATE SPECIAL OR THICKNESS SIZE TIME INSTRUCTIONS AND TIPS MEATS BEEF Hamburgers 1/2 to 3/4 inch Medium 10 to 18 minutes Grill, turning once when juices rise to the surface. Do not leave hamburgers unattended since a flare-up could occur quickly.
Page 27
FOOD WEIGHT FLAME APPROXIMATE SPECIAL OR THICKNESS SIZE TIME INSTRUCTIONS AND TIPS Breasts Medium 30 to 45 minutes Marinate with Italian dressing well-done FISH AND Grill, turning once. Brush with SEAFOOD melted butter, margarine or oil to keep moist. Steaks Halibut 3/4 to 1 inch Medium to...
GRILL RECIPE SUGGESTIONS SALMON In medium bowl, combine shrimp and aluminum foil. Bake covered 25 scallops. In small bowl combine chili minutes on medium with the lid of sauce and next six ingredients. Pour your BBQ grill closed. Remove foil 2 large salmon steaks over seafood.
Page 29
½ tsp. pepper Heat through. If sauce gets too thick, Marinade ribs for 3 hours. Use ¼ tsp. oregano add 1 tbs. water. Serve sauce with marinade for basting by adding beer ¼ tsp. cumin kabobs. to it. Place pan under the ribs and Flour tortillas baste frequently.
LIMITED WARRANTY MODEL 720-0026-LP STAINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries, Inc. warrants to the original consumer purchaser of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below.
Need help?
Do you have a question about the 720-0104-NG and is the answer not in the manual?
Questions and answers