GLEN CANYON 720-0026-LP Use And Care Manual

Stainless steel gas grill

Advertisement

Stainless Steel Gas Grill
USE AND CARE GUIDE
MODEL NO.: 720-0026-LP
PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE
FOR OUTDOOR USE ONLY
®

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 720-0026-LP and is the answer not in the manual?

Questions and answers

Summary of Contents for GLEN CANYON 720-0026-LP

  • Page 1 Stainless Steel Gas Grill USE AND CARE GUIDE MODEL NO.: 720-0026-LP ® FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE...
  • Page 2: Table Of Contents

    TABLE OF CONTENTS SECTION ONE SECTION FIVE Safety Instructions…………………………1~5 Using the side burner…………………… Placement of the grill………………………5 Care & Maintenance ………………. Trouble Shooting………………………… SECTION TWO 19~21 Side Shelf Assembly………….……….……6 SECTION SIX Side Shelf Handle Assembly…………...…7 Lighting Illustrations………………………. Battery Installation ………….……………..8 Exploded View……………………………..
  • Page 3: Safety Instructions

    SAFETY INSTRUCTIONS ***** WARNING ***** FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open Lid. 4. If odor continues, immediately call your gas supplier or your fire department. FOR YOUR SAFETY 1.
  • Page 4: Safety Instructions

    SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. This can severely upset combustion airflow or trap excessive heat in the control area.
  • Page 5 SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING: Always keep your face and body as far away from the burner as possible when lighting. WARNING: IMPORTANT! BEFORE LIGHTING… Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use.
  • Page 6 SAFETY INSTRUCTIONS CHILDREN SHOULD NOT BE LEFT ALONE OR TESTED IN ACCORDANCE WITH ANSI Z21.58b UNATTENDED IN AN AREA WHERE THE GRILL IS LATEST STANDARD 1.6b-2002 BEING USED. NEVER ALLOW THEM TO SIT, STANDARD FOR OUTDOOR COOKING GAS STAND OR PLAY ON OR AROUND THE GRILL AT APPLIANCES.
  • Page 7: Placement Of The Grill

    It is necessary to clean them periodically for optimum performance. The burners will The 720-0026-LP Grill is designed for optimum performance only operate in one position and must be mounted without the use of briquettes. Do not place briquettes on the correctly for safe operation.
  • Page 8: Side Shelf Assembly

    SIDE SHELF ASSEMBLY The screws used to attach the side shelf are already screwed into the two-side panel (see the figure below). Remove the screws and flat washers from the two-side panel, align with the holes in the side shelf panel, and then re-screw into the holes on the two side panel of the grill.
  • Page 9: Side Shelf Handle Assembly

    SIDE SHELF HANDLE ASSEMBLY The screws used to attach the side shelf handle are already screwed into the side shelf handle (see the figure below). Remove the screws from the side shelf handle, align with the holes in the side shelf, and then secure into the holes on the right side shelf of the grill.
  • Page 10: Battery Installation

    BATTERY INSTALLATION In order to install the battery, remove the ignition button housing. Please keep the positive pole facing toward you. Replace the ignition button housing after battery is installed.
  • Page 11: Installation Of Utensil Hook

    INSTALLATION OF UTENSIL HOOK Hang up the Utensil Hooks on left and right side shelf as shown in figure below.
  • Page 12: Rotisserie Motor&Rotisserie Kit Assembly

    ROTISSERIE MOTOR &ROTISSERIE KIT ASSEMBLY 1. The rotisserie motor mount are already screwed into the right side of the grill. Put the rotisserie motor on the mount as shown in the figure below. Assemble the rotisserie skewer as shown in the figure below.
  • Page 13: Propane Tank Assembly

    PROPANE TANK ASSEMBLY 1. Attach regulator to the propane tank by turning the regulator handle clockwise (FIGURE 1). 2. Turn off LP supply at cylinder when appliance is not in use. Put the gas tank into the gas tank pull-out tray. Then tighten up the gas tank fixed pole...
  • Page 14: To Match Light The Grill

    TO MATCH LIGHT THE GRILL 1. If the burner will not light after several attempts then the burner can be match lit. 2. If you’ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible.
  • Page 15: Gas Hook-Up

    Total gas consumption (per hour) of 720-0026-LP grill with CONNECTION: all burners on “HI”: Your grill is equipped with gas supply orifices for use only with liquid propane gas.
  • Page 16: Leak Testing

    LEAK TESTING GENERAL Should be visually checked. Although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling shipment, excessive pressure unknowingly being applied to the unit.
  • Page 17: Installer Final Check

    INSTALLER FINAL CHECK Specified clearance maintained 24” from Unit tested and free of leaks. combustibles. User informed of gas supply shut off valve All internal packaging removed. location. Knobs turn freely. Burners are tight and sitting properly on orifices. PLEASE RETAIN THESE INSTRUCTIONS FOR Pressure regulator connected and set for 11.2”...
  • Page 18: Operating Instructions

    OPERATING INSTRUCTIONS General use of the grill and rotisserie The skewer for the rotisserie is assembled into the motor Each main burner is rated at 12,000 BTU/hr. The main grill assembly by placing the pointed end into the motor, and burners encompass the entire cooking area and are side then sliding the grooved bushing into the slot at the ported to minimize blockage from falling grease and debris.
  • Page 19: Lighting Instructions

    LIGHTING INSTRUCTIONS WARNING: IMPORTANT! these conditions exist call our customer service line. If the flame is yellow, it indicates insufficient air. If the BEFORE LIGHTING… flame is noisy and tends to lift away from the burner, it Inspect the gas supply hose prior to turning the gas indicates too much air.
  • Page 20: Using The Side Burner

    USING THE SIDE BURNER WARNING: IMPORTANT! control knob counterclockwise to the “HI” position. If USING THE SIDE BURNER: the burner does not light, turn the control knob to Inspect the gas supply hose prior to turning the gas “OFF”. If the smell of gas is detected and the igniter is “ON”.
  • Page 21: Trouble Shooting

    ARE & MAINTENANCE OF SIDE BURNER IDE BURNER CLEANING: lean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened per clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off and clog e port.
  • Page 22 TROUBLE SHOOTING ROBLEM SOLUTION When I light the grill it does not flame --Make sure y ou have turn on the gas immediately. --Make sure it has spark while you are try ing to ignite the burner. Push in for approximatel y 5 second before to turn and ignite the grill.
  • Page 23 Rotisserie motor will not turn --Check the voltage at the outlet. If an extension cord is required, ensure it is a 16 gauges, grounded cord. Ensure the on/o ff switch is on. --Ensure the load does not exceed the 40 pounds operational capacity.
  • Page 24: Lighting Illustrations

    LIGHTING ILLUSTRATIONS ain Burner Lighting Illustration Rotisserie Burner Lighting Illustration 1.Make sure the lid is open . Push and turn the rotisserie knob to HI. 2. Push and turn one of main burner knobs 2. Press the electric igniter 3 to 4 to to HI position seconds light the rotisserie burner.
  • Page 25: Exploded View

    EXPLODED VIEW...
  • Page 26: Parts List

    MODEL 720-0026-LP PARTS LIST REF# DESCRIPTION Q’TY REF# DESCRIPTION Lid, Front Gas Tank Tray Slide Heat Indicator Gas Tank Tray Name Plate Individual Shelf Heater Insulating Spacer Tower Rack Bracket Handle As sembly, Lid Tower Rack Cooking G rid, Side burner...
  • Page 27: Grilling Hints

    GRILLING HINTS The don ss o f meat, whether rare, medium, o r well a sp atula instead of tongs o r a fork to turn th done, is affected to a large degree by the thickness of meat, as a spatula will not puncture the meat and let the cut.
  • Page 28: Grill Cooking Chart

    GRILL COOKING CHART FOOD WEIGHT OR FLAME APPROXIMATE SPECIAL INSTRUCTIONS THICKNESS SIZE TIME AND TIPS VEGETABLES Slice. with butter margarine. Wrap in heavy-duty foil. Grill, turning occasionally. Fresh: Beets Medium to 20 minutes Grill, turning once. Brush Carrots occasionally with melted butter or Turnips margarine.
  • Page 29 Well-done 1 inch Mediu 18 to 30 minutes 1-1/2 inches edium to 35 minutes Lamb Chops & Steaks Rare 1 inch High 10 to 15 minutes Remove excess fat from edge. Slash remaining fat at 2- intervals. Grill, turning once. 1-1/2 inch High 14 to 18 minutes...
  • Page 30: Grill Recipe Suggestion

    GRILL RECIPE GESTION BBQ SALMON 1 20 oz. Can pineapple chunks in juic aluminum foil. Bake covered 25 mi nutes 2 large sal mon steaks drained In medium wl, combine shrim on med ium with the lid of your BBQ grill 2 tbs.
  • Page 31 ½ tsp. salt Bring marinade to boil on the side 1 chicken bouillon cube ½ tsp. celery salt burner in a saucepan. Add remaining 1 can beer for basting sauce ¼ tsp. garlic powder 1/3 c. water and peanut butter. Stir to ½...
  • Page 32: Limited Warranty

    IMITED WARRANTY MODEL 720-0026-LP TAINLESS STEEL OUTDOOR GAS GRILL exgrill Industries, Inc. warrants to the original consumer purchaser of each Outdoor Gas Grill that when subject to nor mal residential use, it is free from defects in orkmanship and materials for the periods specified below. This warranty excludes grills used in rental or comm ercial applications.

Table of Contents

Save PDF