Table of Contents
Advertisement
http://waterheatertimer.org/New-water-heater-ideas.html
State - Premier
Hybrid Electric
Heat Pump Water Heater
Installation
Instructions and
Use & Care Guide
To obtain technical, warranty or service assistance during or after
the installation of this water heater, call toll free
1-800-365-0024
When calling for assistance, please have the following
information ready:
1. Model number
2. 7 Digit product number
3. Serial number
4. Date of installation
5. Place of Purchase
Table of Contents
Water Heater Safety ............................................................................... 2
Installing Your Water Heater ................................................................. 3-9
Installation Checklist .............................................................................. 10
Operating Your Water Heater ........................................................... 11-13
Maintenance of Your Water Heater .................................................. 14-15
Diagnostic Codes .................................................................................. 16
Troubleshooting Chart ........................................................................... 17
Repair Parts Illustration ......................................................................... 18
Notes... .............................................................................................. 19-20
®
Consumer Information ................................................................ 3
Consumer Responsibilities ......................................................... 3
Unpacking Instructions ............................................................ 3-4
Location Requirements ............................................................... 4
Water System Piping ................................................................ 5-6
Temperature & Pressure Relief Valve ....................................... 7-8
Electrical Requirements ........................................................... 8-9
Before Using ............................................................................. 11
Water Temperature Regulation ................................................. 11
Adjusting the User Interface Module/ Operational Mode .......... 12
Operational Conditions ............................................................. 13
Temperature and Pressure Relief Valve .................................... 14
Draining and Flushing ................................................................ 14
Heating Element Replacement ............................................. 14-15
Cleaning the Heat Pump ........................................................... 15
Page
318258-000
February 2010
1
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for State Water Heaters Hybrid Electric Heat Pump Water Heater
Summary of Contents for State Water Heaters Hybrid Electric Heat Pump Water Heater
-
Page 1: Table Of Contents
http://waterheatertimer.org/New-water-heater-ideas.html State – Premier ® Hybrid Electric Heat Pump Water Heater Installation Instructions and Use & Care Guide To obtain technical, warranty or service assistance during or after the installation of this water heater, call toll free 1-800-365-0024 When calling for assistance, please have the following information ready: 1. -
Page 2: Water Heater Safety
WATER HEATER SAFETY Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others. -
Page 3: Installing Your Water Heater
INSTALLING YOUR WATER HEATER the water while the electric elements only function during Consumer Information high demand periods. (See “Adjusting the User Interface This water heater should be installed in accordance with Module/ Operational Mode” section). The more often the local code authority having jurisdiction, the power the unit operates using the heat pump, rather than the company or electric utility, and this installation manual. -
Page 4: Location Requirements
• The water heater must NOT be placed on its side. It IMPORTANT: The water heater should be located in an should be transported and stored in an upright position. area where leakage of the tank, connections, condensate • Remove exterior packaging and place installation lines or condensate will not result in damage to the area components aside. -
Page 5: Water System Piping
Some local codes may require, and the manufacturer Water System Piping of this water heater recommends, installing a mixing Piping, fi ttings, and valves should be installed according to valve or an anti-scald device in the domestic hot water the installation drawing (Figure 4). If the indoor installation line as shown in Figure 4. -
Page 6: Condensate Drain Line Installation
Please note the following: Closed System/Thermal Expansion • The system should be installed only with piping that is WARNING suitable for potable (drinkable) water such as copper, CPVC, or polybutylene. This water heater must not be installed using iron piping or PVC water piping. •... -
Page 7: Temperature & Pressure Relief Valve
To reduce the risk of excessive pressures and temperatures Temperature and Pressure in this water heater, install temperature and pressure relief Relief Valve protective equipment required by local codes, but no less than a combination temperature and pressure relief valve WARNING certifi... -
Page 8: Electrical Requirements
If you lack the necessary skills required to properly install the Figure 6 electrical wiring to this water heater, do not proceed but have a T&P Relief Valve Insulation qualifi ed electrician perform the installation. When making the electrical connections, always make sure: T&P Relief Valve Insulation •... -
Page 9: Insulation Blankets
Connect these two wires to the two wires on the water Figure 8A heater using wire nuts or other connectors. Junction Box Connect the free ends of the two wires to the shut off Green switch on the condensate pump in accordance with the Ground manufacturers recommendations. -
Page 10: Installation Checklist
INSTALLATION CHECKLIST Condensate Drain Line Installation Water Heater Location □ Must be located with access to an adequate drain or □ Centrally located with the water piping system. condensate pump. □ The fl ooring beneath the water heater must be able to □... -
Page 11: Operating Your Water Heater
OPERATING YOUR WATER HEATER Before Using Water Temperature Regulation Make sure the water heater has been properly WARNING installed. See “Installing Your Water Heater” section. Make sure the air filter is correctly seated, as it may shift during shipping or installation. See “Repair Parts Illustration”... -
Page 12: Adjusting The User Interface Module/ Operational Mode
Adjusting the User Interface Module/Operational Modes Water Temperature Adjustment Other Controls The water temperature can be adjusted from 95°F to 150°F. Lock - Holding this button for more than 3 Use the Up and Down Buttons on the front seconds switches the lock mode on or off. When panel to set the desired temperature. -
Page 13: Operational Conditions
Water Heater Sounds Operational Conditions During the normal operation of the water heater, sounds or Powered Anode Operation noises may be heard. These noises are common and may result from the following: To shelter the glass-lined water tank from corrosion through electrolysis, this water heater is equipped with a Normal expansion and contraction of metal parts non-sacrificial powered anode which should not need to be... -
Page 14: Maintenance Of Your Water Heater
MAINTENANCE OF YOUR WATER HEATER Place the water heater in Standby Mode by pressing Temperature and Pressure the power button on the user interface module. Turn off the power to the water heater at the circuit Relief Valve breaker/fuse box. Open a nearby hot water faucet until the water is no WARNING longer hot. -
Page 15: Cleaning The Heat Pump
Routine Preventive Maintenance Figure 12: At least monthly, a visual inspection should be made of the following: Wires • Air Filter (Remove and inspect, clean if needed, and reinstall). • Condensate drain pan and condensate lines. Element • The lower metal drain pan for standing water which may indicate a clogged condensate drain pan, condensate lines, or plumbing leak. -
Page 16: Heating Element Replacement
DIAGNOSTIC CODES DISPLAY SHOWS INDICATES CORRECTIVE ACTION Upper element is not functioning Turn off power at the circuit breaker/fuse UPPER ELEMENT box and check for a loose connection at the CONNECT element. For access directions see “Heating FAULT Element Replacement” section. If error persists proceed to the next step. -
Page 17: Troubleshooting Chart
TROUBLESHOOTING CHART PROBLEM POSSIBLE CAUSE(S) CORRECTIVE ACTION Hot water usage pattern exceeds the Change to different mode or modify usage NO HOT WATER capability of the water heater in patterns current mode No power to the water heater Check for blown fuse or tripped breaker. Restore power to unit then press power button. -
Page 18: Repair Parts Illustration
REPAIR PART ILLUSTRATION REPAIR PARTS LIST PARTS DESCRIPTION ITEM Upper Access Cover Lower Access Cover Upper Element (4500 Watts) Lower Element (2000 Watts) Energy Cut-Off (ECO) Switch Temperature & Pressure Relief Valve (T&P) Dip Tube (at hot water outlet) Powered Anode Rod User Interface Module Air Filter Air Inlet Side Panel... -
Page 19: Notes
NOTES... - Page 20 Copyright © 2010 State Industries, Inc. All rights reserved.
Need help?
Do you have a question about the Hybrid Electric Heat Pump Water Heater and is the answer not in the manual?
Questions and answers