Burner Start Up And Test Information - Columbia L series Installation, Operation And Maintenance Manual

BURNER START UP AND TEST INFORMATION

For a new boiler start up, or for troubleshooting an existing installation, the following
information is essential for effective service assistance.
Boiler Model_________________
Burner Model________________
Installation Name__________________________________________
Start Up Contractor________________________________________
Name of Technician Performing Start Up_____________________________________________________
Fuel Type: K Natural Gas K LP Gas K Fuel Oil (#2) K Other_________________________________
Gas Firing
Gas Pressure At Train Inlet
Burner In Off Position_______ "W.C.
Gas Pressure At Train Inlet
High Fire__________________ "W.C.
Gas Pressure At Main Orifice
High Fire__________________ "W.C.
Gas Pressure At Pilot Orifice
__________________ W.C.
Oil Firing
High Fire Vacuum Reading At Oil
Pump Inlet_______________ "H.G.
Oil Nozzle Supply Pressure
Low Fire__________________PSI
High Fire__________________PSI
Firing Rate - GPH
Low Fire__________________
High Fire__________________
Operational Check of Controls
Operating Limit__________________K
Safety Limit_____________________K
Low Water Cut Off_______________K
Comments
____________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
LWLCWH COLUMBIA BOILER COMPANY REV. 13106
Serial No.________________
Invoice No._____ __________
Flame Signal Readings
Pilot____________________________
CO2
High Fire_________________________
CO
High Fire_________________________
Measured Input Rate - BTU/HR
High Fire__________________ "W.C.
CO2
Low Fire________________________
High Fire_________________________
Bachrach Scale Smoke Number
Low Fire_________________________
High Fire_________________________
Over Fire Draft
Low Fire___________________ "W.C.
High Fire___________________ "W.C.
Aux LWCO______________________K
Low Gas Pressure_______________K
High Gas Pressure_______________K
20
N.B. No.______________________
Serial No._____________________
Start Up Date_________________
Phone No.____________________
Stack Outlet Test Point Draft
High Fire__________________ "W.C.
Over Fire Draft
High Fire__________________ "W.C.
Net Stack Temperature
High Fire___________________°F
Stack Outlet Test Point Draft
Low Fire__________________ "W.C.
High Fire__________________ "W.C.
Net Stack Temperature
Low Fire___________________°F
High Fire___________________°F
Flame Safeguard________________K
Ignition Failure
Flame Failure
K
K