Burner Start Up And Test Information - Columbia MPH SERIES Installation, Operation And Maintenance Manual

BURNER START UP AND TEST INFORMATION

For a new boiler start up, or for troubleshooting an existing installation, the following
information is essential for effective service assistance.
Boiler Model__________________
Burner Model_________________
Installation Name___________________________________________ Start Up Date_________________
Start Up Contractor_________________________________________ Phone No.____________________
Name of Technician Performing Start Up_____________________________________________________
Fuel Type: q Natural Gas q LP Gas q Fuel Oil (#2) q Other________________________________
Gas Firing
Gas Pressure At Train Inlet
Burner In Off Position_______ "W.C.
Gas Pressure At Train Inlet
High Fire__________________ "W.C.
Gas Pressure At Main Orifice
Low Fire__________________ "W.C.
High Fire__________________ "W.C.
Gas Pressure At Pilot Orifice
__________________ W.C.
Oil Firing
High Fire Vacuum Reading At Oil
Pump Inlet_______________ "H.G.
Oil Nozzle Supply Pressure
Low Fire__________________PSI
High Fire__________________PSI
Firing Rate - GPH
Low Fire__________________
High Fire__________________
Operational Check of Controls
Operating Limit__________________q
Safety Limit_____________________q
Low Water Cut Off_______________q
Motor Amps ____________________q
Comments
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
___________________________________________________________________________________________________________
Serial No.________________
Invoice No._______________ Serial No.____________________
Flame Signal Readings
Pilot____________________________
CO2
Low Fire_________________________
High Fire_________________________
CO
Low Fire_________________________
High Fire_________________________
Measured Input Rate - BTU/HR
Low Fire__________________BTU/HR
High Fire__________________BTU/HR
CO2
Low Fire___________________ _______
High Fire_________________________
Bachrach Scale Smoke Number
Low Fire_________________________
High Fire_________________________
Over Fire Draft
Low Fire___________________ "W.C.
High Fire___________________ "W.C.
Aux LWCO______________________q
Low Gas Pressure_______________q
High Gas Pressure_______________q
Damper Position_________________q
MPH COLUMBIA BOILER COMPANY
N.B. No._____________________
Stack Outlet Test Point Draft
Low Fire__________________ "W.C.
High Fire__________________ "W.C.
Over Fire Draft
Low Fire__________________ "W.C.
High Fire__________________ "W.C.
Net Stack Temperature
Low Fire___________________°F
High Fire___________________°F
Stack Outlet Test Point Draft
Low Fire__________________ "W.C.
High Fire__________________ "W.C.
Net Stack Temperature
Low Fire___________________°F
High Fire___________________°F
Flame Safeguard________________q
Ignition Failure
Flame Failure
Interlock Set Points ____________ q
q
q
18