Download  Print this page

Sony HCD-SC5 Service Manual

Sacd/dvd receiver.
Hide thumbs

Advertisement

HCD-SC5/SC6/SC8

SERVICE MANUAL

Ver 1.0 2003. 09
HCD-SC5/SC6/SC8 are the amplifier, DVD/
SACD and tuner section in DAV-SC5/SC6/SC8.
Amplifier section
Stereo mode
90 W + 90 W (4 ohms at
1 kHz, THD 10 %)
(HCD-SC5)
100 W + 100 W (4 ohms
at 1 kHz, THD 10 %)
(HCD-SC6/SC8)
90
Surround mode
Front:
W +
(HCD-SC5)
100 W + 100 W
(HCD-SC6/SC8)
Centre*:
90
W
100 W
(HCD-SC6/SC8)
Surround*:
90
(4 ohms at 1 kHz, THD
10 %)
(HCD-SC5)
100 W + 100 W (4 ohms
at 1 kHz, THD 10 %)
(HCD-SC6/SC8)
100
Subwoofer*:
(4 ohms at 100 Hz, THD
10 %)
(HCD-SC5/SC6)
* Depending on the sound field settings and the source,
there may be no sound output.
Inputs
VIDEO 1/VIDEO 2/TV:
Sensitivity: 150 mV
Impedance: 50 kilohms
(AEP, UK and Russian
models)
VIDEO 1:
Sensitivity: 150 mV
Impedance: 50 kilohms
VIDEO 2:
Sensitivity: 300 mV
Impedance: 50 kilohms
(Other models)
Sony Corporation
9-961-137-01
2003I1678-1
Home Audio Company
© 2003.09
Published by Sony Engineering Corporation
PHOTO: HCD-SC5

SPECIFICATIONS

Outputs
Phones
Super Audio CD/DVD system
90
W
Laser
(HCD-SC5)
Signal format system
W +
90
W
Frequency response (at 2 CH STEREO mode)
Harmonic distortion
W
Tuner section
System
FM tuner section
Tuning range
Aerial
Aerial terminals
Intermediate frequency
AM tuner section
Tuning range
AEP, UK, Russian, Australian, Singapore and
Middle Easten models:
Model Name Using Similar Mechanism
Mechanism Type
Optical Pick-up Name
VIDEO 1 (AUDIO
Other models:
OUT):
Voltage: 1 V
Impedance: 1 kilohm
Aerial
Accepts low-and high-
impedance headphones.
Intermediate frequency
Vi
deo section (VIDEO 1, 2, EURO AV)
(AEP, UK and Russian models)
Semiconductor laser
Inputs
(Super Audio CD/DVD: λ
Outputs
= 650 nm)
(CD: λ = 780 nm)
Video section (Other models)
Emission duration:
Inputs Video:
continuous
Outputs Video:
NTSC or NTSC/PAL
DVD (PCM): 2 Hz to 22
kHz (±1.0 dB)
CD: 2 Hz to 20 kHz (±1.0
dB)
Less than 0.03 %
General
Power requirements
PLL quartz-locked digital
European models:
synthesizer system
Australian and Asian models:
87.5 – 108.0 MHz (50 kHz
Taiwan models:
step)
Other models:
FM wire aerial
Dimensions (approx.)
75 ohms, unbalanced
10.7 MHz
Mass (approx.)
Operating temperature
Operating humidity
531 – 1,602 kHz (with the
Design and specification are subject to change without
interval set at 9 kHz)
notice.
SACD/DVD RECEIVER
AEP Model
UK Model
E Model
HCD-SC5/SC6/SC8
Australian Model
HCD-SC6/SC8
NEW
CDM80-DVBU24
TDP022W
531 – 1,602 kHz (with the
interval set at 9 kHz)
530 – 1,710 kHz (with the
interval set at 10 kHz)
AM loop aerial
450 kHz
Video: 1 Vp-p 75 ohms
Video: 1 Vp-p 75 ohms
1 Vp-p 75 ohms
1 Vp-p 75 ohms
S video:
Y: 1 Vp-p 75 ohms
C: 0.286 Vp-p 75 ohms
COMPONENT:
Y: 1 Vp-p 75 ohms
P
/C
, P
/C
: 0.7 Vp-p
B
B
R
R
75 ohms
230 V AC, 50/60 Hz
220 – 240 V AC, 50/60 Hz
120 V AC, 50/60 Hz
110 – 120 V AC, 50/60 Hz
380 × 60 × 337 mm (w/h/d)
incl. projecting parts
4.2 kg
5°C to 35°C (41°F to 95°F)
5 % to 90 %

Advertisement

Table of Contents

   Related Manuals for Sony HCD-SC5

   Summary of Contents for Sony HCD-SC5

  • Page 1: Service Manual

    AEP Model UK Model Ver 1.0 2003. 09 E Model HCD-SC5/SC6/SC8 Australian Model HCD-SC6/SC8 PHOTO: HCD-SC5 HCD-SC5/SC6/SC8 are the amplifier, DVD/ SACD and tuner section in DAV-SC5/SC6/SC8. Model Name Using Similar Mechanism Mechanism Type CDM80-DVBU24 Optical Pick-up Name TDP022W SPECIFICATIONS...
  • Page 2 COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
  • Page 3: Table Of Contents

    HCD-SC5/SC6/SC8 TABLE OF CONTENTS 1. SERVICING NOTE 6-18. SCHEMATIC DIAGRAM ·························································· 4 – DVD SECTION (10/10) – ········································ 51 6-19. PRINTED WIRING BOARD 2. GENERAL ·········································································· 5 – AMP SECTION (SIDE A) – ···································· 52 6-20. PRINTED WIRING BOARD 3. DISASSEMBLY ································································...
  • Page 4: Servicing Note

    HCD-SC5/SC6/SC8 SECTION 1 SERVICING NOTE MODEL IDENTIFICATION NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK — BACK PANEL — OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc.
  • Page 5: General

    HCD-SC5/SC6/SC8 SECTION 2 GENERAL This section is extracted from instruction manual. Front Panel A Disc slot (22) I PHONES (on the side of the system) jack (22) B A (eject) (22) J SOUND FIELD –/+ (43, 44, 45) C H (play) (22)
  • Page 6 HCD-SC5/SC6/SC8 Rear Pan HCD-SC5/SC6 (AEP, UK and Russian models) SPEAKER VIDEO 2 VIDEO 1 VIDEO 2 FM 75 FRONT R CENTER FRONT L AUDIO OUT VIDEO OUT AUDIO IN VIDEO IN EURO AV COAXIAL SURR R WOOFER SURR L OPTICAL...
  • Page 7 HCD-SC5/SC6/SC8 ar Panel HCD-SC8 (AEP, UK and Russian models) SPEAKER VIDEO 2 VIDEO 1 VIDEO 2 FM 75 FRONT R CENTER FRONT L AUDIO OUT VIDEO OUT AUDIO IN VIDEO IN WOOFER EURO AV AUDIO COAXIAL SURR R SURR L...
  • Page 8 HCD-SC5/SC6/SC8 G PLAY MODE (30, 31) Remote H CLEAR (30, 31, 32, 34) I TV (54) J AUDIO (41) K ANGLE (47) L SUBTITLE (48) M ./>, PREV/NEXT, PRESET –/+ (23, 25, 56, 57) N H (play) (22, 25, 30, 31, 32) O X (pause) (23) P DVD TOP MENU/ALBUM–...
  • Page 9: Disassembly

    HCD-SC5/SC6/SC8 SECTION 3 DISASSEMBLY The equipment can be removed using the following procedure. FRONT PANEL SECTION, SIDE PANEL (L / R) SECTION CD MECHANISM DECK DDCON BOARD, POWER BOARD I/O BOARD (CDM80-DVBU24) FL BOARD PLAY BUTTON, SCART BOARD, AMP BOARD...
  • Page 10: Side Panel (l/r) Section

    HCD-SC5/SC6/SC8 Note: Follow the disassembly procedure in the numerical order given. 3-1. FRONT PANEL SECTION, SIDE PANEL (L/R) SECTION front panel section 6 two screws (+BVTP 3 2 four screws (+BVTP 3 8 side panel (L) 1 three screws (+BVTP 3...
  • Page 11: Ddcon Board, Fl Board

    HCD-SC5/SC6/SC8 3-2. DDCON BOARD, FL BOARD qg panel top (R) qd band button qs panel top (L) 2 wire (flat type) (CN815) q; FL board qf four screws (DIA. 2.6 qh front (ml) panel qa three screws (DIA. 2.6 9 four screws (DIA.
  • Page 12: Power Board

    HCD-SC5/SC6/SC8 3-4. POWER BOARD 1 connector (CN903) 4 screw (+BV SUMITITE B3) power sheet 6 two screws (+BV SUMITITE B3) 2 connector (CN904) 7 screw 3 connector (CN902) (+BV SUMITITE B3) 9 POWER board power sheet 3-5. I/O BOARD 8 tuner unit...
  • Page 13: Scart Board, Dvd Board

    HCD-SC5/SC6/SC8 3-6. SCART BOARD, DVD BOARD 3 four screws 2 SCART board (+BV SUMITITE B3) (used only for AEP,UK and Russian models) 5 heat sink DVD 4 ferrite core 8 wire (flat type) (CN003) qd connector 9 wire (flat type)
  • Page 14: Cd Mechanism Deck (cdm80-dvbu24)

    HCD-SC5/SC6/SC8 3-8. CD MECHANISM DECK (CDM80-DVBU24) 3 connector (CN701) 2 wire (flat type) (CN401) 5 connector (CN900) 7 two screws (+BVTP 3 mechanism deck (CDM80-DVBU24) 8 LF board qa two screws 6 connector (+BV SUMITITE B3) 9 sheet (CN901) qd MD cover q;...
  • Page 15: Lever (loading R/l)

    HCD-SC5/SC6/SC8 3-10. LEVER (LOADING R/L) spr-T (loading L) spr-T (loading R) 5 lever (loading R) 2 two hooks 4 two hooks 3 lever (loading L) PRECAUTION DURING LEVER (LOADING R / L) INSTALLATION Align the horizontal position. lever (loading L)
  • Page 16: Disc Stop Lever, Disc Sensor Lever

    HCD-SC5/SC6/SC8 3-11. DISC STOP LEVER, DISC SENSOR LEVER 1 gear (cap) 2 gear (IDL L) PRECAUTION DURING DISC STOP LEVER INSTALLATION chassis (top) hole 5 two hooks 3 two claws disc stop lever 6 disc stop lever hole Install the disc stop lever so that the both holes are aligned.
  • Page 17: Rf Board

    HCD-SC5/SC6/SC8 3-13. RF BOARD 5 RF board 4 wire (flat type) (CN002) 2 wire (flat type) (CN003) 3 wire (flat type) (CN001) 1 claw 3-14. OPTICAL PICK-UP (TDP022W) 3 two insulators 1 two step screws (M) 5 optical pick-up (TDP022W)
  • Page 18: Base Unit

    HCD-SC5/SC6/SC8 3-15. BASE UNIT 4 floating screw (+PTPWHM 2.6) 6 base unit 3 holder down spring 5 floating screw (+PTPWHM 2.6) 2 lever (CL UP2) 1 screw (+BVTP 2.6 3-16. LEVER (BU LOCK) 4 lever (BU lock) 3 three hooks...
  • Page 19: Close Lever

    HCD-SC5/SC6/SC8 3-17. CLOSE LEVER 1 washer (3-1-0.4) 5 close lever 3 claw 2 close lever spring 4 shaft disc stop 3-18. DIR LEVER, GEAR (IDL-B) 2 claw 3 gear puley 4 gear (cap) 5 gear (IDL-A) 8 stoper 9 DIR lever q;...
  • Page 20: Gear (idl-c)

    HCD-SC5/SC6/SC8 3-19. GEAR (IDL-C) 3 gear (IDL-D) 4 three hooks 2 two claws 1 gear (IDL-F) 5 gear loading lever 7 gear (IDL-C) 6 claw...
  • Page 21: Test Mode

    HCD-SC5/SC6/SC8 SECTION 4 TEST MODE [Version Display Mode] [OSD Test Mode] * The software version is displayed. Procedure: Procedure: Press the ?/1 button on the main unit or the ?/1 button on Press three buttons of [FUNCTION], x and A simultaneously the remote commander to turn the set on.
  • Page 22 HCD-SC5/SC6/SC8 [GENERAL DESCRIPTION] 0-1. All (All items continuous check) This menu checks all diagnostic items continuously. Normally, all The Test Mode allows you to make diagnosis and adjustment easily items are checked successively one after another automatically using the remote commander and monitor TV. The instructions, unless an error is found, but at a certain item that requires judgment diagnostic results, etc.
  • Page 23 HCD-SC5/SC6/SC8 0-2-4. Model Type 1-1. DVD-SL (single layer) Press the 1 key on the remote commander and insert a DVD single Model name is displayed. (DAV-SCX) layer disc following the message. Then the adjustment will be made 0-2-5. Region through the steps below, then adjusted values will be written to the Model destination code is displayed.
  • Page 24 HCD-SC5/SC6/SC8 24. Auto track gain adjust DRIVE MANUAL OPERATION Search Check Note: This mode is used for design, and not used in service fundamen- 25. 32Tj forward tally. 26. 32Tj reverse On the Test Mode Menu screen, press the key on the remote 27.
  • Page 25 HCD-SC5/SC6/SC8 2-1. Disc Type 2-1-3. Disc Type CD It sets up so that it may judge as a disc type of specification of the disc with which the set was inserted. Disc Type : CD disc (normal speed, 12 cm)
  • Page 26 HCD-SC5/SC6/SC8 2-3. Track/Layer Jump 2-5. EEPROM Write Adjust Track/Layer Jump EEPROM Write Adjust FWD R.Lj L0>L1 REV L.Lj L1>L0 1. Focus Offset 3.500Tj Fine FWD U.Fj L0>L1 2. Focus Gain 4.500Tj Fine REV D.Fj L1>L0 3. Trk. Offset Coarse 5.10kTj Dirc 4.
  • Page 27 HCD-SC5/SC6/SC8 2-7. Disc Check Memory EMERGENCY HISTORY On the Test Mode Menu screen, selecting displays the Disc Check Memory information such as servo emergency history. The history information from last 1 up to 10 can be scrolled with 1. SL Disc check the O key or o key.
  • Page 28 HCD-SC5/SC6/SC8 MECHA ERROR HISTORY • Error code (bb) 00 : Initializing the mechanism deck. On the Test Mode Menu screen, selecting displays the information 10 : Retry over of eject and loading. of mechanism deck error history. 30 : Open operation in no disc status.
  • Page 29: Electrical Adjustment

    HCD-SC5/SC6/SC8 SECTION 5 ELECTRICAL ADJUSTMENT [TEST DISC LIST] Use the following test disc on test mode. TDV-520CSO (DVD-SL): PART No. J-2501-236-A LUV-P01 (CD): PART No. 4-999-032-01 TDV-540C (DVD-DL): PART No. J-2501-235-A Note: Do not use exiting test disc for DVD.
  • Page 30: Diagrams

    HCD-SC5/SC6/SC8 SECTION 6 DIAGRAMS 6-1. CIRCUIT BOARDS LOCATION DRIVER board RF board POWER LED board FL board DDCON board SCART board (only for AEP, UK and Russian models) DVD board I/O board LF board AMP board POWER board HP board...
  • Page 31 HCD-SC5/SC6/SC8 THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) For schematic diagrams. For printed wiring boards. Note: Note: • All capacitors are in µF unless otherwise noted. pF: µµF •...
  • Page 32: Block Diagrams - Rf/servo Section

    HCD-SC5/SC6/SC8 6-2. BLOCK DIAGRAMS – RF/SERVO SECTION – • SIGNAL PATH WARFI AUDIO(DSP) : AUDIO SECTION : CD CDDOUT AUDIO(DSP) : DVD : VIDEO SECTION : SACD 117 RFIN SD0 – SD7 (for AUDIO SYSTEM) AUDIO(DSP) AV DATA BUS DOUT...
  • Page 33: Audio (dsp) Section

    HCD-SC5/SC6/SC8 – AUDIO (DSP) SECTION – IC402 (2/2) REFERENCE VOLTAGE GENERATOR 127 WAVRB WARFI D1 – D4, SCK, RF/SERVO 39 DSIFL 126 WARFI DSAL BCKO, LRCKO SECTION AUDIO OUT SDO4 SECTION RF/SERVO DSAR 40 DSIFR 123 WCK 18 SDI1 SECTION...
  • Page 34: Audio Out Section

    HCD-SC5/SC6/SC8 – AUDIO OUT SECTION – IC301 STREAM PROCESSOR IC608 D/A CONVERTER J900 • SIGNAL PATH HPOUTL1 PHONES HPOUTL2 IC305 3 SDTI AOUTL+ : AUDIO J205 (2/4) HEADPHONE AOUTL– IC610 Q902 VIDEO 1 HPOUTR1 Q900, 901 1 MCLK LOW-PASS MUTING...
  • Page 35: Video Section

    HCD-SC5/SC6/SC8 – VIDEO SECTION – J205 (3/4) VIDEO 1 VIDEO IN IC207 J206 (2/3) VIDEO INPUT SELECTOR VIDEO 2 IC209 VIDEO IN VIDEO SELECTOR J205 (4/4) 1 IN1 IC206 VIDEO 1 3 IN2 14 2B OUT2 VIDEO OUT 75 DRIVER...
  • Page 36: Power Supply Section

    HCD-SC5/SC6/SC8 – POWER SUPPLY SECTION – T801 DC-DC CONVERTER FL58 TO FLUORESCENT INDICATOR TUBE D806 – 809 RECT Q803, 804 IC308 STREAM PROCESSOR +1.8V +1.8V REGULATOR IC307 STREAM PROCESSOR +3.3V +3.3V REGULATOR IC306 POWER DRIVER REGULATOR IC605 DSP +2.6V +2.6V...
  • Page 37: Printed Wiring Board - Rf Section

    HCD-SC5/SC6/SC8 6-3. PRINTED WIRING BOARD – RF SECTION – • See page 30 for Circuit Boards Location. • : Uses unleaded solder. RF BOARD RF BOARD (SIDE A) (SIDE B) FLEXIBLE BOARD OPTICAL PICK-UP BLOCK (TDP022W) IC001 DVD BOARD CN401...
  • Page 38: Schematic Diagram - Rf Section

    HCD-SC5/SC6/SC8 6-4. SCHEMATIC DIAGRAM – RF SECTION – • See page 63 for Waveforms. • See page 72 for IC Block Diagram. RFMON C006 C028 C027 R026 C013 C031 1000p CN002 C030 0.01 C026 AGND C025 R023 C029 RFAC 0.01...
  • Page 39: Driver Section

    HCD-SC5/SC6/SC8 6-5. PRINTED WIRING BOARD – DRIVER SECTION – • See page 30 for Circuit Boards Location. 6-6. SCHEMATIC DIAGRAM – DRIVER SECTION – • See page 65 for IC Block Diagram. • : Uses unleaded solder. S703 S701 S702...
  • Page 40: Dvd Section (side A)

    HCD-SC5/SC6/SC8 6-7. PRINTED WIRING BOARD – DVD SECTION (SIDE A) – • See page 30 for Circuit Boards Location. • : Uses unleaded solder. • Semiconductor Location Ref. No. Location D900 DRIVER BOARD D901 CN701 (Page 39) IC206 IC301 IC401...
  • Page 41: Dvd Section (side B)

    HCD-SC5/SC6/SC8 6-8. PRINTED WIRING BOARD – DVD SECTION (SIDE B) – • See page 30 for Circuit Boards Location. • : Uses unleaded solder. • Semiconductor Location Ref. No. Location D902 D903 D904 D906 D907 IC001 IC002 IC900 IC003 IC808...
  • Page 42: Dvd Section (1/10)

    HCD-SC5/SC6/SC8 6-9. SCHEMATIC DIAGRAM – DVD SECTION (1/10) – • See page 66 for IC Block Diagram. C403 FL401 C401 C402 CN401 R411 TO RF AMP R412 JL544 C404 R413 JL537 C405 JL536 10 16V R418 R419 R451 JL535 R415...
  • Page 43: Dvd Section (2/10)

    HCD-SC5/SC6/SC8 6-10. SCHEMATIC DIAGRAM – DVD SECTION (2/10) – C526 R581 C527 R582 R583 R580 C519 0.01 R579 8.2k IC501 FAN8035 R534 R535 R533 C514 0.01 R532 R530 R531 R529 C512 0.01 R528 R525 R527 2.2k C510 0.001 R524 R522 R521 4.7k...
  • Page 44: Dvd Section (3/10)

    HCD-SC5/SC6/SC8 6-11. SCHEMATIC DIAGRAM – DVD SECTION (3/10) – • See page 68 for IC Block Diagram. R729 C715 TP701 8.2k 0.0015 IC703(2/2) C703 NJM3404AV(TE2) TP702 IC706 R544 R540 MSM51V18165F- R545 100k 100k 60TSKR1 R725 1.8k R726 C523 0.0015 100k...
  • Page 45: Dvd Section (4/10)

    HCD-SC5/SC6/SC8 6-12. SCHEMATIC DIAGRAM – DVD SECTION (4/10) – • See page 69 for IC Block Diagrams. C870 33000p R803 IC702 C795 TA48M025F(TE16L) IC808 6.3V MSM56V16160F-8TK C796 C797 FL810 FL811 CHIP EMI FILTER C840 C843 C854 0.01 0.01 R804 C866 R852 0.01...
  • Page 46: Dvd Section (5/10)

    HCD-SC5/SC6/SC8 6-13. SCHEMATIC DIAGRAM – DVD SECTION (5/10) – • See page 63 for Waveforms. • See page 68 for IC Block Diagram. C303 0.01 FL301 Q301 DTC114EKA -T146 C301 C302 0.01 FL304 IC302 BR24L16F-WE2 IC802 TC7S32FU(TE85R) C320 0.01 R352...
  • Page 47: Dvd Section (6/10)

    HCD-SC5/SC6/SC8 6-14. SCHEMATIC DIAGRAM – DVD SECTION (6/10) – • See page 63 for Waveforms. • See page 65 for IC Block Diagram. CN003 TP023 R013 TP024 R015 TP025 FB004 I/O BOARD (2/2) TP026 R036 R257 TP027 R039 TP028 R041...
  • Page 48: Dvd Section (7/10)

    HCD-SC5/SC6/SC8 6-15. SCHEMATIC DIAGRAM – DVD SECTION (7/10) – • See page 65 for IC Block Diagram. IC202 HY57V283220T-6 C217 0.01 C219 0.01 C226 0.01 C234 0.01 C238 0.01 C274 0.01 IC215 SN74ALV CH16841DGGR C239 0.01 R251 C314 0.01 C356 0.01...
  • Page 49: Dvd Section (8/10)

    HCD-SC5/SC6/SC8 6-16. SCHEMATIC DIAGRAM – DVD SECTION (8/10) – • See page 63 for Waveforms. • See page 66, 67, 68 for IC Block Diagrams. IC600 IC601 NJM78M05DL1A -TE1 R600 C603 C600 C601 R687 C608 C605 R681 C602 C607 R608 3.3k...
  • Page 50: Dvd Section (9/10)

    HCD-SC5/SC6/SC8 6-17. SCHEMATIC DIAGRAM – DVD SECTION (9/10) – • See page 63 for Waveforms. • See page 69 for IC Block Diagram. CN900 FB901 Q908 DTC124EKA R992 C900 -T146 Q903 Q909 2SC2712-GL -TE85L DTC124EKA -T146 Q910 DTC124EKA R900 -T146...
  • Page 51: Dvd Section (10/10)

    HCD-SC5/SC6/SC8 6-18. SCHEMATIC DIAGRAM – DVD SECTION (10/10) – IC006 C018 C020 C019 IC004 IC005 C015 C014 C016 C017 IC003 C012 C013 FL003 FB008 FB007 C006 47 16V FL004 C005 FB010 FB009 IC002 FL005 IC001 220 4V CHIP EMI CN008...
  • Page 52: Amp Section (side A)

    HCD-SC5/SC6/SC8 6-19. PRINTED WIRING BOARD – AMP SECTION (SIDE A) – • See page 30 for Circuit Boards Location. • : Uses unleaded solder. • Semiconductor Location C403 Ref. No. Location Q403 D402 R413 C404 R411 D121 R409 R410 D401...
  • Page 53: Amp Section (side B)

    HCD-SC5/SC6/SC8 6-20. PRINTED WIRING BOARD – AMP SECTION (SIDE B) – • See page 30 for Circuit Boards Location. • : Uses unleaded solder. • Semiconductor Location Ref. No. Location SPEAKER D101 FRONT R CEINTER FRONT L WOOFER D102 D103...
  • Page 54: Schematic Diagram

    HCD-SC5/SC6/SC8 6-21. SCHEMATIC DIAGRAM – AMP SECTION (1/2) – • See page 64 for Waveforms. • See page 65 for IC Block Diagram. L901 C991 0.047 R991 L903 R902 Q900 CN304 CN303 CN301 DTC343TK CN302 CNP301 -T-146 C904 R903 0.01 4.7k...
  • Page 55: Amp Section (2/2)

    HCD-SC5/SC6/SC8 6-22. SCHEMATIC DIAGRAM – AMP SECTION (2/2) – R384 IC106 CXD9750L IC105 CXD9750L IC104 CXD9750L IC103 CXD9750L C104 C103 C102 IC102 CXD9750L IC101 CXD9750L C106 C105 C101 0.01 0.01 0.01 0.01 0.01 0.01 C215 D105 C214 D104 D102 D101...
  • Page 56: I/o Section

    HCD-SC5/SC6/SC8 6-23. PRINTED WIRING BOARD – I/O SECTION – • See page 30 for Circuit Boards Location. • : Uses unleaded solder. • Semiconductor Location Ref. No. Location D103 D201 D202 D203 D206 IC201 IC202 IC204 IC206 IC207 IC208 IC209...
  • Page 57: I/o Section

    HCD-SC5/SC6/SC8 6-24. SCHEMATIC DIAGRAM – I/O SECTION (1/2) – • See page 64 for Waveforms. • See page 70 for IC Block Diagram. CN201 C201 330p R201 4.7k Q201 2SC2412K-T-146 R206 C213 470k R203 R204 R202 D203 D202 R205 C203...
  • Page 58: I/o Section (1/2)

    HCD-SC5/SC6/SC8 6-25. SCHEMATIC DIAGRAM – I/O SECTION (2/2) – • See page 64 for Waveforms. • See page 70, 71 for IC Block Diagrams. L209 L207 J202 IC208 MM1568AJBE C284 C288 C285 R269 CN203 C287 C265 L212 R267 C281 C276...
  • Page 59: Front Panel Section

    HCD-SC5/SC6/SC8 6-26. PRINTED WIRING BOARD – FRONT PANEL SECTION – • See page 30 for Circuit Boards Location. • : Uses unleaded solder. • Semiconductor Location Ref. No. Location D806 D807 D808 D809 D810 D812 IC801 IC802 Q803 D-10 IC802...
  • Page 60: Front Panel Section

    HCD-SC5/SC6/SC8 6-27. SCHEMATIC DIAGRAM – FRONT PANEL SECTION – • See page 64 for Waveforms. • See page 70 for IC Block Diagram. D812 SLR325VR-T31 R844 4.7k R837 2.2k R804 R873 1.5k CNP809 FL801 S826 FLUORESCENT INDICATOR TUBE R805 R803 1.5k...
  • Page 61: Power Section

    HCD-SC5/SC6/SC8 6-28. PRINTED WIRING BOARD – POWER SECTION – • See page 30 for Circuit Boards Location. • : Uses unleaded solder. • Semiconductor BOARD BOARD Location CN301 CN008 (Page 53) (Page 40) Ref. No. Location IC902 D902 D904 D905...
  • Page 62: Power Section

    HCD-SC5/SC6/SC8 6-29. SCHEMATIC DIAGRAM – POWER SECTION – • See page 71 for IC Block Diagram. LF901 EXCEPT MX,TW CN900 CN901 R930 3.3M C903 250V CN904 D911 FML-22S T901 C920 L901 IC908 C918 SI-8120JF R919 R920 4.7k R917 C926 L904...
  • Page 63 HCD-SC5/SC6/SC8 • Waveforms – RF BOARD – IC001 r; (FE) IC001 tj (RFAC) IC001 1 (DVDRFP) IC001 el (TE) 0.3 Vp-p 0.5 Vp-p 800m Vp-p 1.3 Vp-p 100m V/DIV, 1 ms/DIV 500m V/DIV, 100 ns/DIV 200m V/DIV, 100 ns/DIV 500m V/DIV, 1 ms/DIV –...
  • Page 64 HCD-SC5/SC6/SC8 – DDCOM BOARD – – AMP BOARD – Q803 collector IC304 4 IC301, 302, 303 2 (OUTL1) 4.2 Vp-p 25.2 Vp-p 3.4 Vp-p 9.1 µ s 2.6 µ s 20.3ns µ 10 V/DIV, 4 µ s/DIV 1 V/DIV, 10 ns/DIV...
  • Page 65: Ic Block Diagrams

    HCD-SC5/SC6/SC8 6-30. IC BLOCK DIAGRAMS – AMP BOARD – IC305 NJM4580E (TE2) A OUT B OUT A –IN A +IN B –IN B +IN V– – DRIVER BOARD – IC701 BA6956AN IC215 SN74ALVCH16841DGGR 56 1LE CONTROL LOGIC LATCH – DVD BOARD –...
  • Page 66 HCD-SC5/SC6/SC8 IC401 CXD3068Q 60 59 58 55 54 53 52 50 49 48 46 45 44 43 42 41 DVDD2 ASYE TES1 DOUT TEST DVSS1 LRCK PCMD FRDR BCLK FFDR EMPH TRDR TFDR XTSL DVSS2 SRDR XTAI SFDR XTAO DVDD1...
  • Page 67 HCD-SC5/SC6/SC8 IC604 IS61LV6416-10TLT ROW/COLUMN DECODER OUTPUT ENABLE BUFFER 64K x 16 BYTE ENABLE MEMORY CHIP ENABLE BUFFER ARRAY BUFFER I/O 15 I/O 0 I/O 14 I/O 1 I/O 13 I/O 2 I/O 12 I/O 3 I/O 11 I/O 4 I/O 10...
  • Page 68 HCD-SC5/SC6/SC8 IC608 AK4382AVT-E2 DZFL CLOCK DE–EMPHASIS MCLK DZFR DIVIDER CONTROL ∆∑ AOUTL+ INTERPOLATOR MODULATOR BICK AOUTL– AUDIO SDTI DATA INTERFACE ∆∑ AOUTR+ LRCK INTERPOLATOR MODULATOR AOUTR– µP CCLK INTERFACE CDTI IC706 MSM51V18165F-60TSKR1 40 – 36 34 33 REFRESH INTERNAL TIMING...
  • Page 69 HCD-SC5/SC6/SC8 IC808 MSM56V16160F-8TK7R1 35 34 TIMING REGISTER PROGRAMING OUTPUT REGISTER BUFFERS LATENCY INTERNAL INTERNAL COLUMN & COLUMN READ ADDRESS ADDRESS BURST ADDRESS ADDRESS DATA BUFFERS BUFFERS CONTROLLER COUNTOR COUNTOR REGISTER CONTROLLER INPUT DATA SENSE COLUMN REGISTER AMPLIFIER DECODERS BANK INPUT...
  • Page 70 HCD-SC5/SC6/SC8 – FL BOARD – IC802 MSM9202-05GS-KDR1 Timing Timing Generator 2 Generator 1 64 VDD Duty Control 63 DAT Digit 8bit Control Shift 62 CLK Register 61 CS Port Control Driver Circuit 60 RST Command Decoder 59 OSC1 Read Write...
  • Page 71 HCD-SC5/SC6/SC8 IC208 MM1568AJBE VCC1 VCC2 BIAS 75Ω COUT DRIVER MUTE1 CLAMP GND2 75Ω VOUT DRIVER YC MIX VSAG CLAMP GND2 75Ω YOUT DRIVER BIAS BIAS YSAG GND1 GND1 10 NC 11 GND2 CYIN 12 75Ω CYOUT DRIVER CLP 13 CYSAG...
  • Page 72 HCD-SC5/SC6/SC8 – RF BOARD – IC001 CXD1881AR 64 63 62 61 60 59 55 54 53 52 FAST ATTACK INPUT OUTPUT HOLD FULL WAVE AGC CHARGE INHIBIT RECTIFER PUMP PROGRAMMABLE FROM S-PORT INPUT EQUALIZER DVDRFP FILTER BIAS DVDRFN DIFFERENTIATOR INPUT...
  • Page 73: Ic Pin Function Description

    HCD-SC5/SC6/SC8 6-31. IC PIN FUNCTION DESCRIPTION • DVD BOARD IC206 ZIVA5X-C1F (DVD SYSTEM PROCESSOR) Pin No. Pin Name Description VDDP — Power supply terminal (+3.3V) (I/O signal) Address bus HD15 Data bus (address signal multiplexed) HD14 Data bus (address signal multiplexed)
  • Page 74 HCD-SC5/SC6/SC8 Pin No. Pin Name Description MRAS SDRAM row address strobe signal output MCAS SDRAM column address strobe signal output SDRAM write enable signal output (“H” : read, “L” : write) GND25 — Ground terminal (SDRAM I/O signal) VDD25 —...
  • Page 75 HCD-SC5/SC6/SC8 Pin No. Pin Name Description MD30 SDRAM data MD31 SDRAM data GND25 — Ground terminal (SDRAM I/O signal) VDD25 — Power supply terminal (+3.3V) (SDRAM I/O signal) VCLK System clock (not used) I2C_CTRL — Not used S1 signal output...
  • Page 76 HCD-SC5/SC6/SC8 Pin No. Pin Name Description GPIO4 (2) — Not used (pull-up) VDDP — Power supply terminal (+3.3V) (I/O signal) GNDP — Ground terminal (I/O signal) GPIO4 (3) — Not used (pull-down) GPIO4 (4) — Not used (pull-down) IEC958 S/PDIF signal...
  • Page 77 HCD-SC5/SC6/SC8 Pin No. Pin Name Description TCK signal input RESET ZIVA reset input BUS CLK Not used — Ground terminal (inside core) — Power supply terminal (+1.8V) (inside core) Address bus 3 Address bus 2 GNDP — Ground terminal (I/O signal)
  • Page 78 HCD-SC5/SC6/SC8 • DVD BOARD IC301 CXP973064-228R (MACHANISH CONTROLLER) Pin No. Pin Name Description EEP SO Not used SDEN Serial data enable signal output to DVD/CD RF amplifier DOCTRL/ Digital out on/off control signal output to the digital signal processor ISBTEST “L”: digital out off, “H”: digital out on...
  • Page 79 HCD-SC5/SC6/SC8 Pin No. Pin Name Description SQSO Subcode Q data input from the digital signal processor MUTE DSD Muting on/off control signal output to the DSD decoder “H”: muting on SQCK Subcode Q data reading clock signal output to the digital signal processor —...
  • Page 80 HCD-SC5/SC6/SC8 • DVD BOARD IC401 CXD3068Q (DIGITAL SIGNAL PROCESSOR, DIGITAL SERVO PROCESSOR) Pin No. Pin Name Description DVDD0 — Power supply terminal (+3.3V) (digital system) XRST Reset signal input from the mechanism controller “L”: reset MUTE Muting on/off control signal input from the mechanism controller “H”: muting on...
  • Page 81 HCD-SC5/SC6/SC8 Pin No. Pin Name Description AVDD0 — Power supply terminal (+3.3V) (analog system) ASYO EFM full-swing output terminal ASYI Asymmetry comparator voltage input terminal RFAC EFM signal input from the DVD/CD RF amplifier AVSS1 — Ground terminal (analog system)
  • Page 82 HCD-SC5/SC6/SC8 • DVD BOARD IC607 CXD9617R (AUDIO DIGITAL SIGNAL PROCESSOR) Pin No. Pin Name Description — Ground terminal XRST Reset signal input from the system controller “L”: reset EXTIN Master clock signal input terminal Not used Sampling frequency selection signal input terminal Not used VDDI —...
  • Page 83 HCD-SC5/SC6/SC8 Pin No. Pin Name Description VDDE — Power supply terminal (+3.3V) WMD1 S-RAM wait mode setting terminal Fixed at “H” in this set — Ground terminal WMD0 S-RAM wait mode setting terminal Fixed at “H ” in this set...
  • Page 84 HCD-SC5/SC6/SC8 Pin No. Pin Name Description SDI3 Rear L-ch and R-ch audio serial data input from the digital audio processor SDI4 Audio serial data input terminal Not used Synchronous/asychronous selection signal input terminal SYNC “L”: Synchronous, “H”: asynchronous (fixed at “H” in this set) 117 to 119 —...
  • Page 85 HCD-SC5/SC6/SC8 • DVD BOARD IC701 TMC57929PGF-RDP (DVD DECODER) Pin No. Pin Name Description 1, 2 D5, D6 Two-way data bus with the mechanism controller — Ground terminal (digital system) Two-way data bus with the mechanism controller Address signal input from the mechanism controller —...
  • Page 86 HCD-SC5/SC6/SC8 Pin No. Pin Name Description DVD mode: Serial data request signal input from the DVD system processor XHAC SACD mode: Serial data request signal input from the DSD decoder HINT Not used XS16 Not used Not used XPDI Not used VDDS —...
  • Page 87 HCD-SC5/SC6/SC8 Pin No. Pin Name Description RFDCC Input terminal for adjusting DC cut high-pass filter for RF signal Not used RFIN RF signal input from the DVD/CD RF amplifier 118, 119 VCCA5, VCCA4 — Power supply terminal (+3.3V) (analog system) VCOR1 —...
  • Page 88 HCD-SC5/SC6/SC8 Pin No. Pin Name Description XTAL 33.8688 MHz clock signal input terminal — Ground terminal (digital system) XTL2 System clock output terminal (33.8688 MHz) XTL1 System clock input terminal (33.8688 MHz) — Power supply terminal (+3.3V) (digital system) 172 to 176...
  • Page 89 HCD-SC5/SC6/SC8 • DVD BOARD IC801 CXD2753R (DSD DECODER) Pin No. Pin Name Description VSCA0 — Ground terminal (for core) XMSLAT Serial data latch pulse signal input from the mechanism controller MSCK Serial data transfer clock signal input from the mechanism controller...
  • Page 90 HCD-SC5/SC6/SC8 Pin No. Pin Name Description PHREFI Bit clock signal (2.8224 MHz) input terminal for DSD data output Not used PHREFO Bit clock signal (2.8224 MHz) output to the digital audio processor Not used ZDFL Front L-ch Zero data flag detection signal output terminal Not used...
  • Page 91 HCD-SC5/SC6/SC8 Pin No. Pin Name Description WRFD Not used Operation clock signal input for PSP physical disc mark detection from the DVD decoder WAVDD0, 124, 125 — A/D power supply terminal (+2.5V) (for PSP physical disc mark detection) WAVDD1 WARFI...
  • Page 92 HCD-SC5/SC6/SC8 • IC901 PD703033BYGF-M40-3BA-A (SYSTEM CONTROLLER) Pin No. Pin Name Description DAMP-DATA Serial data output to the stream processors DAMP-CLK Serial data transfer clock signal output to the stream processors I2C-DATA Communication data bus with the DVD system processor and mechanism controller CQ-RST Reset signal output to the DVD system processor “L”: reset...
  • Page 93 HCD-SC5/SC6/SC8 Pin No. Pin Name Description PROG SW SCAN SELECT switch input terminal “L”: SELECTABLE, “H”: INTERLACE FM750 Power supply for tuner pack on/off control signal output TUNED Tuning detection signal input from the tuner unit “L”: tuned TUN-DI Serial data input from the tuner unit...
  • Page 94: Exploded Views

    HCD-SC5/SC6/SC8 SECTION 7 EXPLODED VIEWS NOTE: • Abbreviation : Singapore model • -XX, -X mean standardized parts, so they may : Australian model : Taiwan model have some difference from the original one. : 110-240V AC area in E model •...
  • Page 95: Front Panel Section

    HCD-SC5/SC6/SC8 7-2. FRONT PANEL SECTION not supplied not supplied not supplied FL801 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-248-573-01 PANEL TOP(R) 4-249-729-01 SLOT DISC X-4955-961-1 WINDOW SUB ASSY 4-249-732-01 COVER SLOT 4-248-572-01 PANEL TOP(L) (SC5)
  • Page 96: Chassis Section-1

    HCD-SC5/SC6/SC8 7-3. CHASSIS SECTION-1 EXCEPT AEP, UK, RU not supplied not supplied F901 not supplied not supplied not supplied chassis section-2 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-468-790-11 POWER SWITCHING (including Ref.No.201) 1-689-360-11 SCART BOARD (AEP,UK,RU)
  • Page 97: Chassis Section-2

    HCD-SC5/SC6/SC8 7-4. CHASSIS SECTION-2 not supplied supplied not supplied supplied not supplied not supplied not supplied not supplied chassis section-3 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4748-350-A DVD BOARD, COMPLETE (SC5:AEP,UK) A-4750-121-A DVD BOARD, COMPLETE (SC8:TW)
  • Page 98: Chassis Section-3

    HCD-SC5/SC6/SC8 7-5. CHASSIS SECTION-3 not supplied not supplied mechanism deck section-1 (CDM80-DVBU24) not supplied SC6:AEP,UK/SC8:AEP,UK F902 not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-468-790-11 POWER SWITCHING (including Ref.No.101) 4-248-579-01 MD COVER...
  • Page 99: (cdm80-dvbu24)

    HCD-SC5/SC6/SC8 7-6. MECHANISM DECK SECTION-1 (CDM80-DVBU24) CD mechanism section-2 (CDM80-DVBU24) M701 CD mechanism section-3 (CDM80-DVBU24) base unit section Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING 4-246-203-01 LEVER (RELEASE) 4-248-723-01 SPR-E, HOLDER DOWN...
  • Page 100: Mechanism Deck Section-2

    HCD-SC5/SC6/SC8 7-7. MECHANISM DECK SECTION-2 (CDM80-DVBU24) not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-245-627-01 WASHER (6-2.7-0.4) 4-245-640-01 GEAR (CAP) 4-245-637-01 ROLLER, RUBBER 4-245-626-01 CAP, CLAMPER DBU-1 4-245-649-01 GEAR (IDL-I) 4-245-638-01 LEVER (CL UP1) 4-245-657-01 LEVER (LOADING-R) 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING...
  • Page 101: Mechanism Deck Section-3

    HCD-SC5/SC6/SC8 7-8. MECHANISM DECK SECTION-3 (CDM80-DVBU24) supplied supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-245-643-01 GEAR (IDL-C) 4-245-640-01 GEAR (CAP) X-4955-497-1 CHASSIS (BOTTOM) ASSY 4-245-628-01 LEVER (BU LOCK) 4-248-722-01 SPR-E, DIR 4-248-206-01 WASHER (3-1-0.4)
  • Page 102: Base Unit Section

    HCD-SC5/SC6/SC8 7-9. BASE UNIT SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4728-690-A RF BOARD, COMPLETE 3-053-847-41 INSULATOR 0 605 1-685-250-11 PWB, FLEXIBLE 1-477-263-11 OPTICAL PICK-UP (TDP022W) 4-981-923-01 SCREW (M), STEP X-4955-484-1 HOLDER (BU) ASSY The components identified by mark 0 or dotted line with mark 0 are critical for safety.
  • Page 103: Electrical Parts List

    HCD-SC5/SC6/SC8 SECTION 8 ELECTRICAL PARTS LIST Note: • Due to standardization, replacements in the parts • CAPACITORS : Korean model list may be different from the parts specified in the uF : µ F : Mexican model diagrams or the components used on the set.
  • Page 104 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks C213 1-164-505-11 CERAMIC CHIP 2.2uF C314 1-164-156-11 CERAMIC CHIP 0.1uF (SC5/SC6) C214 1-164-505-11 CERAMIC CHIP 2.2uF C315 1-164-156-11 CERAMIC CHIP 0.1uF C215 1-164-505-11 CERAMIC CHIP 2.2uF C321 1-162-970-11 CERAMIC CHIP 0.01uF...
  • Page 105 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks D104 6-500-248-01 DIODE SFPL-62V IC305 8-759-385-17 IC NJM4580E(TE2) D105 6-500-248-01 DIODE SFPL-62V IC306 8-759-533-85 IC BA05FP-E2 IC307 8-759-460-72 IC BA033FP-E2 D106 6-500-248-01 DIODE SFPL-62V IC308 6-700-263-01 IC NJM2870F18(TE2)
  • Page 106 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks R122 1-216-845-11 METAL CHIP 100K 1/16W R360 1-216-837-11 METAL CHIP 1/16W R123 1-216-845-11 METAL CHIP 100K 1/16W (SC8) (SC5/SC6) R361 1-216-837-11 METAL CHIP 1/16W (SC8) R124 1-216-845-11 METAL CHIP...
  • Page 107 HCD-SC5/SC6/SC8 DDCON DRIVER Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks A-4748-364-A DDCON BOARD, COMPLETE S802 1-786-220-11 SWITCH, KEY BOARD (. PREV) S803 1-786-220-11 SWITCH, KEY BOARD (H) ********************** S804 1-786-220-11 SWITCH, KEY BOARD (X) < CAPACITOR >...
  • Page 108 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks A-4749-782-A DVD BOARD, COMPLETE (SC8:RU) C239 1-164-943-11 CERAMIC CHIP 0.01uF 10.00% 16V C240 1-164-943-11 CERAMIC CHIP 0.01uF 10.00% 16V ******************** A-4749-784-A DVD BOARD, COMPLETE (SC8:AUS) C241 1-164-943-11 CERAMIC CHIP 0.01uF...
  • Page 109 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks C406 1-164-939-11 CERAMIC CHIP 0.0022uF 10.00% 50V C613 1-117-370-11 CERAMIC CHIP 10uF C407 1-117-370-11 CERAMIC CHIP 10uF C614 1-124-779-00 ELECT CHIP 10uF C408 1-125-777-11 CERAMIC CHIP 0.1uF 10.00% 10V...
  • Page 110 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks C671 1-164-943-11 CERAMIC CHIP 0.01uF 10.00% 16V C780 1-117-370-11 CERAMIC CHIP 10uF C672 1-164-943-11 CERAMIC CHIP 0.01uF 10.00% 16V C781 1-117-370-11 CERAMIC CHIP 10uF C673 1-164-943-11 CERAMIC CHIP 0.01uF...
  • Page 111 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks C925 1-107-820-11 CERAMIC CHIP 0.1uF FL604 1-234-177-21 FERRITE C926 1-107-820-11 CERAMIC CHIP 0.1uF FL605 1-234-177-21 FERRITE C927 1-107-820-11 CERAMIC CHIP 0.1uF C928 1-107-820-11 CERAMIC CHIP 0.1uF FL606...
  • Page 112 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks IC903 8-759-326-78 IC PST9140NL R032 1-218-990-11 SHORT CHIP IC904 8-759-326-78 IC PST9140NL R033 1-218-990-11 SHORT CHIP IC905 8-759-234-20 IC TC7S08F-TE85L R034 1-218-990-11 SHORT CHIP IC907 8-759-326-78 IC PST9140NL...
  • Page 113 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks R220 1-218-935-11 RES-CHIP 1/16W R313 1-218-990-11 SHORT CHIP R221 1-218-935-11 RES-CHIP 1/16W R314 1-218-990-11 SHORT CHIP R315 1-218-990-11 SHORT CHIP R222 1-218-935-11 RES-CHIP 1/16W R316 1-218-965-11 RES-CHIP...
  • Page 114 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks R412 1-218-965-11 RES-CHIP 1/16W R528 1-218-990-11 SHORT CHIP R413 1-218-965-11 RES-CHIP 1/16W R529 1-218-971-11 RES-CHIP 1/16W R530 1-218-974-11 RES-CHIP 1/16W R415 1-218-990-11 SHORT CHIP R531 1-218-990-11 SHORT CHIP...
  • Page 115 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks R639 1-218-941-81 RES-CHIP 1/16W R712 1-218-965-11 RES-CHIP 1/16W R640 1-218-941-81 RES-CHIP 1/16W R713 1-218-965-11 RES-CHIP 1/16W R714 1-218-965-11 RES-CHIP 1/16W R642 1-218-941-81 RES-CHIP 1/16W R715 1-218-965-11 RES-CHIP...
  • Page 116 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks R806 1-218-990-11 SHORT CHIP R914 1-218-941-81 RES-CHIP 1/16W R821 1-218-933-11 RES-CHIP 1/16W R915 1-218-941-81 RES-CHIP 1/16W R916 1-218-941-81 RES-CHIP 1/16W R822 1-218-933-11 RES-CHIP 1/16W R917 1-218-952-11 RES-CHIP...
  • Page 117 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks R971 1-218-965-11 RES-CHIP 1/16W < IC > R977 1-218-969-11 RES-CHIP 1/16W R978 1-218-953-11 RES-CHIP 1/16W IC801 8-759-827-70 IC NJL64H400A-1 ( ) IC802 6-700-112-01 IC MSM9202-05GS-KDR1 R979 1-218-973-11 RES-CHIP...
  • Page 118 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks < RESISTOR > C227 1-128-551-11 ELECT 22uF 20.00% 25V R900 1-216-829-11 METAL CHIP 4.7K 1/16W C228 1-164-156-11 CERAMIC CHIP 0.1uF R901 1-216-807-11 METAL CHIP 1/16W C230 1-126-964-11 ELECT 10uF 20.00% 50V...
  • Page 119 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks C340 1-162-960-11 CERAMIC CHIP 220PF Q138 8-729-027-23 TRANSISTOR DTA114EKA-T146 (AEP,UK,RU) (AEP,UK,RU) Q139 8-729-900-53 TRANSISTOR DTC114EKA-T146 C342 1-162-960-11 CERAMIC CHIP 220PF (AEP,UK,RU) (AEP,UK,RU) Q140 8-729-027-23 TRANSISTOR DTA114EKA-T146 C472...
  • Page 120 HCD-SC5/SC6/SC8 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks R210 1-216-813-11 METAL CHIP 1/16W R286 1-216-833-11 METAL CHIP 1/16W R211 1-216-813-11 METAL CHIP 1/16W R290 1-216-853-11 METAL CHIP 470K 1/16W R212 1-216-813-11 METAL CHIP 1/16W R291...
  • Page 121 HCD-SC5/SC6/SC8 POWER Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks < LINE FILTER > C922 1-162-964-11 CERAMIC CHIP 0.001uF C923 1-107-898-11 ELECT 2200uF 20.00% 35V 0 LF901 1-456-081-11 COIL, LINE FILTER (EXCEPT E32,MX,TW) C924 1-107-898-11 ELECT 2200uF 20.00% 35V...
  • Page 122 HCD-SC5/SC6/SC8 POWER Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 0 R903 < FUSE HOLDER > 1-245-392-51 METAL OXIDE 0.15 0 R904 1-216-341-11 METAL OXIDE 0.22 0 R905 FH901 1-533-313-11 FUSE HOLDER 1-215-926-00 METAL OXIDE FH902...
  • Page 123 HCD-SC5/SC6/SC8 POWER POWER LED Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks < TRANSFORMER > C032 1-165-176-11 CERAMIC CHIP 0.047uF C033 1-107-826-11 CERAMIC CHIP 0.1uF 0 T901 1-437-865-11 TRANSFORMER, POWER (MX,TW) C034 1-107-826-11 CERAMIC CHIP 0.1uF...
  • Page 124 HCD-SC5/SC6/SC8 SCART Ref. No. Ref. No. Part No. Part No. Description Description Remarks Remarks Ref. No. Part No. Description Remarks R022 1-216-813-11 METAL CHIP 1/10W MISCELLANEOUS R023 1-216-820-11 METAL CHIP 1/10W ************** R024 1-216-864-11 METAL CHIP 1/10W R025 1-216-809-11 METAL CHIP...
  • Page 125 HCD-SC5/SC6/SC8 MEMO...
  • Page 126 HCD-SC5/SC6/SC8 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision...

This manual is also suitable for:

Hcd-sc6Hcd-sc8

Comments to this Manuals

Symbols: 0
Latest comments: