Table of Contents
Advertisement
Quick Links
For Parts Call 606-678-9623 or 606-561-4983
For Parts Call 606-678-9623 or 606-561-4983
Safety • Assembly • Operation • Tips & Techniques • Maintenance • Troubleshooting • Parts Lists • Warranty
OPERATOR'S MANUAL
READ SAFETY RULES AND INSTRUCTIONS CAREFULLY BEFORE OPERATION
Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-
covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any).
If a spark arrester is used, it should be maintained in effective working order by the operator. In the State of California the above is required by law
(Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. A spark arrester
for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 361131 Cleveland,
Ohio 44136-0019.
PRINTED IN U.S.A.
Single-Stage Snow Thrower
IMPORTANT
MTD LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019
www.mymowerparts.com
www.mymowerparts.com
Model 235, S235
FORM NO. 769-01801A
05/2006
Advertisement
Table of Contents
Related Manuals for White Outdoor 235
Summary of Contents for White Outdoor 235
- Page 1 For Parts Call 606-678-9623 or 606-561-4983 Safety • Assembly • Operation • Tips & Techniques • Maintenance • Troubleshooting • Parts Lists • Warranty OPERATOR’S MANUAL Model 235, S235 Single-Stage Snow Thrower IMPORTANT READ SAFETY RULES AND INSTRUCTIONS CAREFULLY BEFORE OPERATION Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush- covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any).
-
Page 2: Table Of Contents
If you have difficulty assembling this product or have any questions regarding the controls, operation, or maintenance of this unit, you can seek help from the experts. To reach a local White Outdoor dealer or retailer, visit www.whiteoutdoor.com or or phone our Customer Support line at (800)-949-4483. -
Page 3: Safety Labels
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Safety Labels WARNING This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate... -
Page 4: Safe Operation Practices
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 WARNING: Engine Exhaust, some of its constituents, and certain vehicle compo- nents contain or emit chemicals known to State of California to cause cancer and birth defects or other reproductive harm. DANGER: This machine was built to be operated according to the rules for safe operation in this manual. - Page 5 For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Operation Maintenance & Storage 1. Do not put hands or feet near rotating parts, in the 1. Never tamper with safety devices. Check their proper auger/impeller housing or chute assembly. Contact with the operation regularly.
-
Page 6: Setting Up Your Snow Thrower
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 NOTE: This Operator’s Manual covers several models. Snow thrower features vary by model. Not all features discussed in this manual are applicable to all snow thrower models. NOTE: All references to left or right side of the snow thrower is from the operating position only Setup And Contents of Carton... -
Page 7: Know Your Snow Thrower
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Auger Control Know Electric Starter Button Your Snow Starter Handle Thrower Fuel Cap Primer Chute Assembly Spark Plug Access Chute Handle IMPORTANT: This unit runs on a mixture of fuel Choke Lever and oil. -
Page 8: Operating Your Snow Thrower
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Electric Starter Button (if equipped) Operation Starter Handle Primer Spark Plug Access Fuel Cap Chute Assembly Choke Lever Chute Knob WARNING Read, understand, and follow all Figure 5-1 instructions and warnings on the Before Starting... -
Page 9: Clearing Snow
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 4. If your home electrical system is grounded, but To help prevent possible freeze-up of starter, a three-hole receptacle is not available, one should proceed as follows: be installed by a licensed electrician before using the 1. -
Page 10: Adjustments & Maintenance
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Adjusting Shave Plate 1. To check the adjustment of the shave plate, place the unit on a level surface. The wheels, shave plate and augers should all contact level surface. Note that if the shave plate is adjusted too high, snow may blow under Side View the housing. - Page 11 For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Remove the belt cover by removing five hex screws. See Figure 6-3. Then simply pull the belt off by grasping it from the bottom of the auger pulley and pulling off. Once you remove the belt from the pulleys, you can push down on the idler pulley to release the belt from under the belt keeper.
-
Page 12: Off-Season Storage
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 If the snow thrower will not be used for 30 days or 1. Remove all gasoline from the fuel tank to prevent gum longer, or if it is the end of the snow season when the deposits from forming on these parts and harming the last possibility of snow is gone, the equipment needs to engine. -
Page 13: Troubleshooting
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Problem Possible Cause(s) Solution Engine fails to start 1. Fuel tank empty, or stale fuel 1. Fill tank with clean fresh gasoline. 2. Improper fuel mixture 2. Mix new fuel at a ratio of 50:1 3. - Page 14 For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Model S235 Determine drive pulley system by measuring this hole. www.mymowerparts.com www.mymowerparts.com...
-
Page 15: Parts List
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Model S235 Part List: Snow PART No. DESCRIPTION Qty. PART No. DESCRIPTION Qty. Thrower 629-0236† Extension Cord 710-0352 Screw, 1/4-14 x .375 710-0627 Hex Screw, 5/16-24 x .75 684-04227 Auger Assembly Housing 21”... - Page 16 For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Model S235 www.mymowerparts.com www.mymowerparts.com...
-
Page 17: Accessories & Kits
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 Model S235 PART NUMBER DESCRIPTION Qty. 684-04127 Chute Assembly 710-04071 Carriage Bolt 5/16-18 x 1.0” Part List: 710-0451 Carriage Bolt 5/16-18 x 0.750” Snow 712-04063 Flange Lock Nut, 5/16-18 Thrower 720-04072 Star Knob, 5/16-18... -
Page 18: Notes
For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 NOTES: www.mymowerparts.com www.mymowerparts.com... - Page 19 For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 NOTES: www.mymowerparts.com www.mymowerparts.com...
- Page 20 For Parts Call 606-678-9623 or 606-561-4983 For Parts Call 606-678-9623 or 606-561-4983 MANUFACTURER’S LIMITED WARRANTY FOR The limited warranty set forth below is given by MTD LLC with respect to MTD does not extend any warranty for products sold or new merchandise purchased and used in the United States, its posses- exported outside of the United States, its possessions and sions and territories.