Table of Contents
Related Manuals for RACOM PROFI MW160
Summary of Contents for RACOM PROFI MW160
- Page 1 Operating manual Wideband modems – PROFI MW160 version 1.5 3/31/2014 RACOM s.r.o. • Mirova 1283 • 592 31 Nove Mesto na Morave • Czech Republic www.racom.eu Tel.: +420 565 659 511 • Fax: +420 565 659 512 • E-mail: racom@racom.eu...
-
Page 3: Table Of Contents
3.12. View of radio modem — description of connectors, model with DSUB (Canon) connectors and with terminals ..........................18 5.1. Mounting dimensions of the radiomodem .................. 21 6.1. Warning sticker IEC 60417-5041 (DB:2002-10) ................. 24 6.2. Country of Origin declaration ..................... 25 © RACOM s.r.o. – Wideband modems – PROFI MW160... - Page 4 3.8. GPS module parameters ......................15 3.9. Table of service connector connections ..................16 3.10. Slot options ..........................18 4.1. Table of technical parameters MW160 ..................19 4.2. Standards complied ........................20 Wideband modems – PROFI MW160 – © RACOM s.r.o.
-
Page 5: Introduction
Fig. 1: Radio modem MW160 with Cannon connectors Fig. 2: Radio modem MR160 with screw clamps, MR300 with Cannon connectors and MR400 with Cannon connectors © RACOM s.r.o. – Wideband modems – PROFI MW160... -
Page 6: Radio Modem Mw160
The radio modem is equipment which can only be operated in the state on the basis of Permission to operate transmitting radio stations issued by the Department of Frequency Spectrum Management at the national Telecommunication Office. Wideband modems – PROFI MW160 – © RACOM s.r.o. -
Page 7: Description Of Radiomodem Mw160
Radio modems MX160 are special devices which require skilled assembly. All supplied equipment is assembled by RACOM at the user’s site. For subsequent maintenance RACOM specially trains the user’s skilled staff and as an additional aid provides them with Operating regulations for radio data networks and MORSE Firmware –... - Page 8 Description of Radiomodem MW160 Important CAUTION! Danger of explosion upon replacing the incorrect type of battery. Follow the manufacturers instructions for handling used batteries. Wideband modems – PROFI MW160 – © RACOM s.r.o.
-
Page 9: Connectors
3.2.1. RS232, RS422 and RS485 Connectors a) Table of data connector RS232 connections Tab. 3.1: Table of data connector RS232 connections RS232 Screw DSUB9F signal terminals Fig. 3.1: RS232 DSUB9 female © RACOM s.r.o. – Wideband modems – PROFI MW160... -
Page 10: Data Cable Rs485 Connections
Tab. 3.3: Table for distinguishing LEDs for RxD and TxD by colour Type of interface Colour (RxD / TxD) RS232 red / green RS232 opt. separated orange / green RS422/485 opt. separated orange / yellow Wideband modems – PROFI MW160 – © RACOM s.r.o. -
Page 11: Ethernet
The ETH module consumption is 30 mA (60 mA until 07/2008). The following table contains connector connections and colours of conductors. For the crossed cable the order of conductors on one side is the same as for the direct cable. © RACOM s.r.o. – Wideband modems – PROFI MW160... -
Page 12: Analog And Digital Inputs And Outputs
Connector A OUT - analog outputs Connector A IN - analog inputs Connector D OUT - digital outputs Connector D IN - digital inputs Terminal UP this clamps pair is not used Wideband modems – PROFI MW160 – © RACOM s.r.o. -
Page 13: Description Of Analog And Digital Inputs And Outputs
+A in any MORSE system equipment transmitter A in (e.g. MD160, MX 160, MWxxx, MRxxx, MC100, MG100i, ...) Fig. 3.7: Examples of wiring analog inputs and outputs © RACOM s.r.o. – Wideband modems – PROFI MW160... -
Page 14: Gps Module
Pin No. 3 becomes the input for configuration data, if we connect pin No. 8 to GND. • The behaviour of time pulses at pin No. 6 (default) +6 V -6 V 100 ms 900 ms http://www.u-blox.com/products/modules.html Wideband modems – PROFI MW160 – © RACOM s.r.o. -
Page 15: Supply Connector
Terminals of this connector are labelled in the standard manner. Only DC voltage in the range from 10.8 to 15.6 V can be connected. Connecting higher voltage may damage the radio modem. https://www.racom.eu/eng/support/firmware/mr400/index.html © RACOM s.r.o. – Wideband modems – PROFI MW160... -
Page 16: Information Led
Fig. 3.10: Service connector ground keying of TX carrier waves for service purposes Important ATTENTION! The service mode is not suitable for normal operation Wideband modems – PROFI MW160 – © RACOM s.r.o. -
Page 17: View Of Radio Modem
Fig. 3.11: Service cable connector connections 3.9. View of Radio Modem The only difference in appearance between the radio modem MW160 and the radio modem MR400 is the type designation badge – see the following image. © RACOM s.r.o. – Wideband modems – PROFI MW160... -
Page 18: View Of Radio Modem - Description Of Connectors, Model With Dsub (Canon) Connectors And With Terminals
Optional modules slot 5 ADIO (analog and digital inputs and outputs) slot 4 Ethernet 10/100 Mbps slot 3 2×RS232 slot 2 RS232 or galv. sep. RS232 or RS422/RS485 or GPS slot 1 Wideband modems – PROFI MW160 – © RACOM s.r.o. -
Page 19: Table Of Technical Parameters
1.3 kg 1) Availability of specific types and frequencies check here , please. Presently these types are under mass production. 2) Approximate values dependent on frequency and modem type. http://www.racom.eu/eng/products/rfp.html http://www.racom.eu/eng/products/radio-modems-mr400.html#specifications © RACOM s.r.o. – Wideband modems – PROFI MW160... -
Page 20: Standards Complied
Table of Technical Parameters Tab. 4.2: Standards complied EMC (Electromagnetic Compatibility) ETSI EN 301 489-5 V 1.3.1 Electrical safety CSN EN 60 950:2001 Wheeled vehicle usage UN Regulation No.10 (EHK No.10) Wideband modems – PROFI MW160 – © RACOM s.r.o. -
Page 21: Dimensional Diagram And Labeling Modems
In this case 4x M4 screws are used for mounting purposes. There are no centre holes in the P version for attachment to a DIN rail. Labelling Radio Modems is described in next table: © RACOM s.r.o. – Wideband modems – PROFI MW160... - Page 22 25 kHz, casing with flanges for screws and/or DIN rail clips , SCC connectors with screw terminals, SCC1 - RS485, optically separated, SCC2 - RS232, SCC3 - RS232, Ethernet 01 2014 Wideband modems – PROFI MW160 – © RACOM s.r.o.
-
Page 23: Condition For Mw160
6.1. Important Warning RACOM s. r. o. (hereinafter referred to as RACOM) is the exclusive owner of all rights to this operator manual. All rights reserved. Any duplication of this manual in any way, shape or form, or translation to any other language (without the prior written consent of the owner of the rights) is strictly forbidden. -
Page 24: Product Conformity
Fig. 6.1: Warning sticker IEC 60417-5041 (DB:2002-10) 6.3. Product Conformity Hereby, RACOM s. r. o., declares that this MX160 radio modem is in compliance with the essential requirements and other relevant provisions of Directive 1999/5/EC. This equipment therefore bears the CE marking. The warning exclamation mark in the circle marks the radio modem as class 2 equipment denoting radio equipment with possible limitations or with requirements on authorisation to use radio equipment in certain countries. -
Page 25: Country Of Origin
Nove Mesto na Morave, 1 of March 2014 Jiri Hruska, CEO RACOM s.r.o. • Mirova 1283 • 592 31 Nove Mesto na Morave • Czech Republic www.racom.eu Tel.: +420 565 659 511 • Fax: +420 565 659 512 • E-mail: racom@racom.eu Fig. -
Page 26: Limitations Of Use
AT, AU, BE, BR, BG, CA, HR, CZ, CY, DK, EE, FI, FR, DE, GR, HK, HU, IS, IE, IT, LV, LT, LU, MY, NL, NO, PL, RO, SG, SI, ZA, ES, SE, CH, GB and US. Wideband modems – PROFI MW160 – © RACOM s.r.o. -
Page 27: Revision History
Revision History Appendix A. Revision History Revision 1.5 20014-03-27 Added section Section 6.4, “Country of Origin” © RACOM s.r.o. – Wideband modems – PROFI MW160...
Need help?
Do you have a question about the PROFI MW160 and is the answer not in the manual?
Questions and answers