Troubleshooting - Yamaha AR230 Owner's/Operator's Manual

*AR230(SRT1000)-'04-OwnMnl 11/10/03 11:27 AM Page 4-20
T
ROUBLESHOOTING

TROUBLESHOOTING

If any trouble happens on your Sport Boat, use this section to check for possible cause. If you
cannot find the cause or if the procedure for replacement or repair is not described in this
owner's manual, ask your Yamaha Sport Boat dealer or qualified mechanic for the proper ser-
vice.
The Troubleshooting Chart contains: "TROUBLE," "POSSIBLE CAUSE," "REMEDY," and
"REFER PAGE."
Check the possible cause and remedy, and also the referred page for the maintenance steps to
solve the trouble.
TROUBLESHOOTING CHART
TROUBLE POSSIBLE CAUSE
• Starter motor • Fuse Burned out
does not turn
over
Run down
• Battery
Poor terminal
connections
Battery switch off
• Jet pump
Not latched
cleanout hatch
• Starter
Faulty
component
• Shift lever Not in Neutral
• Starter motor • Engine shut-off Clip on cord is not
turns over/ switch in place
engine does
Empty
not start
• Fuel
Stale or
contaminated
Water or dust
collected
• Fuel tank
Built-up pressure
• Spark plug Fouled or defective • Clean or replace
• Spark plug cap Not fitted or loose
Filled with fuel
• Crankcase
Filled with water
Clogged or water
• Fuel filter
collected
& S P
PECIAL ROCEDURES
REMEDY Page
• Replace the fuse and 4-15
check wiring
• Recharge 4-16
4-16
• Tighten as required
• Turn on switch 4-17
5-5
• Latch securely
• Have serviced at
Yamaha dealer
• Shift to Neutral 2-7
• Install clip in engine 2-6
shut-off switch
• Refill as soon as possible* 3-2
• Have serviced at
Yamaha dealer
• Have service at
Yamaha dealer
• Open the fuel tank filler
3-14
cap and release pressure
4-7
• Fit properly 4-7
• Have serviced at
Yamaha Dealer
• Crank engine with
spark plug out until clean
• Have serviced at
Yamaha Dealer
5-1
5