Maintenance Chart - Yamaha VZ150A Owner's Manual

EMU00362*

MAINTENANCE CHART

Frequency of maintenance operations may be adjusted according to the operating con-
ditions, but the following table gives general guidelines.
The mark (6) indicates the check-ups which you may carry out yourself.
The mark (1) indicates work to be carried out by your Yamaha dealer.
Item
Cleaning/Adjustment/
Spark plug(s)
Replacement
Greasing points Greasing
Gear oil Change
Fuel system Inspection
Fuel filter (Water separator) Cleaning/Inspection
Fuel tank Cleaning
High pressure fuel pump
Inspection
drive belt* 2
High pressure fuel pump oil* 3 Inspection
Idling speed Inspection/Adjustment
Anode(s) Inspection/Replacement
Outboard motor exterior Inspection
Cooling water passage* 1 Cleaning
Propeller/Cotter pin Inspection/Replacement
Battery Inspection/Charge
Throttle pick-up timing Inspection/Adjustment
Bolts/Nuts Retightening
Oil tank water drain Cleaning
Oil pump Inspection/Adjustment
Power trim/tilt unit Inspection
Power trim/tilt operation Inspection
Exhaust leakage Inspection
Water leakage Inspection
Cowling clamp Inspection
Throttle link Inspection/Adjustment
Throttle sensor Inspection/Adjustment
Wiring/Connector(s) Inspection/Reconnect
*1. When operating in salt water, turbid or muddy water, the engine should be flushed with clean
water after each use.
*2. Be sure to replace the high pressure fuel pump drive belt after every 1,000 hours or 5 years
(whichever comes first) of operation.
*3. Be sure to replace the high pressure fuel pump oil after every 1,000 hours or 5 years (whichev-
er comes first) of operation.
Initial
Interval
10 hours 50 hours
(1 month) (3 months)
● ●
●
● ●
● ●
●
●/1
● ●
●
● ●
●
(every month)
● ●
● ●
1
● ●
● ●
● ●
● ●
4-9
E
Every
Refer
100 hours 200 hours
page
(6 months) (1 year)
●
4-11
●
4-10
●
4-22
●
4-13
●
4-14
●
—
1
4-17
1
—
●
4-15
●/1
4-23
●
4-29
●
4-28
●
4-20
4-24
1
—
●
4-27
●
4-16
—
●
4-19
●
4-19
●
4-18
●
4-18
●
—
1
—
1
—
●
4-18