How To Order Repair Parts; Parts List - Empire DV-55IP Installation Instructions And Owner's Manual

PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide.
Index Part
No. Number
1 11762
2 632024
3 11764
4 712059
5 R-619
6 11787
7 11766
8 DV-559
9 11759
10 DV-613
11 DV-725
12 DV-131
13 DV-548
14 DV-524
15 DV-600
16 DV-567
17 712036
18 DV-579-C
19 8720130
20 11765
21 912073
22 R-1941
23 DV-832
24 DV-562
24 15667
25 DV-826
26 732062
27 762217
27 762113
28 DV-808
29 DV-824
30 P-88-42
30 742223
31 DV-687
32 712045
USE ONLY MANUFACTURER'S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INjURY OR DEATH.
Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts through
the distributor. Parts can be shipped directly to the service person/dealer.
All parts listed in the Parts List have a Part Number. When ordering parts, first obtain the Model Number from the name plate on your
equipment. Then determine the Part Number (not the Index Number) and the Description of each part from the following appropriate
illustration and list. Be sure to give all this information . . .
Furnace Model Number
Furnace Serial Number
Type of Gas (Propane or Natural)
Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store.
Shipments contingent upon strikes, fires and all causes beyond our control.
Page 20
Empire Comfort Systems, Inc. Nine eighteen Freeburg ave. Belleville, IL 62222-0529

PARTS LIST

Description
Outer Casing Top
Motor Mount (Four Required)
Motor Mounting Bar (Two Required)
Gasket (Two Required)
Motor
Fan Blade
Fan Housing
Upper Front Panel
Side Panel
Right Inner Shield
Vent Cap
Outside Mounting Plate
air Inlet Tube
Flue Outlet Tube
Vent Kit Complete
(Nos. 11, 12, 13, 14)
air Drop Welded assembly
Gasket for Flue Outlet Flange
Combustion Chamber
Bushing
Switch Compartment assembly
Limit Control
Fan Control
Switch Compartment Cover
Lower Front Panel (USA)
Lower Front Panel (Canada)
Rear Burner
Spark Plug Wire
Pilot with Orifice LP Gas
Pilot with Orifice Natural Gas
Pilot Tubing
Front Burner
Main Burner Orifice Natural Gas
(Two Required)
Main Burner Orifice LP Gas
(Two Required)
Manifold and Plate assembly
Manifold Gasket

HOW TO ORDER REPAIR PARTS

Index Part
No. Number
33 712098
34 DV-781
35 DV-064
36 DV-691
37 712059
38 DV-847
38 DV-972
39 DV-779
40 722040
41 R-2147
41 R-2149
42 UH-810
43 R-1995
44 UH-451
45 11760
45 15690
46 8720148
47 872053
48 DV-571
49 DV-671
50 DV-765
51 DV-764
52 DV-692
53 872050
54 R-1616
55 8720140
56 DV-614
57 11759
Not Shown R-9832
Not Shown R-9833
Not Shown R-6389
Not Shown 862060
Not Shown 742245
Not Shown 7421110
Part Description
Part Number
Description
Gasket for Observation Hole Cover
Lighting Hole Cover w/Mica
Cover Plate for Observation Hole
Seal Bracket
Gasket Tubing Seal
Burner Door Natural Gas
Burner Door LP Gas
Gasket for Burner Door
Manifold Union
Gas Valve VR8204C 1126 LP Gas
(10.0")
Gas Valve VR8204C 1001
Natural Gas (3.5")
Transformer Mounting Bracket
Transformer
Junction Box Cover
Outer Casing Bottom (USA)
Outer Casing Bottom (Canada)
Bushing
Cord Set
Control Compartment Divider
Manifold Support
Gasket for Chamber air Inlet
(Top & Bottom) (Two Required)
Gasket for Chamber air Inlet
(Sides) (Two Required)
Control Module Mounting Bracket
Wire Harness for Control Module
Control Module
Bushing
Left Inner Shield
Side Panel
Wiring assembly Upper
Wiring assembly Lower
24 Volt Wall Thermostat
Lighter Rod
Pilot Orifice LP
Pilot Orifice Natural
12432-13-1008