Page 1
GLO-RAY ® Heated Shelf GRS, GRSB & GRSBF Series Installation & Operating Manual I&W #07.05.027.00 Este manual contiene importante información sobre This manual contains important safety information seguridad concerniente al mantenimiento, uso y concerning the maintenance, use and operation of this operación de este producto.
Additional information can be found by visiting our web site at www.hatcocorp.com INTRODUCTION The Hatco Glo-Ray Heated Shelf is designed to Safety instructions that appear in this manual after keep prepared foods hot at kitchen work areas, a warning symbol and the words WARNING or waitress pick-up stations or customer serving points.
Some aftermarket or generic replacement parts do not have the characteristics that will allow them to operate safely in Hatco equipment. It is essential to use Hatco Replacement Parts when repairing Hatco equipment. Failure to...
SPECIFICATIONS PLUG CONFIGURATIONS Units are supplied from the factory with an electrical cord and plug installed. Plugs are supplied according to the applications as shown in Figure 1. NEMA 5-15P CEE 7/7 Schuko WARNING Plug unit into a properly grounded electrical outlet of the correct voltage, size and plug configuration.
SPECIFICATIONS ELECTRICAL RATING CHART - STANDARD GRS MODELS Plug Shipping † Model Voltage Watts Amps Configuration Weight GRS-18-I NEMA 5-15P 16 lbs. (7 kg) NEMA 5-15P 16 lbs. (7 kg) CEE 7/7 Schuko 16 lbs. (7 kg) BS-1363 16 lbs. (7 kg) 220-230 CE 228-250 1.0-1.1...
SPECIFICATIONS ELECTRICAL RATING CHART - STANDARD GRSBF MODELS Plug Shipping Model † Voltage Watts Amps Configuration Weight GRSBF-18-F NEMA 5-15P 15 lbs. (7 kg) GRSBF-24-F NEMA 5-15P 20 lbs. (9 kg) GRSBF-24-I NEMA 5-15P 22 lbs. (10 kg) NEMA 5-15P 22 lbs.
Page 11
SPECIFICATIONS ELECTRICAL RATING CHART - STANDARD GRSBF MODELS Plug Shipping Model † Voltage Watts Amps Configuration Weight GRSBF-60-F NEMA 5-15P 45 lbs. (20 kg) GRSBF-60-I 1220 12.2 NEMA 5-15P 50 lbs. (23 kg) 1220 10.2 NEMA 5-15P 50 lbs. (23 kg) GRSBF-60-S 1500 12.5...
MODEL DESCRIPTIONS GRS MODEL The GRS Heated Shelf is ideal for pass-through areas, buffet lines or as a heated work shelf. It features an on/off rocker switch with indicator light, 140° to 180°F (60° to 82°C) adjustable thermostat and 6' (1829 mm) cord with plug. Surface mounted foil elements distribute heat under the entire stainless steel surface.
Hatco GRS MODELS equipment is not covered under the Hatco warranty. Recommended for use in metallic 1. Remove the unit from the carton and lay it upside counters. For other surfaces, verify that the down on the cardboard.
Page 14
INSTALLATION Apply a bead of NSF approved sealant between the countertop material and mounting flange. Countertop Countertop Z-Bracket Z-Bracket Four screws from underside of unit Figure 5. GRSB Countertop Installation COUNTERTOP CUTOUT MODEL MINIMUM WIDTH MAXIMUM WIDTH MINIMUM DEPTH MAXIMUM DEPTH GRSB-24-F 24-1/2"...
Page 15
INSTALLATION Apply a bead of NSF approved sealant between the countertop material and mounting flange. Countertop Countertop Z-Bracket Z-Bracket Four screws from underside of unit Figure 6. GRSBF Countertop Installation COUNTERTOP CUTOUT MODEL MINIMUM WIDTH MAXIMUM WIDTH MINIMUM DEPTH MAXIMUM DEPTH GRSBF-18-F 18-1/2"...
Page 16
INSTALLATION 6. Assemble the Z-brackets to the underside of the 9. If you wish to move the control box to a semi- unit using the four screws removed in step 2. remote location, remove it from the bottom of the unit.
OPERATION CAUTION Power On/Off Switch Some exterior surfaces on the unit will get hot. Use caution when touching these areas to avoid injury. CAUTION Unit is not weatherproof. For safe and proper operation locate the unit indoors where the ambient air temperature is a minimum of 70°F Shelf Thermostat (21°C).
Hard to reach areas should be safely in Hatco equipment. It is essential to use cleaned with a small brush and mild soap. Hatco Replacement Parts when repairing Hatco equipment.
Hatco will explain accept or reject any such claim in whole or in part. at Buyer’s request: Hatco will not accept the return of any Product 3CS and FR Tanks without prior written approval from Hatco, and all c) One (1) Year Parts and Labor PLUS Nine such approved returns shall be made at Buyer’s...
HATCO AUTHORIZED PARTS DISTRIBUTORS NEW YORK TENNESSEE ALABAMA INDIANA Acme American Repairs, Inc. Camp Electric Jones McLeod Appl. Svc. GCS Service Memphis 901-527-7543 Birmingham 205-251-0159 Indianapolis 317-545-9655 Brooklyn 718-456-6544 TEXAS IOWA Alpro Service Co. ARIZONA Brooklyn 718-386-2515 Stove Parts Supply Electric Motor Service Co.
Need help?
Do you have a question about the GLO-RAY GRS Series and is the answer not in the manual?
Questions and answers