Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Bosch DHD9605UC/01
Summary of Contents for Bosch DHD9605UC/01
- Page 1 DOWNDRAFT INSTALLATION INSTRUCTIONS DHD Models YOUR OUR INSP RATION.
-
Page 2: To Reduce The Risk Of Fire, Electric Shock, Or Injury To Persons, Observe The Following
SAFETY INSTR[ Read All Instructions Before Using the Appliance. READ AND SAVE THESE INSTRUCTIONS WARNING WARNING TO REDUCE THE RISK OF FIRE, ELECTRIC CAUTION: For general ventilating use only. Do SHOCK, OR INJURY TO PERSONS, OBSERVE not use to exhaust hazardous or explosive materi= THE FOLLOWING: als and vapors. -
Page 3: General Description
Top Cap internal Btower (Not Included) Strain Relief :igure 1 iNTRODUCTiON Step 1 PLAN THE INSTALLATION GENERAL DESCRIPTION Carefully follow the planning procedures listed below (See Figure 2). The complete downdraft system consists of the ventilator, Determine whether a remote or integral blower will be the intake and the blower (See Fig. - Page 4 i/8" Min. Be certain to avoid interference with gas and electric supply to cooktop. ° Shelving and drawer depths are dependent upon cooktop depth and setback. Cooktop 25" Cutout SB (see Depth Fig. 7,8) Cooktop Drawer tk_rFor integral ventilator installations discharged through left side of cabinet, this dimension...
- Page 5 examples of possible Figures 3 through 6 are Integral Blower Remote Blower Through Wall Installations Roof Mount Installation Remote Blower Duct Transition Wall Cap 12" Min. Ground Figure 3 Figure 4 Remote Blower Integral Blower Through Walt Installation Through Wall Installation 3-1/4"...
- Page 6 TABLE Uo VENTULATOR PERFORMANCE CALCULATION TOTAL EQUIVALENT iQUANTITY SiZE EQUBVALENT QUANTITY TOTAL DUCTPIECES DUCT PIECES EQUIVALENT USED EQUIVALENT USED SiZE LENGTH LENGTH LENGTH LENGTH 6" U.2' 3=U4"× 10" 0.95' BOUND CENTER m 5' 0.7' 8" REVERSE ELBOW LEFT 0°6' 3oU4"X mO"...
-
Page 7: Ductwork Installation Guidelines
Limit use to short lengths and do not crush when making corners. Step 2: Prepare Countertop Cutout For installation with a Bosch cooktop, refer to Part A and For overhead cabinet and cooktop side clearances Figure 7 (Page 7)). - Page 8 24" deep base cabinet with 25" countertop. ** NGT and NGP: width in table is at the widest point (center). INSTALLATION WITH BOSCH COOKTOPS WHEN SPECIFIED ....2 1/4" Figure 7...
- Page 9 INSTALLATION WITH OTHER COOKTOPS WHERE SPECIFIED Figure 8 B. FOR INSTALLATION WITH ANOTHER BRAND OF COOKTOP (Figure 8) Have the following cooktop measurements available before Calculate the cutout depth, CD: proceeding All cooktop dimensions should be verified Determine the cooktop overhang (CO) through measurement prior to cutting the countertop: CO = (COD-CCD)/2 (Assumes front and rear cooktop CCW = Cooktop Cutout Width...
-
Page 10: Step 3: Prepare Duct Cutouts In Cabinet
Point "P" (Center of Rear Cut-line) -..., Countertop Surface Right Side Cabinet Back Left Side Plumb line to intersection SS-B Receptac+e Location ular Duct Shown Cabinet BottomShelf Figure 9: Cabinet Cutout for Ductwork Cabinet Cutout Dimensions for B+ower: 6 3/8" 14 1/2"... -
Page 11: Step 4: Install Ductwork (Remote Blower, If Used)
Step 4: Install Ductwork (Remote Blower, Step 6: Mount Vent and Cooktop If Used) Remove grease filters and any packing materials from inside the intake. install the ductwork and remote blower (if used) in Set the vent intake into rear of countertop opening. accordance with the ductwork routing plan developed in Carefully lower it into position so that the flanges on the Step 1. - Page 12 Step 7: Mount Integral Blower or Figure 10 - Internal Blower Outlet Duct Transition for Re- mote Blower _ntegra_ B_ower DHG601DUC (See Figures 10 and 12 for further detail): Attach blower in front of round exhaust outlet with 4-6 (depending on configura- tion) #8 sheetmetal screws Feed cord from blower through strain relief.
- Page 13 Figure 12 - Wiring Diagram [WAR_IIIG: POWER UUST BE DISCCNNECTED BEFORE 8JERVIC_HG THIS APPLIANCE 1 STEP DOWN SWITOH O01TROL O_OE L@N_N _ UPPE[_ UNIT UNIT 8W_TCH POS|T|¢H SHOWN POWER WITH DOWND_FT WiRE 8iNGLE PHASE IIHz LOWEreD P¢SiTmCN Lt: 12IV _: GROI_DED WHITE WiRE ¢...
- Page 14 Installa- tion Instructions to ensure that nothing has been omitted or overlooked. Also, refer to the Care & Use Manual for addi- tional information or call Bosch Customer Support 1-800- 994-2904.
- Page 15 YOUR LIFE. OUR INSPIRATION. 5551 McFadden Avenue, Huntington Beach CA, 92649 • 800-994-2904 • www.boschappliances.com 9000065051 • 10019 RevA • 02/05 © 2005 BSH Home Appliances Corporation • Litho in U.S.A.