Page 1: Table Of Contents
Manual heating and air conditioning Dual automatic temperature control Rear window defroster Lights Headlamps Turn signal control Bulb replacement Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Moon roof Message center 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 2 Starting Brakes Traction Control™/AdvanceTrac Air suspension Transmission operation Roadside Emergencies Getting roadside assistance Hazard flasher switch Fuel pump shut-off switch Fuses and relays Changing tires Lug nut torque Jump starting Wrecker towing 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 4: Introduction
– Special handling may apply for service or vehicle end of life disposal. See www.dtsc.ca.gov/hazardouswaste/perchlorate. CONGRATULATIONS Congratulations on acquiring your new Ford. Please take the time to get well acquainted with your vehicle by reading this handbook. The more you know and understand about your vehicle, the greater the safety and pleasure you will derive from driving it.
Page 5 Correct vehicle usage and the authorized disposal of waste, cleaning and lubrication materials are significant steps towards this aim. Information in this respect is highlighted in this guide with the tree symbol. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 6 For a detailed description of what is covered and what is not covered by your vehicle’s New Vehicle Limited Warranty, refer to the Warranty Guide that is provided to you along with your Owner’s Guide. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 7 In order to properly diagnose and service your vehicle, Ford Motor Company, Ford of Canada, and service and repair facilities may access vehicle diagnostic information through a direct connection to your vehicle when diagnosing or servicing your vehicle.
Page 8 • where the driver was positioning the steering wheel. To access this information, special equipment must be directly connected to the recording modules. Ford Motor Company and Ford of Canada do not access event data recorder information without obtaining consent,...
Page 9 Driving while distracted can result in loss of vehicle control, accident and injury. Ford strongly recommends that drivers use extreme caution when using any device that may take their focus off the road. The drivers primary responsibility is the safe operation of their vehicle.
Page 10 Brake Fluid - Anti-Lock Brake System Non-Petroleum Based Powertrain Malfunction Speed Control Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Wash/Wipe Windshield Rear Window Defrost/Demist Defrost/Demist 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 11 Battery Acid or Sparks Explosive Gas Fan Warning Maintain Correct Fluid Power Steering Fluid Level Emission System Engine Air Filter Passenger Compartment Jack Air Filter Low Tire Pressure Check Fuel Cap Warning 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 12: Instrument Cluster
If the light is blinking, engine misfire is occurring which could damage your catalytic converter. Drive in a moderate fashion (avoid heavy acceleration and deceleration) and have your vehicle serviced immediately by your authorized dealer. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 13 ABS light stays illuminated or continues to flash, a malfunction has been detected, have the system serviced immediately by your authorized dealer. Normal braking is still functional unless the brake warning light also is illuminated. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 14 Refer to Engine coolant in the Maintenance and Specifications chapter. Never remove the coolant reservoir cap while the engine is running or hot. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 15 AdvanceTrac (RTT) (if equipped): Displays when the AdvanceTrac with RSC system is active. If the light remains on, have the system serviced immediately, refer to the Driving chapter for more information. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 16 If the indicators stay on or flash faster, check for a burned out bulb. High beams: Illuminates when the high beam headlamps are turned on. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 17: Gauges
Overspeed chime (if equipped): Sounds when the vehicle speed reaches 120 km/h (75 mph) or higher. Reverse warning chime (if equipped): Sounds when the vehicle is in reverse. Refer to the Driving chapter for more information. GAUGES 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 18 Odometer: Registers the total miles (kilometers) of the vehicle. • With Standard Message Center • With Optional Message Center Refer to Message Center in the Driver Controls chapter on how to switch the display from Metric to English. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 19 Add oil if needed. If the oil level is correct, have your vehicle checked by your authorized dealer. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 20 Refer to Filling the tank in the Maintenance and Specifications chapter for more information. The FUEL icon and arrow indicates which side of the vehicle the fuel door is located. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 21: Entertainment Systems
— six in AM, six in FM1 and six in FM2. To access your saved stations, press the corresponding memory preset. The memory preset # and the station frequency will appear on the display. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 22 Note: The system may take a few moments to turn on. 2. Press CD to enter CD mode. If a disc is already loaded into the system, CD play will begin where it ended last. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 23 Press and hold FF to manually advance in a CD/MP3 track. Press FOLDER to access the previous folder on MP3 discs, if available. Press FOLDER to access the next folder on MP3 discs, if available. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 24 15 seconds, the system will reload the disc. To auto eject up to 6 discs, press and hold until the system begins ejecting all loaded discs. If the discs are not removed, the system will reload the discs. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 25: Am/Fm Stereo With Cd
Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 2. MUTE/ : Press to mute the playing media. Press again to return to the playing media. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 26 SCAN to begin the search. To view the station name or type: Press TEXT/SCAN to toggle between displaying the station type (COUNTRY, ROCK, etc.) or the station name (WYCD, WXYT, etc.). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 27 MENU until COMPRESS ON/OFF appears in the display. Use SEEK, SEEK to toggle ON/OFF. When COMPRESS is ON, the system will bring the soft and loud CD passages together for a more consistent listening level. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 28 CD or DVD. The CD/DVD status will display in the radio display. For further information on the Family Entertainment System (FES) please refer to Family Entertainment DVD system later in this section. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 29 Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 30 CD play will begin where it ended last. If no CD is loaded, NO DISC will appear in the display. 17. CD eject: Press to eject a CD/MP3. 18. CD slot: Insert a CD label side 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 31: Am/Fm Stereo With In-Dash Six Cd
Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 2. MUTE/ : Press to mute the playing media. Press again to return to the playing media. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 32 To view the station name or type: When the desired category appears in the display, press TEXT/SCAN to toggle between displaying the station type (COUNTRY, ROCK, etc.) or the station name (WYCD, WXYZ, etc.). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 33 In Folder mode, pressing SEEK will scroll only through tracks within the selected folder. Press FOLDER, FOLDER to access the previous/next folder (if available). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 34 In CATEGORY MODE, press SEEK, SEEK to select a category. Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 35 Press and hold a preset button until sound returns and PRESET # SAVED appears in the display. You can save up to 18 stations, six in AM, six in FM1 and FM2. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 36 16. CD: Press to enter CD/MP3 mode. If a CD/MP3 is already loaded into the system, CD/MP3 play will begin where it ended last. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 37 To auto eject up to 6 CDs, press and hold until the system begins ejecting all loaded discs. If the discs are not removed, the system will reload the discs. 19. CD slot: Insert a CD/MP3 label side up. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 38: Auxiliary Input Jack
AUX and FM or CD controls. Troubleshooting: 1. Do not connect the audio input jack to a line level output. Line level outputs are intended for connection to a home stereo and are not 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 39: Rear Seat Controls
) or decrease ( ) the volume level in the headphones. From the rear seat controls, volume control can be set no higher than the current radio setting unless the speakers are turned off. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 40 2 and 4 simultaneously on the front audio controls. The rear speakers mute and rear seat passengers have audio (for their selected media) available through their headphones. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 41 FM: 87.7, 87.9–107.7, 107.9 MHz Radio reception factors: There are three factors that can affect radio reception: • Distance/strength: The further you travel from an FM station, the weaker the signal and the weaker the reception. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 42 (12 cm) audio compact discs only. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Dirty, warped or damaged CDs, irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player.
Page 43: Satellite Radio Information
United States, www.sirius-canada.ca in Canada, or call SIRIUS at 1–888–539–7474. Satellite radio reception factors: To receive the satellite signal, your vehicle has been equipped with a satellite radio antenna located on the 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 44 Note: SIRIUS reserves the unrestricted right to change, rearrange, add or delete programming including canceling, moving or adding particular channels, and its prices, at any time, with or without notice to you. Ford Motor Company shall not be responsible for any such programming changes.
Page 45: Radio Display Messages
1–888–539–7474 to channel. subscribe to the channel or tune to another channel. NO TEXT Artist information not Artist information not available. available at this time on this channel. The system is working properly. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 46: Family Entertainment System
DVD player is capable of playing standard DVDs, CDs, MP3s and is compatible with CD-R/W, CD-R and certain CD-ROM media. Please review this material to become familiar with the FES features and controls as well as the very important safety information. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 47: To Play Dvd/Cd In Dvd System
The DVD system can play audio CDs, CD-R and CD-R/W, CD-ROM and video CDs. To ensure proper disc operation, check the disc for finger prints and scratches. Clean the disc with a soft cloth, wiping from the center to the edge. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 48 The DVD system can be used to connect and play auxiliary electronic devices such as game systems, personal camcorders, video cassette recorders, etc. 1. Ensure that the vehicle ignition is in the RUN or ACCESSORY position. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 49 3. Press MEDIA to change the audio source of the active channel (A or B). The audio source will be shown on the display. You may change the active channel by pressing the A or B headphone control button. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 50 DVD system. A display will appear at the bottom of the screen indicating the brightness level. The brightness display will only appear when the menu is not displayed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 51 DVD system. (Reverse): Press and release for the previous chapter or track. Press and hold to reverse search a DVD, Video CD, or FES CD in DVD/CD mode. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 52 When in Dual Play, press to increase ) or decrease ( ) the volume for the wired headphones. (Wireless headphone volume is controlled with the rotary dial on the right ear piece.) 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 53 Unless otherwise stated, all operations can be carried out with the remote control. Always point the remote control directly at the player. Ensure that there are no obstructions between the remote and player. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 54 5. ANGLE (DVD dependent): Press to select the angle to view the scene. 6. Channel A/B: Press to select either A or B headphones and then use the MEDIA control to select the desired playing media for the headphones. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 55 MENU again when in the DVD disc menu to access the system set-up menu. 20. SUBTITLE (DVD dependent): Press to turn the subtitle feature ON or OFF. 21. LANGUAGE (DVD dependent): Press to select the desired language. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 56 DVD player. Remove the screw and unlatch the battery cover to access the batteries. The remote control unit uses two AAA batteries which are supplied with the unit. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 57 Then, lightly press down on top and slide the cover off. When replacing the batteries, use two new batteries (alkaline recommended) and install them with the correct orientation as indicated in the battery housing. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 58 The wired headphone jack for Channel A is located on the left side of the FES and is labeled A. Headphones plugged into this headphone jack will hear audio from the audio source selected to be the 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 59 These are called Channel A and Channel B. Both Channel A and Channel B can be listened to on the wired headphones (not included) or on the infrared (IR) wireless headphones. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 60 (Headphone only mode) When the Family Entertainment System (FES) detects that the original radio supplied by Ford Motor Company has been removed from the vehicle, the Family Entertainment System will work in a state referred to as “Headphone Only Mode”.
Page 61 ENTER to confirm. The system default is Angle 1. Aspect ratio Select ASPECT RATIO to select the viewing size and shape of the video displayed on the LCD screen. This is disc dependent. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 62 French). This is disc dependent. Once you have made your selection, press ENTER to confirm. The system default is English. Subtitles Select SUBTITLES to turn the subtitle option on or off. The system default is OFF. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 63 1. Ensure that the vehicle ignition is in the RUN or ACCESSORY position. 2. Ensure that the DVD system is ON. 3. Insert the MP3 disc into the DVD system, label side up. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 64 Follow the PC configuration recommendations of the encoder software vendor. We recommend that you avoid running other software applications on your PC during MP3 encoding to avoid undesirable noise and distortion. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 65 (DVD) only. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD and DVD players. Irregular shaped CDs or DVDs, CDs or DVDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the FES DVD system.
Page 66 1/4 and 1/2. These will display on the status bar on top of the screen as the screens cycle through at this rate. Frame by frame 1. With a DVD playing, press pause. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 67 The B headphone jack (5) is located on the right side of the DVD system. Plug in wired headphones (not included) here. Note: The B headphones can only access DVD and AUX modes. They cannot access radio sources. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 68 The radio will ignore button presses that affect the primary (speaker) audio source. LOCKED (disabled): The FES buttons are locked and all FES button presses are ignored by the radio and the FES except for load and eject. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 69 Do not leave children unattended in the vehicle and do not let children operate the system while unsupervised. If wired headphones or auxiliary systems are used, children may become entangled in the cords and seriously injure themselves. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 70 Federal Communication Commission (FCC) Compliance Changes or modifications not approved by Ford Lincoln-Mercury could void user’s authority to operate the equipment. This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules.
Page 71 Be especially careful not to spill liquids of any kind onto the media controls or into the system. If liquid is accidentally spilled onto the system, immediately turn the system OFF and consult a qualified service technician. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 72: Navigation System
(headphone only mode) When the Family Entertainment System (FES) detects that the original radio supplied by Ford Motor Company has been removed from the vehicle, the FES will work in a state referred to as “Headphone Only Mode.” This mode allows the FES to operate as a standalone system, without interface to the radio.
Page 73: Climate Controls
Refer to Rear window defroster later in this chapter for more information. 5. A/C: Press to activate/deactivate air conditioning. Use with recirculated air to improve cooling performance and efficiency. Engages automatically in MAX A/C, (defrost) and (floor/defrost). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 74 3. REAR: Press to enable the control located in the rear of the floor console (if equipped), or to activate the auxiliary A/C system per the settings on the front control. Press again to turn the auxiliary system off. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 75 MAX A/C or O (OFF) when the vehicle is parked. This allows the vehicle to “breathe” using the outside air inlet vents. • Do not put objects under the front seats that will interfere with the airflow to the back seats. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 76: Dual Automatic Temperature Control
2. Rear temperature control: Press to enable the auxiliary system and set the desired rear cabin airflow temperature with the front control. The rear cabin airflow temperature will match the driver airflow temperature 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 77 15. Driver temperature control: Press to increase or decrease the temperature on the driver side of the cabin. Sets the passenger side temperature also when DUAL is disengaged. Note: The recommended vehicle cabin setting is between 72°F (22°C) and 75°F (24°C). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 78 (REAR) is illuminated. The rear cabin airflow temperature will be warmer or cooler than the driver airflow temperature setting when more than one rear temperature bar (REAR) is illuminated. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 79 (1 indicator light). Press again to deactivate the passenger cooled seat. 12. F Front fan speed control: Press to manually increase or decrease the fan speed. To return to full automatic control, press AUTO. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 80 • Do not put objects under the front seats that will interfere with the airflow to the back seats. • Remove any snow, ice or leaves from the air intake area at the base of the windshield. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 81: Rear Window Defroster
This may cause damage to the heated grid lines and will not be covered by your warranty. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 82: Lights
Pull headlamp control towards you to turn foglamps on. The foglamp indicator light will illuminate. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 83 The Daytime Running Lamp (DRL) system does not activate the tail lamps and generally may not provide adequate lighting during these conditions. Failure to activate your headlamps under these conditions may result in a collision. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 84 (a piece of masking tape works well). 3. Turn on the low beam headlamps to illuminate the wall or screen and open the hood. Cover one of the headlamps so no light from that lamp hits the wall. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 85: Turn Signal Control
7. Repeat Steps 3–5 for the other headlamp. 8. Close the hood and turn off the lamps. TURN SIGNAL CONTROL • Push down to activate the left turn signal. • Push up to activate the right turn signal. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 86 • any of the remote entry controls are pressed and the ignition is OFF. Press the controls to activate the lamps. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 87: Bulb Replacement
“D.O.T.” for North America to ensure lamp performance, light brightness and pattern and safe visibility. The correct bulbs will not damage the lamp assembly or void the lamp assembly warranty and will provide quality bulb burn time. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 88 To replace all instrument panel lights - see your authorized dealer * To obtain replacement approach lamp assembly bulbs, see your authorized dealer and reference Ford part no. 2L1Z–13B374–BB for the passenger side mirror and 2L1Z–13B375–BB for the driver side mirror.
Page 89 9. Install the headlamp assembly and secure with two retainer bolts. Replacing front parking lamp/turn/sidemarker signal bulbs 1. Make sure that the headlamp control is in the OFF position. 2. Open the hood. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 90 DO NOT TIP THE LAMP ASSEMBLY SIDEWAYS. 4. Rotate the bulb socket counterclockwise and remove from lamp assembly. 5. Pull bulb straight out of socket and snap in the new bulb. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 91 2. Carefully disconnect the bulb from the harness assembly via the two snap clips. Install the new bulb in reverse order. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 92 3. Disconnect the bulb assembly from the lens. 4. Remove and replace the bulb. 5. Align the turn signal lens clip with the slot in the mirror assembly and carefully press the lens in. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 93 3. While holding the clip in the release position, pull the approach light module down. 4. Remove the two wires from the module and replace the module with a new one. 5. Reverse the order to reassemble the approach light module. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 94: Driver Controls
Select: 2 — Normal speed operation of rear wiper. 1 — Intermittent operation of rear wiper. OFF — Rear wiper and washer off. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 95: Steering Wheel Adjustment
Rotate the visor towards the side window and extend it rearward for additional sunlight coverage. Note: To stow the visor back into the headliner, visor must be retracted before moving it back towards the windshield. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 96 The door will open to full open position. The rear view mirror may have to be adjusted to its lower arm position to prevent interference when the conversation mirror is extended down. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 97 2. Utility compartment, Coin holder slots, Tissue box holder 3. Power point and Rear audio controls (if equipped) 4. Rear Cupholders Use only soft cups in the cupholder. Hard objects can injure you in a collision. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 98 Always keep the power point caps closed when not being used. A second auxiliary power point is located on the rear side of the center console. The power point is accessible from the rear seats. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 99 The lighter will be released from its heating position when it is ready to be used. Improper use of the lighter can cause damage not covered by your warranty. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 100: Power Windows
• Lowering a front window approximately two to three inches or • Open 3rd Row Power Quarter Glass, for vehicles equipped with this option 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 101 (darken) to minimize glare. The mirror will automatically return to the normal state whenever the vehicle is placed in R (Reverse) to ensure a bright clear view when backing up. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 102: Mirrors
If the click is not heard, use the switch to fold the mirrors out, then in, until the click is heard. After that, the mirrors will operate to their normal positions until they are again moved manually. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 103 These actions could cause damage to the glass and mirrors. Signal indicator mirrors (if equipped) When the turn signal is activated, the lower portion of the mirror housing will blink. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 104: Speed Control
Setting speed control The controls for using your speed control are located on the steering wheel for your convenience. 1. Press the ON control and release 2. Accelerate to the desired speed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 105 Resuming a set speed Press the RES (resume) control and release it. This will automatically return the vehicle to the previously set speed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 106 SET + control. Turning off speed control There are two ways to turn off the speed control: • Depress the brake pedal. This will not erase your vehicle’s previously set speed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 107 SEEK advance through preset channels or subscribed channels. In CD mode: • Press SEEK to select the next selection on the CD or press and hold to forward or reverse the CD. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 108 In any mode: • Press VOL + or − to adjust volume. Climate control features (if equipped) Press TEMP + or - to adjust temperature. Press FAN + or - to adjust fan speed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 109: Moon Roof
To close, press and hold the rear or front control until the glass panel stops moving. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 110 ACC position for programming and/or operation of the HomeLink . It is also recommended that a new battery be placed in the hand-held transmitter of the device being programmed to HomeLink for quicker training and accurate transmission of the radio-frequency signal. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 111 “learn” or “smart” button (usually near where the hanging antenna wire is attached to the unit). 6. Firmly press and release the “learn” or “smart” button. (The name and color of the button may vary by manufacturer.) 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 112 HomeLink . The indicator light will flash slowly and then rapidly after HomeLink accepts the radio frequency signal. • Proceed with Step 4 in the “Programming” section. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 113 2. The indicator light will begin to flash after 20 seconds. Without releasing the HomeLink button, follow Step 2 in the “Programming” section. For questions or comments, contact HomeLink at www.homelink.com or 1–800–355–3515. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 114: Message Center
• Distance to Empty • Average Fuel Economy (AFE) • Outside Air Temperature (OAT) • Compass • Setup Menu • Blank Display Odometer/Trip odometer Refer to Gauges in the Instrument Cluster chapter. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 115 It is important to press the RESET stem (press and hold for 2 seconds in order to reset the function) after setting the speed control to get accurate highway fuel economy readings. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 116 Compass zone adjustment (if equipped) 1. Determine which magnetic zone you are in for your geographic location by referring to the zone map. 2. Turn ignition to the ON position. 7 8 9 1011 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 117 4. Slowly drive the vehicle in a circle (less than 5 km/h [3 mph]) until the CIRCLE SLOWLY TO CALIBRATE display changes to CALIBRATION COMPLETED. It will take up to five circles to complete calibration. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 118 SETUP MENU display sequence. If the RESET stem is not pressed within 4 seconds, the message center display returns to the SETUP MENU entry message “HOLD RESET FOR SETUP MENU”. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 119 Note: Oil Life Start Value of 100% equals 5,000 miles (8,000 km) or 180 days. For example, setting Oil Life Start Value to 60% sets the Oil Life Start Value to 3,000 miles (4,828 km) and 120 days. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 120 ON or OFF. 3. Press the RESET stem for the next SETUP MENU item or wait for more than 4 seconds to return to the INFO MENU (“HOLD RESET FOR SETUP MENU” will appear). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 121 • They will not reappear until an ignition OFF-ON cycle has been completed. • They reappear if the condition clears then reoccurs within the same ignition ON-OFF cycle. This acts as a reminder that these warning conditions still exist within the vehicle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 122 CHECK CHARGING SYSTEM. Displayed when the electrical system is not maintaining proper voltage when the engine is running. If you are operating electrical accessories when the engine is idling at a low speed, 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 123 When oil life left reaches 0%, the OIL CHANGE REQUIRED message will be displayed. LIFTGATE/GLASS AJAR. Displayed when the liftgate or the liftgate glass is not completely closed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 124 • Trip odometer • Distance to Empty • Average Fuel Economy • Instantaneous Fuel Economy • Trip Elapsed Drive Time • Blank Screen Odometer/Trip odometer Refer to Gauges in the Instrument Cluster chapter. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 125 1. Determine your magnetic zone by referring to the zone map. 2. Turn ignition to the ON position. 3. Start the engine. 4. From Setup menu, select the Update Zone function. 7 8 9 1011 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 126 Note: If the RESET control is pressed or 3 minutes has expired, the display will go back to the INFO menu and will show CAL instead of the compass heading until the compass is calibrated. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 127 It is important to press the RESET control (press and hold RESET for 2 seconds in order to reset the function) after setting the speed control to get accurate highway fuel economy readings. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 128 • Autolamp Delay (if equipped) • Air Suspension (if equipped) • Autolock (if equipped) • Power Liftgate (if equipped) • Easy Entry/Exit (if equipped) • Compass Zone (if equipped) • Compass Calibration (if equipped) • Language 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 129: Reset To English
P (Park), select this function from the SETUP control for the current display mode. 2. Press the RESET control to turn the air suspension OFF or ON. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 130 SETUP menu for the current language to be displayed. 2. Waiting 4 seconds or pressing the RESET control cycles the message center through each of the language choices. Selectable languages are English, Spanish, or French. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 131 6. BRAKE FLUID LEVEL 7. TIRE PRESSURE SYSTEM (if equipped) 8. AIR SUSPENSION SYSTEM (if equipped) 9. FUEL LEVEL System warnings System warnings alert you to possible problems or malfunctions in your vehicle’s operating systems. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 132 Liftgate/glass ajar Check charging system Tire pressure sensor fault (if equipped) Low tire pressure (if equipped) Tire pressure monitor fault (if equipped) 4x4 shift in progress (if equipped) Air suspension OFF (if equipped) 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 133 ON to OFF. It appears on the display when the vehicle is in reverse and will not go away until the vehicle is no longer in reverse. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 134 For more information on how the system operates under these conditions, refer to Understanding Your Tire Pressure Monitoring System in the Tires, 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 135 5 percent or less. When oil life left is between 5% and 0%, the CHANGE OIL SOON message will be displayed. When oil life left reaches 0%, the OIL CHANGE REQUIRED message will be displayed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 136 TO EXIT 4X4 SHIFT TO N (if equipped). Displayed when 2WD is selected while the vehicle has been stopped in 4X4 LOW. For more information, refer to Control trac four-wheel drive (4x4) operation in the Driving chapter. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 137 • or the ignition is in Run and the transmission is not in Park • or the Battery Voltage is below the minimum operating voltage WARNING: Make sure all persons are clear of the power liftgate area before using the power liftgate control. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 138 Note: If weight is added to the gate (bike rack, snow, etc.) the gate may automatically start a power close event immediately after a power open. In this mode a unique continuous chime will sound. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 139 Resetting the power liftgate: The power liftgate may not operate under these conditions. If any of these conditions occur, the power liftgate must be reset. • a low voltage or dead battery 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 140 Liftgate window To open the liftgate window, push the button on the left side of the liftgate handle above the license plate. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 141 1. To open, lift up on the handle and cover. 2. To close, lower the cover and press down on the handle until the latch clicks. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 142 Do not load any objects on the shelf that may obstruct your vision or strike occupants of the vehicle in the case of a sudden stop or collision. Do not place people or pets on or under the parcel shelf. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 143 Always ensure that the load is secure before traveling. Ford Motor Company recommends loading the roof rack only when equipped with (optional) crossbars, to avoid unintended damage to the roof panel.
Page 144: Locks And Security
The autolock feature will lock all the doors, liftgate and liftgate window when: • all doors are closed, • the ignition is in the 3 (ON) position, • you shift into any gear putting the vehicle in motion, and 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 145 (one short and one long chirp) if autolock was activated. 7. Turn the ignition to the 1 (OFF/LOCK) position. The horn will chirp once to confirm the procedure is complete. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 146 Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 147 Press the control a second time within three seconds to unlock all doors and liftgate. Locking the doors/liftgate Press this control to lock all doors and liftgate. The park/turn signal lamps will flash once. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 148 If any of the doors or liftgate are ajar, the horn will make two quick chirps, reminding you to properly close all doors. Opening the liftgate window Press the control to unlatch the liftgate window. • 4–button remote 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 149 Sounding a panic alarm Press this control to activate the alarm. The personal panic alarm will cycle the horn and parking lamps on/off. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 150 Press the control once to unlock the driver’s door. Pressing the control will automatically move the seat, rearview mirrors, and adjustable pedals to the desired memory position (the memory position corresponds to the transmitter being used). • 4–button remote 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 151 SET control on the memory seat control. 3. Repeat this procedure for another remote transmitter if desired. Replacing the battery The remote entry transmitter uses one coin type three-volt lithium battery CR2032 or equivalent. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 152 • Take all your vehicle’s transmitters to your dealer for programming, or • Perform the programming procedure yourself. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 153 The system automatically turns off after 25 seconds or when the ignition is turned to the 2 (ACCESSORY) or 3 (ON) position. The dome lamp control must not be set to the off position for the illuminated entry system to operate. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 154 7. Press the power door unlock control twice within 5 seconds. Note: The horn will chirp once to indicate the perimeter lighting feature has 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 155 • The factory set code will work even if you have set your own personal code. Erasing personal code 1. Enter the factory set 5–digit code. 2. Within five seconds, press the 1 • 2 on the keypad and release. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 156 The SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Theft indicator The theft indicator is located in the instrument cluster.
Page 157 OFF position and restart the engine with all other objects on the key ring held away from the ignition key. Check to make sure the coded key is an approved Ford coded key. 2007 Expedition (exd)
Page 158 (ON) for at least three seconds but no more than ten seconds]. 4. Turn the ignition from the 3 (ON) back to 1 (OFF/LOCK) position in order to remove the second coded key from the ignition. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 159 Steps 1 through 5. If failure repeats, bring your vehicle to your authorized dealer to have the new spare key(s) programmed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 160: Seating And Safety Restraints
Never adjust the driver’s seat or seatback when the vehicle is moving. Do not pile cargo higher than the seatbacks to reduce the risk of injuring people in a collision or sudden stop. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 161 Reclining the seatback can cause an occupant to slide under the seat’s safety belt, resulting in severe personal injuries in the event of a collision. Pull the seatback handle up to recline the seat. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 162 Using the manual lumbar support (if equipped) The lumbar support control is located on the outboard side of the seat. Turn the lumbar support control clockwise for more support. Turn the lumbar support counter-clockwise for less support. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 163 The control is located on the outboard side of the seat cushion. Move the switch in the direction of the arrows to raise or lower the front portion of the seat cushion. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 164 • Continue pressing the control until it reaches the end of the seat track. • Continue pressing the control for approximately 2 seconds. You will feel the seat bounce back slightly. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 165 (back and cushion) to stabilize. The heated seats and the cooled seats will only function when the ignition is in RUN. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 166 To remove an air filter: • Remove key from ignition. • Push up on the outside rigid edge of the filter and rotate toward the front of the vehicle once tabs are released. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 167 Move the front passenger seat forward so that the second row seat headrest clears the front seat. For assistance, refer to the label located on the side of the seat cushion. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 168 To return the seat to the upright position: 1. Lift the seatback toward the rear of the vehicle. 2. Rotate the seatback until you hear a click, locking it in the upright position. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 169 Always return the seat from the kneel position prior to raising the seatback. Failure to do so could result in personal injury. To place the seats in the cargo mode: 1. Fold down the 2nd row seat. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 170 The E-Z entry seat allows for easier entry and exit to and from the 3rd row seat. To enter the 3rd row seat: 1. Fold down the 2nd row seat and release the handle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 171 After returning the seatback to its original position, pull on the seatback to ensure that it has fully latched. An unlatched seat may become dangerous in the event of a sudden stop or collision. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 172 Folding the 2nd row center 20% seat system (if equipped) 1. Locate the release handle located in the upper left seat back, and pull the handle to release the folding seat latch. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 173 An unlatched seat may become dangerous in the event of a sudden stop or collision. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 174 Before folding the third row seats, fold the head restraints down by pulling on the strap located at the bottom of the restraint. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 175 Note: Be sure that the head restraints are folded down before powering the 3rd row seat down. The control buttons are located on the right-hand rear quarter trim panel (accessible from the liftgate area). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 176: Safety Restraints
Your vehicle’s Personal Safety System consists of: • Driver and passenger dual-stage airbag supplemental restraints. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 177 This allows your Personal Safety System to distinguish between different levels of crash severity and modify the deployment strategy of the dual-stage airbags and safety belt pretensioners. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 178 In addition, the RCM also monitors the restraints warning light in the instrument cluster. A difficulty with the system is indicated by one or more of the following: 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 179 Be sure everyone in your vehicle is in a seat and using a safety belt properly. In a rollover crash, an unbelted person is significantly more likely to die than a person wearing a safety belt. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 180 Make sure the tongue is securely fastened in the buckle. • Front and rear seats 2. To unfasten, push the release button and remove the tongue from the buckle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 181 In this mode, the shoulder belt is pre-locked. The belt will still retract to remove any slack in the shoulder belt. The automatic locking mode is not available on the driver safety belt. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 182 “automatic locking retractor” feature for child seats is still functioning properly, in addition to other checks for proper safety belt system function. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 183 To lower the shoulder belt height, squeeze the side release buttons with your thumb and finger and slide the height adjuster down. To raise the height of the shoulder belt, 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 184 D-ring, not the portion where the belt exits from the quarter trim panel.) 2. Slide the guide up or down along the webbing so that the belt is centered on the occupant’s shoulder. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 185 (if equipped), child safety seat LATCH and tether anchors, and attaching hardware, should be inspected after a collision. Ford Motor Company recommends that all safety belt assemblies in use in vehicles involved in a collision be replaced.
Page 186 The Belt-Minder feature uses two different warning chimes. During the first minute of activation, the warning chime will sound once every second. The remaining warning chimes will sound twice every second while the system is activated. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 187 1 in 4 of us will be seriously injured in a crash during our lifetime. “I’m not going far” 3 of 4 fatal crashes occur within 25 miles of home. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 188 “I’d rather be thrown clear” Not a good idea. People who are ejected are 40 times more likely to DIE. Safety belts help prevent ejection, WE CAN’T “PICK OUR CRASH”. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 189 (Step 3 must be completed within 50 seconds after the safety belt warning light turns off.) • After Step 3, the safety belt warning light will be turned on for three seconds. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 190: Airbags
Airbags DO NOT inflate slowly; there is a risk of injury from a deploying airbag. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 191 (including frame, bumper, front end body structure and tow hooks) may affect the performance of the airbag system, increasing the risk of injury. Do not modify the front end of the vehicle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 192 The driver and passenger airbags are designed to inflate in frontal and near-frontal collisions, not rollover, side-impact, or rear-impacts unless the collision causes sufficient longitudinal deceleration. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 193 The RCM (restraints control module) monitors its own internal circuits and the supplemental airbag electrical system wiring (including the impact sensors, the system wiring, the airbag system readiness light, the airbag back up power and the airbag ignitors). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 194 See your authorized dealer. All occupants of the vehicle should always wear their safety belts even when an airbag SRS is provided. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 195 Rather, it means the forces were not of the type sufficient to cause activation. Side airbags are designed to inflate in side-impact collisions, not roll-over, rear-impact, frontal or near-frontal collisions, unless the collision causes sufficient lateral deceleration. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 196 Do not attempt to service, repair, or modify the Safety Canopy system, its fuses, the A, B, C or D pillar trim, or the headliner on a vehicle containing a Safety Canopy . See your authorized dealer. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 197 • Two crash sensors mounted in the front doors (one on each side of the vehicle). • Two crash sensors located at the C pillar behind the rear doors (one on each side of the vehicle). • Rollover sensor in the restraints control module (RCM). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 198 (including the A, B, C, and D pillar trim) must be inspected and serviced by an authorized dealer. If the Safety Canopy not replaced, the unrepaired area will increase the risk of injury in a collision. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 199: Child Restraints
12 in the rear seat of your vehicle. Accident statistics suggest that children are safer when properly restrained in the rear seating positions than in the front seating position. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 200 To improve the fit of both the lap and shoulder belt on children who have outgrown child safety seats, Ford Motor Company recommends use of a belt-positioning booster. Booster seats position a child so that safety belts fit better. They lift the child up so that the lap belt rests low across the hips and the knees bend comfortably.
Page 201 (top of ear level) above the top of the seat. In this case, move the backless booster to another seating position with a higher seat back and lap/shoulder belts. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 202 It is best to use a booster seat with lap/shoulder belts in the back seat- the safest place for children to ride. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 203 Carefully follow all of the manufacturer’s instructions with the safety seat you put in your vehicle. If you do not install and use the safety seat properly, the child may be injured in a sudden stop or collision. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 204 80 pounds (36 kg) using an upper torso harness and a belt-positioning booster. Ford recommends the use of a child safety seat having a top tether strap. Install the child safety seat in a seating position with LATCH and tether anchors.
Page 205 Children 12 and under should be properly restrained in the rear seat whenever possible. 1. Position the child safety seat in a seat with a combination lap and shoulder belt. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 206 Make sure the tongue is latched securely by pulling on it. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 207 (you should not be able to pull more belt out). If the retractor is not locked, unbuckle the belt and repeat Steps 2 through 9. Check to make sure the child seat is properly secured before each use. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 208 Some of the rear seats of your vehicle are equipped with built-in tether strap anchors located behind the seats as described below. In the third row center seating position, the tether anchor is a loop at the bottom of the seatback. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 209 Second row seating positions 1. Position the child safety seat on the seat cushion. 2. Locate the tether anchor at the bottom back of the seat. • outboard seating positions 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 210 (outboard seats) and over the back of the seat. 4. Grasp the tether strap and position it to the seat frame. 5. Rotate the tether strap, and clip the tether strap to the anchor on the seat frame. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 211 3. Locate the anchor webbing loop for the seating position. • You may need to pull back the top of the hinged panel along the bottom of the seat back to access the tether anchor. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 212 This type of child seat eliminates the need to use safety belts to attach the child seat. For forward-facing child seats, the tether strap must also be attached to the proper tether anchor. See Attaching safety seats with tether straps in this chapter. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 213 The locator symbols are on round plastic buttons on the center seat and on rectangular tags on the outboard seats. Follow the child seat manufacturer’s instructions to properly install a child seat with LATCH attachments. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 214 Also try to tug the seat forward. Check to see if the anchors hold the seat in place. If the safety seat is not anchored properly, the risk of a child being injured in a crash greatly increases. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 215: Tires, Wheels And Loading
A vehicle equipped with AWD or 4WD (when selected) has the ability to use all four wheels to power itself. This increases traction which may enable you to safely drive over terrain and road conditions that a conventional two-wheel drive vehicle cannot. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 216 All other things held equal, a shorter wheelbase may make your vehicle quicker to respond to steering inputs than a vehicle with a longer wheelbase. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 217: Tire Information
10 to 12 inches or limited production tires as defined in Title 49 Code of Federal Regulations Part 575.104(c)(2). U.S. Department of Transportation-Tire quality grades: The U.S. Department of Transportation requires Ford Motor Company to give you the following information about tire grades exactly as the government has written it.
Page 218 TIRES Tires are designed to give many thousands of miles of service, but they must be maintained in order to get the maximum benefit from them. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 219: Tire Inflation
INFLATING YOUR TIRES Safe operation of your vehicle requires that your tires are properly inflated. Remember that a tire can lose up to half of its air pressure without appearing flat. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 220 (if equipped), at least monthly and before long trips. You are strongly urged to buy a reliable tire pressure gauge, as automatic service station gauges may be inaccurate. Ford recommends the use of a digital or dial-type tire pressure gauge rather than a stick-type tire pressure gauge.
Page 221 7. Check the sidewalls to make sure there are no gouges, cuts or bulges. TIRE CARE Inspecting your tires Periodically inspect the tire treads for uneven or excessive wear and remove objects such as stones, nails or glass that may be wedged in the 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 222 You should replace your spare tire when you replace the road tires or after six years due to aging even if it has not been used. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 223 (such as P-metric versus LT-metric or all-season versus all-terrain) as those originally provided by Ford. The recommended tire and wheel size may be found on either the Safety Compliance Certification Label or the Tire Label which is located on the B-Pillar or edge of the driver’s door.
Page 224 4. Use both eye and ear protection. For a mounting pressure more than 20 psi greater than the maximum pressure, a Ford Dealer or other tire service professional should do the mounting. Always inflate steel carcass tires with a remote air fill with the person inflating standing at a minimum of 12 ft.
Page 225 Unless otherwise specified, rotate the tires approximately every 5,000 miles (8,000 km). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 226 This information identifies and describes the fundamental characteristics of the tire and also provides a U.S. DOT Tire Identification Number for safety standard certification and in case of a recall. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 227 These speed ratings may need to be adjusted for the difference in conditions. The ratings range from 81 mph (130 km/h) to 186 mph (299 km/h). These ratings are listed in the following chart. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 228 Refer to the Safety Compliance Certification Label, which is located on the B-Pillar or the edge of the driver’s door, for the correct tire pressure for your vehicle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 229 The cold inflation pressure should never be set lower than the recommended pressure on the vehicle label. The tire suppliers may have additional markings, notes or warnings such as standard load, radial tubeless, etc. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 230 4. Maximum Load Single lb. (kg) at psi (kPa) cold: Indicates the maximum load and tire pressure when the tire is used as a single; defined as two tires (total) on the rear axle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 231 B-Pillar or the edge of the driver’s door. Refer to the payload description and graphic in the Vehicle loading — with and without a trailer section. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 232: Tire Pressure Monitoring System (Tpms)
(at least monthly) using a tire gauge, see Inflating your tires in this chapter. Failure to properly maintain your tire pressure could increase the risk of tire failure, loss of control, vehicle rollover and personal injury. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 233 To restore the full functionality of the Tire Pressure Monitoring System, have the damaged road wheel/tire repaired and remounted on your vehicle. For additional information, refer to Changing tires with TPMS in this section. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 234 TPMS If your tires are properly malfunction inflated and your spare tire is not in use and the light remains ON, have the system inspected by your authorized dealer. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 235 If the low tire pressure warning light is ON, visually check each tire to verify that no tire is flat. (If one or more tires are flat, repair as necessary.) Check air pressure in the road tires. If 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 236: Vehicle Loading
Follow these guidelines when using snow tires and chains: • Use only cable type chains or chains offered by Ford as an accessory or equivalent. Other conventional link type chains may contact and cause damage to the vehicle’s wheel house and/or body.
Page 237 Overloading or improperly loading your vehicle can contribute to loss of vehicle control and vehicle rollover. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 238 GAW (Gross Axle Weight) – is the total weight placed on each axle (front and rear) – including vehicle curb weight and all payload. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 239 Exceeding the Safety Compliance Certification Label vehicle weight rating limits could result in substandard vehicle handling or performance, engine, transmission and/or structural damage, serious damage to the vehicle, loss of control and personal injury. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 240 GVWR and GAWR limitations. Replacement tires with a higher limit than the original tires do not increase the GVWR and GAWR limitations. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 241 2 years. Measuring the inside of the vehicle with the rear seat folded down, you have room for 12-100 lb. (45 kg) bags of cement. Do you have enough load capacity to transport the 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 242: Trailer Towing
Follow these guidelines to ensure safe towing procedure: • Stay within your vehicle’s load limits. If exceeded, cargo should be removed from the trailer and/or the vehicle until all weights are within specified limits. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 243 Note: Before towing a trailer, make sure the trailer brakes (if equipped) and lamps are properly connected and functional. Electronic trailer brakes (if equipped) refer to the instructions provided by the aftermarket electronic brake controller manufacture for determining trailer brake functionality. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 244 (3.4 square meters [36.5 square feet]). Note: For vehicles equipped with the optional trailer tow package, the maximum frontal area of trailer should not exceed 5.6 square meters (60 square feet). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 245 Tires, Wheels and Loading Rear axle Maximum GCWR Trailer weight range Engine ratio - lb. (kg) (0 - maximum) lb. (kg) Expedition EL (U.S. Only) Expedition Max (Canada Only) 4x2 5.4L with standard 12200 (5534) 0–6000 (0–2721) trailer tow package 5.4L with...
Page 246 1. Park the unloaded vehicle on a level surface. With the ignition in the ON position and all doors closed, allow the vehicle to stand (without passengers) for several minutes so that it can level. 2. Turn the air suspension (if equipped) control to OFF. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 247 Trailer lamps are required on most towed vehicles. Make sure all running lights, brake lights, turn signals and hazard lights are working. See your authorized dealer or trailer rental agency for proper instructions and equipment for hooking up trailer lamps. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 248 • If you are driving down a long or steep hill, shift to a lower gear. Do not apply the brakes continuously, as they may overheat and become less effective. • The trailer tongue weight should be 10–15% of the loaded trailer weight. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 249 Replace the rear axle lubricant any time the axle has been submerged in water. Rear axle lubricant quantities are not to be checked or changed unless a leak is suspected or repair required. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 250: Recreational Towing
If a distance of 50 miles (80 km) or a speed of 35 mph (56 km/h) must be exceeded, the drive shaft will have to be removed before the vehicle is towed. Ford recommends the driveshaft be removed/installed only by a qualified technician at an authorized dealer. See your authorized dealer for driveshaft removal/installation.
Page 251: Driving
Do not start your vehicle in a closed garage or in other enclosed areas. Exhaust fumes can be toxic. Always open the garage door before you start the engine. See Guarding against exhaust fumes in this chapter for more instructions. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 252 Seating and Safety Restraints chapter. 2. Make sure the headlamps and vehicle accessories are off. 3. Make sure the gearshift is in P (Park). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 253 1. Turn the key to 4 (START) without pressing the accelerator pedal and release once the engine starts. The key will return to 3 (ON). 2. When the engine starts, release the key. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 254 Replacement rubber caps are available through the authorized dealer, 3L1Z-6E088-AA. Use of an engine block heater is strongly recommended if you live in a region where temperatures reach -10°F (-23°C) or below. For best 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 255: Brakes
The ABS performs a self-check after you start the engine and begin to drive away. A brief 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 256 BRAKE brake warning light also remains illuminated with parking brake released. (If your brake warning lamp illuminates, have your vehicle serviced immediately.) 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 257 However, if the normal brakes fail, the parking brake can be used to stop your vehicle in an emergency. Since the parking brake applies only the rear brakes, the vehicle’s stopping distance will increase greatly and the handling of your vehicle will be adversely affected. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 258: Traction Control™/Advancetrac
Excessive wheel spin is controlled by momentarily reducing engine power and/or applying the anti-lock brakes. Traction Control is a driver aid that helps your vehicle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 259 • Changing lanes on a snow-rutted road. • Entering a snow-free road from a snow-covered side street, or vice versa. • Entering a paved road from a gravel road, or vice versa. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 260 AdvanceTrac with RSC button for more than five seconds will further disable the brake portion of the Traction Control feature and the “sliding car” icon will flash momentarily and then illuminate steady. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 261 AdvanceTrac with RSC system. Also, do not install a stereo loudspeaker near the front center console or tunnel or under either front seat as the vibrations can adversely affect the AdvanceTrac with RSC sensors located in this area. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 262 If the steering wanders or pulls, check for: • Underinflated tire(s) on any wheel(s) • Uneven vehicle loading • High crown in center of road 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 263: Air Suspension
Normal vehicle operation does not require any action by the driver. On vehicles equipped with air suspension, turn the air suspension and the ignition switch off prior to jacking, hoisting or towing your vehicle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 264: Transmission Operation
This vehicle is equipped with a park/brake-shift interlock feature that prevents the gearshift lever from being moved from P (Park) when the ignition is in the ON position unless brake pedal is depressed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 265 Always set the parking brake fully and make sure the gearshift is latched in P (Park). Turn the ignition to the LOCK position and remove the key whenever you leave your vehicle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 266 (Neutral) position. 4. Remove tool and reinstall the protective cover. 5. Start the vehicle and release the parking brake. Do not drive your vehicle until you verify that the brakelamps are working. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 267 • Move the gearshift lever into the desired gear. If your vehicle is equipped with a floor-shift transmission, press the gearshift lever release button (on the front of the lever) while shifting into the desired gear. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 268 Overdrive can be deactivated by pressing the transmission control switch on the end of the gearshift lever (column-shift transmission) or on the side of the gearshift lever (floor-shift transmission). • Column-shift transmission 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 269 2 (Second) Transmission operates in 2nd gear only. Use 2 (Second) to start-up on slippery roads or to provide additional engine braking on downgrades. 1 (First) • Transmission operates in 1st gear only. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 270 The system is designed to provide a warning to assist the driver in detecting objects to avoid damaging the vehicle. The system may not detect smaller objects, particularly those close to the ground. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 271 Speed above 2.5 mph (4 km/h) up to 1.6 feet (.5 meters) Solid 1.6 feet (.5 meters) to 3.1 feet Fast beep (1 meter) 3.1 feet (1 meter) to 5.7 feet Medium/fast beep (1.8 meters) 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 272 These elements may cause the system to operate inaccurately. If the vehicle sustains damage to the rear bumper/fascia, leaving it misaligned or bent, the sensing zone may be altered causing inaccurate measurement of obstacles or false alarms. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 273 Instrument Cluster chapter. • 4X4 AUTO – displays when 4A is selected. • 4X4 – displays when 4H is selected. • 4X4 LOW – displays when 4L is selected. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 274 This will disable the engine management feature, allowing the vehicle to maintain full power and enhanced momentum through the obstacle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 275 Four–wheel drive vehicles are specially equipped for driving on sand, snow, mud and rough terrain and have operating characteristics that are somewhat different from conventional vehicles, both on and off the road. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 276 • It may be safer to stay on the apron or shoulder of the road and slow down gradually before returning to the pavement. You may lose control if you do not slow down or if you turn the steering wheel too sharply or abruptly. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 277 See your authorized dealer. Do not spin the wheels at over 35 mph (56 km/h). The tires may fail and injure a passenger or bystander. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 278 Information on transfer case maintenance can be found in the Maintenance and Specifications chapter. You should become thoroughly familiar with this information before you operate your vehicle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 279 As when you are driving over sand, apply the accelerator slowly and avoid spinning your wheels. If the vehicle does slide, steer in the direction of the slide until you regain control of the vehicle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 280 Ford Motor Company joins the U.S. Forest Service and the Bureau of Land Management in encouraging you to help preserve our national forest and other public and private lands by “treading lightly.”...
Page 281 In emergency stopping situations, apply the brake forcefully and steadily. Do not “pump” the brakes. Refer to the Brakes section of this chapter for additional information on the operation of the anti-lock brake system. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 282 Ford Motor Company recommends that caution be used with any vehicle equipped with a high load or device (such as ladder racks or pickup box cover).
Page 283: Roadside Emergencies
Ford and Mercury vehicles, and six years or 70,000 miles (110,000 km) on Lincoln vehicles. Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start •...
Page 284: Hazard Flasher Switch
1–800–241–3673; Lincoln vehicle customers call 1–800–521–4140. Canadian customers who require roadside assistance, call 1–800–665–2006. If you need to arrange roadside assistance for yourself, Ford Motor Company will reimburse a reasonable amount. To obtain reimbursement information, U.S. Ford or Mercury vehicles customers call 1–800–241–3673;...
Page 285: Fuel Pump Shut-Off Switch
4. Turn the ignition to the ON position. Pause for a few seconds and return the key to the OFF position. 5. Make a further check for leaks in the fuel system. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 286: Fuses And Relays
Blue Natural Natural — — — Green Green Green Pink Pink — — Orange Green Green — — — — Blue Yellow Yellow — — — Brown — — Natural Black Black 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 287 To reinstall the fuse box cover, place the top part of the cover on the fuse panel, then push the bottom part of the cover until you hear it click shut. Gently pull on the cover to make sure it is seated properly. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 288 Climate control — Not used All lock motor feeds, Liftgate release, Liftglass release Not used (Spare) Rear wiper Adjustable pedals, Datalink Fog lamps, Cornering lamps Park lamps relay High beam headlamps Horn relay 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 289 Delayed accessory relay Power distribution box The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 290 Rear window defroster relay 30A** Third row seats (driver side) 40A** Trailer tow connector (electric brake) 60A** ABS (valves) — Not used 40A** Heated/cooled seats 60A** ABS (pump) 20A** Rear console power point 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 291 Power liftgate 40A** Rear window defroster, Heated mirror 30A** Passenger seat 10A* A/C clutch 15A* Brake lamps 20A* Fuel pump 20A* Back-up lamps 25A* Trailer tow connector (stop/turn lamps) 20A* 4x4 module 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 292 Trailer tow connector relay (park lamp) — Trailer tow connector relay (battery charge) — Run/Start relay — Not used — PCM relay — One-touch Start diode — A/C clutch diode — Fuel pump diode 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 293: Changing Tires
Tire Pressure Monitor System (TPMS) sensor. The use of tire sealants may damage your tires. The use of tire sealants may also damage your Tire Pressure Monitoring System. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 294 Ford. If the dissimilar spare tire or wheel is damaged, it should be replaced rather than repaired.
Page 295 • Driving vehicles equipped with a camper body • Driving vehicles with a load on the cargo rack Drive cautiously when using a full-size dissimilar spare tire/wheel and seek service as soon as possible. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 296 Item Location Spare tire Under the vehicle, just forward of the rear bumper Jack tools and jacking instructions Under the access panel located in the floor compartment behind the rear seat 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 297 5. To remove the spare tire, turn the handle counterclockwise until the tire is lowered to the ground and the cable is slightly slack. 6. Slide the retainer through the center of the spare tire wheel. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 298 Refer to the instruction sheet (located in the rear floor compartment behind the 3rd row seat with the jack tray tools assembly kit) for detailed tire change instructions. 1. Park on a level surface, activate hazard flashers and set the parking brake. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 299 Note: Use the frame rail as the jacking location point, NOT the control arm. 7. Raise the vehicle to provide sufficient ground clearance when installing the spare tire; approximately 1/4 inch (6 mm). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 300 If on a grade, block both opposite wheels on the downward side of the hill. If the vehicle slips off the jack, someone could be seriously injured. • Front • Rear 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 301 14. Turn on the air suspension system (if equipped). Refer to Message center in the Driver Controls chapter for instructions on turning the air suspension system on. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 302 Close the access hole with the rubber plug. Reinstall the tray into the vehicle and secure it with the wing nut (turn clockwise until tight). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 303: Lug Nut Torque
M14 x 2.0 * Torque specifications are for nut and bolt threads free of dirt and rust. Use only Ford recommended replacement fasteners. When a wheel is installed, always remove any corrosion, dirt or foreign materials present on the mounting surfaces of the wheel or the surface of the wheel hub, brake drum or brake disc that contacts the wheel.
Page 304 Connecting the jumper cables 1. Connect the positive (+) jumper cable to the positive (+) terminal of the discharged battery. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 305 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. 3. Connect the negative (-) cable to the negative (-) terminal of the assisting battery. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 306 2. Start the engine of the disabled vehicle. 3. Once the disabled vehicle has been started, run both engines for an additional three minutes before disconnecting the jumper cables. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 307 Remove the jumper cables in the reverse order that they were connected. 1. Remove the jumper cable from the jump starting stud. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 308 Roadside Emergencies 2. Remove the jumper cable on the negative (-) connection of the booster vehicle’s battery. 3. Remove the jumper cable from the positive (+) terminal of the booster vehicle’s battery. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 309 4. Remove the jumper cable from the positive (+) terminal of the disabled vehicle’s battery. After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 310: Wrecker Towing
It is recommended that your vehicle be towed with a wheel lift or flatbed equipment. Do not tow with a slingbelt. Ford Motor Company has not approved a slingbelt towing procedure. Also, wrecker towing the vehicle by the frame-mounted tow hooks is not recommended or advised.
Page 311 • Do not exceed a distance of 50 miles (80 km). • Do not exceed 35 mph (56 km/h) vehicle speed. Ford Motor Company produces a towing manual for all authorized tow truck operators. Have your tow truck operator refer to this manual for proper hook-up and towing procedures for your vehicle.
Page 312: Customer Assistance
Center at 1-800-392-3673 (FORD). Away from home If you own a Ford or Mercury vehicle and are away from home when your vehicle needs service, or if you need more help than the authorized dealer could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealer to help you.
Page 313 If you own a Lincoln vehicle and are away from home when your vehicle needs service, or if you need more help than the authorized dealer could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealer to help you.
Page 314 Customer Assistance In some states (in the U.S.) you must directly notify Ford in writing before pursuing remedies under your state’s warranty laws. Ford is also allowed a final repair attempt in some states. In the United States, a warranty dispute must be submitted to the BBB...
Page 315 You are not bound by the decision but may choose to accept it. If you choose to accept the BBB AUTO LINE decision then Ford must abide by the accepted decision as well. If the arbitrator has decided in...
Page 316 (CANADA ONLY) For vehicles delivered to authorized Canadian dealers. In those cases where you continue to feel that the efforts by Ford of Canada and the authorized dealer to resolve a factory-related vehicle service concern have been unsatisfactory, Ford of Canada participates in an impartial third party mediation/arbitration program administered by the Canadian Motor Vehicle Arbitration Plan (CAMVAP).
Page 317 Customer Assistance If you did not take advantage of the Ford Extended Service Plan at the time of purchasing your vehicle, you may still be eligible. Since this information is subject to change, please ask your authorized dealer for complete details about Ford Extended Service Plan coverage options, or visit the Ford ESP website at www.ford-esp.com.
Page 318: Reporting Safety Defects (U.s. Only)
However, NHTSA cannot become involved in individual problems between you, your dealer, or Ford Motor Company. 2007 Expedition (exd)
Page 319: Reporting Safety Defects (Canada Only)
REPORTING SAFETY DEFECTS (CANADA ONLY) If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform Transport Canada, using their toll-free number: 1–800–333–0510. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 320: Cleaning
• Never use abrasive materials such as steel wool or plastic pads as they can scratch the chrome surface. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 321 • Do not use hydrofluoric acid-based or high caustic-based wheel cleaners, steel wool, fuels or strong household detergent. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 322 Use only approved products to clean plastic parts. These products are available from your authorized dealer. • For routine cleaning, use Motorcraft Detail Wash (ZC-3-A). • If tar or grease spots are present, use Motorcraft Bug and Tar Remover (ZC-42). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 323 (ZC-38-A) on the instrument panel and interior trim areas. • Avoid cleaners or polishes that increase the gloss of the upper portion of the instrument panel. The dull finish in this area helps protect the driver from undesirable windshield reflection. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 324 (but do not oversaturate) or the ring will set. • Do not use household cleaning products or glass cleaners, which can stain and discolor the fabric and affect the flame retardant abilities of the seat materials. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 325 If this occurs, the leather should be cleaned immediately to avoid permanent staining. UNDERBODY Flush the complete underside of your vehicle frequently. Keep body and door drain holes free from packed dirt. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 326 Cleaning FORD AND LINCOLN MERCURY CAR CARE PRODUCTS Your Ford or Lincoln Mercury authorized dealer has many quality products available to clean your vehicle and protect its finishes. These quality products have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and appearance of your vehicle.
Page 327: Maintenance And Specifications
2. Block the wheels. To reduce the risk of vehicle damage and/or personal burn injuries do not start your engine with the air cleaner removed and do not remove it while the engine is running. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 328 2. Go to the front of the vehicle and release the auxiliary latch that is located under the front center of the hood. 3. Lift the hood until the lift cylinders hold it open. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 329: Engine Compartment
2. Engine oil dipstick 3. Brake fluid reservoir 4. Engine coolant reservoir 5. Air filter assembly 6. Power steering fluid reservoir 7. Power distribution box 8. Engine oil filler cap 9. Battery 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 330 Checking and adding washer fluid for the liftgate Washer fluid for the liftgate is supplied by the same reservoir as the windshield. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 331 3. Pull the wiper blade toward the base of the wiper arm and remove it from the arm. 4. Attach the new wiper to the wiper arm and press it into place until a click is heard. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 332: Engine Oil
DO NOT ADD OIL. • If the oil level is below this mark, engine oil must be added to raise the level within the normal operating range. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 333 1/4 of a turn until the cap is fully seated. To avoid possible oil loss, DO NOT operate the vehicle with the engine oil level indicator and/or the engine oil filler cap removed. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 334 Change your engine oil and filter according to the appropriate schedule listed in scheduled maintenance information. Ford production and aftermarket (Motorcraft) oil filters are designed for added engine protection and long life. If a replacement oil filter is used that does not meet Ford material and design specifications, start-up engine noises or knock may be experienced.
Page 335: Battery
Lift the battery with a battery carrier or with your hands on opposite corners. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 336 D (Drive) and allow the engine to idle for at least one minute. 7. Drive the vehicle to complete the relearning process. • The vehicle may need to be driven 10 miles (16 km) or more to relearn the idle and fuel trim strategy. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 337: Engine Coolant
50–50 mixture of coolant and water provides the following: • Freeze protection down to -34°F (-36°C). • Boiling protection up to 265°F (129°C). • Protection against rust and other forms of corrosion. • Enables calibrated gauges to work properly. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 338 If sprayed on the windshield, engine coolant could make it difficult to see through the windshield. • Add Motorcraft Premium Gold Engine Coolant or equivalent meeting Ford specification WSS-M97B51-A1. Refer to Maintenance product specifications and capacities in this chapter. 2007 Expedition (exd)
Page 339 Motorcraft Premium Gold Engine Coolant from yellow to golden tan. • Do not add/mix an orange-colored, extended life coolant such as Motorcraft Specialty Orange Engine Coolant, meeting Ford specification WSS-M97B44-D, or DEX-COOL brand with the factory-filled coolant. Mixing Motorcraft Specialty Orange Engine...
Page 340 Recycled engine coolant Ford Motor Company does NOT recommend the use of recycled engine coolant in vehicles originally equipped with Motorcraft Premium Gold Engine Coolant since a Ford-approved recycling process is not yet available.
Page 341 The “fail-safe” distance depends on ambient temperatures, vehicle load and terrain. How fail-safe cooling works If the engine begins to overheat: • The engine coolant temperature gauge will move to the red (hot) area. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 342 Take your vehicle to an authorized dealer as soon as possible. FUEL FILTER For fuel filter replacement, see your authorized dealer. Refer to scheduled maintenance information for the appropriate intervals for changing the fuel filter. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 343: Fuel Information
The toxic effects of fuel may not be visible for hours. • Avoid inhaling fuel vapors. Inhaling too much fuel vapor of any kind can lead to eye and respiratory tract irritation. In severe cases, 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 344 • Stay outside your vehicle and do not leave the fuel pump unattended when refueling your vehicle — this is against the law in some places; • Keep children away from the fuel pump; never let children pump fuel. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 345 The customer warranty may be void for any damage to the fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is not used. The fuel system may be under pressure. If the fuel filler cap is venting vapor or if you hear a hissing sound, wait until it stops before completely removing the fuel filler cap.
Page 346 Do not be concerned if your engine sometimes knocks lightly. However, if it knocks heavily under most driving conditions while you are using fuel with the recommended octane rating, see your authorized dealer to prevent any engine damage. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 347 Ask your fuel supplier about gasolines that meet the World-Wide Fuel Charter. Cleaner air Ford endorses the use of reformulated “cleaner-burning” gasolines to improve air quality, per the recommendations in the Choosing the Right Fuel section. Running out of fuel Avoid running out of fuel because this situation may have an adverse effect on powertrain components.
Page 348 • Have the vehicle loading and distribution the same every time. Your results will be most accurate if your filling method is consistent. Calculating fuel economy 1. Fill the fuel tank completely and record the initial odometer reading (in miles or kilometers). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 349 • You may want to turn off the speed control in hilly terrain if unnecessary shifting between the top gears occurs. Unnecessary shifting of this type could result in reduced fuel economy. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 350 • Close windows for high speed driving. EPA window sticker Every new vehicle should have the EPA window sticker. Contact your authorized dealer if the window sticker is not supplied with your vehicle. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 351 If other than Ford, Motorcraft or Ford-authorized parts are used for maintenance replacements or for service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability.
Page 352 No additional vehicle service is required. If the indicator remains on, have your vehicle serviced at the first available opportunity. Although some malfunctions detected by the 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 353 I/M testing, the above driving cycle will have to be repeated. POWER STEERING FLUID Check the power steering fluid. Refer to the scheduled maintenance information for the service interval schedules. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 354 (i.e., if the transmission slips or shifts slowly) or if you notice some sign of fluid leakage. Transmission fluid should be checked by an authorized dealer. If required, fluid should be added by an authorized dealer. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 355: Air Filter(S)
This connector will need to be unplugged. 2. Reposition the locking clip on the connector (connector shown from below for clarity), squeeze the connector and pull it off of the air outlet tube. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 356 Push the air filter cover toward the center of the vehicle and up slightly to release it. 6. Remove the air filter element from the air filter housing. 7. Install a new air filter element. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 357 10. Reconnect the Mass Air Flow Sensor electrical connector to the outlet tube. Make sure the locking tab on the connector is in the “locked” position (connector shown from below for clarity). 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 358: Part Numbers
PCV valve. Replace the PCV valve with one that meets Ford material and design specifications for your vehicle, such as a Motorcraft or equivalent replacement part. The customer warranty may be void for any damage to the emissions system if such a PCV valve is not used.
Page 359: Maintenance Product Specifications And Capacities
Maintenance and Specifications 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 360 Maintenance and Specifications 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 361 Maintenance and Specifications 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 362 Maintenance and Specifications 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 363: Engine Data
87 octane Firing order 1-3-7-2-6-5-4-8 Ignition system Coil on plug Spark plug gap 0.040–0.050 inch (1.02–1.27 mm) Compression ratio 9.85:1 Spark plug gap not adjustable Engine drivebelt routing • 5.4L V8 Engine 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 364 Vehicle identification number (VIN) The vehicle identification number is located on the driver side instrument panel. XXXXXXXXXXXXXXXXX Please note that in the graphic, XXXX is representative of your vehicle identification number. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 365 TRANSMISSION/TRANSAXLE CODE DESIGNATIONS You can find a transmission/transaxle code on the Safety Compliance Certification Label. The following table tells you which transmission or transaxle each code represents. Description Code Six-speed automatic (6R75) 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 366: Accessories
GENUINE FORD ACCESSORIES FOR YOUR VEHICLE A wide selection of Genuine Ford Accessories are available for your vehicle through your local Ford or Ford of Canada dealer. These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance of your vehicle.
Page 367 • Electrical or electronic accessories or components that are added to the vehicle by the authorized dealer or the owner may adversely affect battery performance and durability. 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 368: Index
Changing a tire ......293 fluid, refill capacities ....359 Child safety restraints ....200 fluid, specification ....359 child safety belts ....200 Auxiliary Input Jack ....38 Child safety seats ......203 Auxiliary power point ....98 in front seat ......205 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 369 ......359 Getting roadside assistance ...283 service points ......329 Getting the service you starting after a collision ..285 need .........312 Engine block heater ....254 Ordering additional owner’s literature .........318 Engine oil ........332 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 370 ..342, 358 Ignition .......251, 363 fuel pump shut-off switch ..285 Illuminated visor mirror .....95 improving fuel economy ..348 Infant seats octane rating ....346, 363 (see Safety seats) .....203 quality ........347 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 371 ..83 instrument panel, dimming ..84 interior lamps .....86, 88 replacing bulbs ....88, 91 Octane rating ......346 Lane change indicator Oil (see Engine oil) ....332 (see Turn signal) ......85 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 372 Remote entry system ....146 illuminated entry ....153 Snowplowing .........8 locking/unlocking doors ..147 Spare tire opening the trunk ...148–149 (see Changing the Tire) ...296 panic alarm ......149 replacement/additional Spark plugs, specifications .....358, 363 transmitters ......152 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Page 373 ..........94 snow tires and chains ....236 checking and adding fluid ..330 spare tire .........294 liftgate reservoir .....330 terminology ......219 replacing wiper blades ...331 tire grades .......218 treadwear ......218, 222 Wrecker towing ......310 2007 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)

This manual is also suitable for:

2007 expedition

Ford Expedition Owner's Manual

Introduction

Instrument Cluster

Entertainment Systems

Climate Controls

Lights

Driver Controls

Locks and Security

Seating and Safety Restraints

Tires, Wheels and Loading

Driving

Roadside Emergencies

Customer Assistance

Cleaning

Maintenance and Specifications

Accessories

Index

Quick Links

Table of Contents

Related Manuals for Ford Expedition

Summary of Contents for Ford Expedition

This manual is also suitable for:

Table of Contents