1
SERVICE MANUAL
Level 1&2
Nokia 500
RM-750
Transceiver characteristics
Band
GSM EDGE 850/900/1800/1900 MHz
WCDMA 850/900/1700/1900/2100 MHz
Display
3,2" nHD capacitive touch TFT color display
640x360 pixel resolution
16:9 aspect ratio
Camera
5 megapixel full focus (EDOF) CMOS
Operating System
Symbian Anna
Connections
WLAN 802.11 b/g
Bluetooth 2.1
Integrated A-GPS
3.5mm AV connector
Transceiver with BL-4U battery pack
Talk time
GSM: Up to 7 hours
WCDMA: Up to 5 hours
Note:
Talk times are dependent on network parameters
and phone settings
Conf idential | Copyright © 2011 Nokia | A ll rights reserved
Nokia 500 (RM-750)
L1L2 Service Manual
Standby
GSM: Up to 500 hours
WCDMA: Up to 455 hours
Version 1.0

   Also See for Nokia 500

   Related Manuals for Nokia 500

   Summary of Contents for Nokia 500

  • Page 1

    GSM: Up to 500 hours WCDMA: Up to 5 hours WCDMA: Up to 455 hours Note: Talk times are dependent on network parameters and phone settings Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 2: Table Of Contents

    BATTERY INFORMATION..............................8 EXPLODED VIEW ................................. 9 SERVICE DEVICES ................................10 SOFTWARE UPDATE................................11 DISASSEMBLY INSTRUCTIONS ............................12 10. ASSEMBLY HINTS................................18 11. SOLDER COMPONENTS ..............................19 Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 3

    02.08.2011 First approved version The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA service suppliers, and the content of it is confidential. Please note that NOKIA provides also other guidance documents (e.g.

  • Page 4: Copyright

    Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice. Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.

  • Page 5: Warnings And Cautions, Warnings, Cautions

    3. Use only approved components as specified in the parts list. 4. Ensure all components, modules screws and insulators are correctly re–fitted after servicing and alignment. 5. Ensure all cables and wires are repositioned correctly Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 6: Esd Protection

    ESD protected spare part packages MUST NOT be opened/closed out of an ESD Protected Area. For more information and local requirements about ESD protection and ESD Protected Area, contact your local Nokia After Market Services representative. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 7: Care And Maintenance

    All of the above suggestions apply equally to the product, battery, charger or any accessory. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 8: Battery Information

    Batteries’ performance is particularly limited in temperatures well below freezing. Do not dispose batteries in a fire! Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 9: Exploded View

    SCREW TORX+ SIZE 6 M 1.4 X 4 BATTERY COVER I0016 I0017 Only available Not reuseable Repair/swap Ver. 1.0 as assembly after removal only in level 3 Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 10: Service Devices

    Service Bulletin (SB-011) on Nokia Online. Supplier or manufacturer Battery BL-4U SS-88 Camera Removal tool contacts for tool re-order can be found in “Recommended service equipment” document on Nokia Online. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 11: Software Update

    To use the FLS-5 Flash Dongle, follow the user guide inside the sales package. Please check always for the latest version of flash software, which is available on Nokia Online. Conf idential | Copyright © 2011 Nokia | A ll rights reserved...

  • Page 12: Disassembly Instructions

    4) Open the BATTERY COVER by pushing it to the film. direction shown. 5) Remove the BATTERY COVER. 6) Unscrew the four TORX+ size 6 screws in the order shown. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 13

    11) Use the AV plug to remove the AV JACK. 12) Use the DC plug to remove the DC JACK. Be careful not to damage the gasket around the DC JACK. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 14

    18) Open the locking mechanism of the DISPLAY end as shown. Be careful not to damage the DISPLAY connector with the SS-93. Be careful not to damage connector. the connector while opening it. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 15

    23) Remove the DISPLAY ADHESIVE with the tweezers. 24) Lift up the DISPLAY with the SS-93 from the Do not use it again. Discard it. shown place. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 16

    30) Carefully lift up the PROXIMITY SENSOR PWB with the tweezers. Do not use it again. Discard it. the dental tool. Be careful not to damage the PROXIMITY SENSOR PWB. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 17

    Nokia 500 (RM-750) L1L2 Service Manual 31) Remove the PROXIMITY SENSOR PWB with the 32) The Nokia 500 disassembly is now complete. tweezers. -END OF DISASSEMBLY- Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 18: Assembly Hints

    Nokia 500 (RM-750) L1L2 Service Manual 10. ASSEMBLY HINTS 1) Tighten the TORX + size 6 screws to the torque of 12 Ncm. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

  • Page 19: Solder Components

    L1L2 Service Manual 11. SOLDER COMPONENTS S2403 V2402 S2405 V2401 V2400 S2404 X1563 X1564 BOTTOM E6105 X7403 F3300 X7402 F3301 S2401 S2402 S2400 E3001 Ver. 1.0 Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 1.0...

This manual also for:

603, 701

Comments to this Manuals

Symbols: 0
Latest comments: