Port A Cool Port-A-Cool Owner's Manual

Port A Cool Port-A-Cool Owner's Manual

Electric models

Advertisement

Port-A-Cool® Products and Accessories
Küül® Pads Cooling Media
are manufactured by
manufactured by port-a-cool, llc
Port-A-Cool, LLC
P.O. Box 2167 • 709 Southview Circle • Center, TX 75935
Phone 936-598-5651 • 800-695-2942
PAC-ACC-03
and
®
www.port-a-cool.com

Owners Manual

For All Electric Models
Manufactured by Port-A-Cool, LLC
Port-A-Cool®,
Port-A-Cool JetStream™
and Cyclone™
product lines
READ AND SAVE
THESE INSTRUCTIONS
For

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Port-A-Cool and is the answer not in the manual?

Questions and answers

Ryan
July 16, 2025

I need to know the fan motor specifications for the PAC2K3618 port a cool unit.

Summary of Contents for Port A Cool Port-A-Cool

  • Page 1: Owners Manual

    Owners Manual For All Electric Models Manufactured by Port-A-Cool, LLC Port-A-Cool®, Port-A-Cool JetStream™ and Cyclone™ product lines Port-A-Cool® Products and Accessories Küül® Pads Cooling Media are manufactured by ® manufactured by port-a-cool, llc Port-A-Cool, LLC P.O. Box 2167 • 709 Southview Circle • Center, TX 75935 Phone 936-598-5651 •...
  • Page 2 QUICK SET UP GUIDE Q. WHERE CAN I BUY REPLACEMENT PARTS? A. Unit replacement parts may be purchased from any Port-A-Cool® product distributor or directly from Port-A-Cool® Parts/Technical Support department. You may also visit www.port-a-coolparts. com to order online.
  • Page 3: Table Of Contents

    B. Connecting the water and electricity or air. located in the back of your Port-A-Cool® unit, have never been wet. The resin in the pads will emit an odor the first time you wet them that lasts approximately one to three weeks. Keep the unit in III.
  • Page 4: Safe Operation

    Object jammed into impeller blade. Remove object. adapter is attached to the water inlet on the side of the PORT-A-COOL® unit, which is below the spray bar adjustment and drain valves. A standard garden hose is attached to this brass hose adapter and cinched switch is turned on, but Air Locked.
  • Page 5: Operating Procedures

    1) Fresh Air Supply - The inlet side of the PORT-A-COOL® unit (pad side) must be placed so as to insure that a smooth, uninterrupted supply of fresh air is available. PORT-A-COOL® unit overflows from...
  • Page 6: Filling With Water

    Refer to Section II, Part B for details on connecting to a water supply line. Once the unit is connected to a water supply, turn on the supply valve allowing the PORT-A-COOL® unit sump tank to fill with water. Once the sump tank by foreign material.
  • Page 7: Maintenance & Storage

    Once the sump is drained and the power disconnected, the pads may be removed to allow inspection of the sump tank. Assuming that the PORT-A-COOL® unit is in a dusty environment, dust will collect in the turns and makes humming sound.
  • Page 8: Technical Support

    The most common problems encountered with a PORT-A-COOL® unit are operational problems. The PORT-A-COOL® unit consists of three systems. It is important to determine which system of the PORT-A-COOL® unit the problem is asso- Please have serial number and model number of unit available.
  • Page 9 (Figure 4 NExT PAGE) PAGE 29 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL • PAGE 6...
  • Page 10 8) Replace pads by installing pads from outside toward center replacing center pad last. Replace pad flap with Hose screws. Connection Electrical Plug Locking Casters (Figure 2) (Figure 3) (Figure 1) PAGE 7 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL • PAGE 28...
  • Page 11 Remove the bracket and hose from the pump by loosening the Electrical Plug fastening screws and hose clamp. 8) Install new pump by reversing above steps. (Figure 2) Hose Connection Locking Casters PAGE 27 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL • PAGE 8...
  • Page 12: Exploded Views And Parts Lists By Model

    PAC-PLB-01 INLET HOSE ADAPTER TUBE-03 SIGHT TUBE PAD6022/26 KUUL PAD SET FOR CYCLONE 220/50 and 220/60 models may require additional parts. Please contact Customer Service at 936-598-5651 for assistance PAGE 9 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL •PAGE 26...
  • Page 13 PUMP TO SPRAYBAR CONTROL VALVE MOTOR-013-04 1/6HP VOSTERMAN MOTOR VENT16-INJ-01 VENTURI FOR 16" FAN 220/50 and 220/60 models may require additional parts. Please contact Customer Service at 936-598-5651 for assistance PAGE 25 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL • PAGE 10...
  • Page 14 VALVE-01 1/2” GATE VALVE LOUVERS-JS-24 LOUVER W/MESH FOR 24” JS/VT VENTURI-24-02 24” VENTURI 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance PAGE 11 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL • PAGE 24...
  • Page 15 PAC163SVT ORG. SN# &SUBSEQUENT VI. WIRING DIAGRAM for TWO-SPEED MODELS NEW 09/29/2009 Port-A-Cool, LLC 2009 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance PAGE 23 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL • PAGE 12...
  • Page 16 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance 220/50 and 220/60 models may require additional parts. Please contact Customer Service at 936-598-5651 for assistance PORT-A-COOL OWNER’S MANUAL • PAGE 22 PAGE 13 • PORT-A-COOL OWNER’S MANUAL...
  • Page 17 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance PAGE 21 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL • PAGE 14...
  • Page 18 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance PAGE 15 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL • PAGE 20...
  • Page 19 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance PAGE 19 • PORT-A-COOL OWNER’S MANUAL PORT-A-COOL OWNER’S MANUAL • PAGE 16...
  • Page 20 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance 220/50 and 220/60 models require additional parts. Please contact Customer Service at 936-598-5651 for assistance PORT-A-COOL OWNER’S MANUAL • PAGE 18 PAGE 17 • PORT-A-COOL OWNER’S MANUAL...

Table of Contents