Maintenance Safety - MULTIQUIP WHISPERWATT DCA-15SPXU4 Operation Manual

■ ALWAYS be sure the operator is familiar with proper safety
precautions and operation techniques before using
generators.
■ NEVER leave the generator unattended, turn off engine when
unattended.
■ Unauthorized equipment modifications will void all warranties.
■ ALWAYS ensure generator is on level ground before use.
■ DO NOT place hands or fingers inside generators engine
compartment when engine is running.
■ NEVER run engine without air cleaner. Severe engine damage
may occur.
■ NEVER
change or adjust the engine speed which has been
set at the factory prior to shipping.
Power Cord Safety
■ NEVER let power cables or cords lay in wate r.
■ NEVER stand in water while AC power from the generators
is being transfer to a load.
■ NEVER use a defective or frayed power cable. Check the
cable for cuts in the insulation.
■ NEVER use a extension cord that is frayed or damaged where
the insulation has been cut.
■ ALWAYS make certain that proper power or extension cord
has been selected for the job See Table 6.
Grounding Safety
■ ALWAYS make sure that electrical circuits are properly
grounded per the National Electrical Code (NEC) and
local codes before operating generator. Severe injury or
death! by electrocution can result from operating an
ungrounded generator.
■ ALWAYS make sure the generators are properly grounded to
a suitable earth ground (GROUND ROD). See installation in
this manual.
■ NEVER use gas piping as an electrical ground.
DCA-15SPXU4— OPERATION MANUAL — REV. #0 (03/31/11) — PAGE 11
DCA-15SPXU4 — RULES FOR SAFE OPERATION

Maintenance Safety

■ NEVER lubricate components or attempt service on a running
■ High Temperatures – Always stop engine and
allow the engine to cool before adding fuel, oil
or performing service and maintenance
functions. Contact with hot! components can
cause serious burns.
■ Keep the machinery in proper running condition.
■ Fix damage to the machine immediately and replace any
■ ALWAYS replace any worn or damaged warning decals.
■ ALWAYS store equipment properly when it is not being used.
Equipment should be stored in a clean, dry location out of the
reach of children and un-authorized personnel.
■ The electrical voltage required to operate the generator can
cause severe injury or even death through physical contact
with live circuits. Turn all circuit breakers OFF before
performing maintenance on the generator.
■ Dispose of hazardous waste properly. Examples of potentially
■ DO NOT use food or plastic containers to dispose of
■ DO NOT pour waste, oil or fuel directly onto the ground,
■ ALWAYS allow the machine a proper amount of time to
■ ALWAYS service air cleaner frequently to prevent engine
■ ALWAYS disconnect the NEGATIVE battery terminal
■ Follow all battery safety guidelines listed in this manual
machine.
broken parts immediately.
hazardous waste are used motor oil, fuel and fuel filters.
hazardous waste.
down a drain or into any water source.
cool before servicing.
malfunction.
before performing service on the generator.
when handleing or servicing the generator.
1