Whisperwatt series 60hz generator (cummins qsb7-g6 diesel engine) (90 pages)
Summary of Contents for MULTIQUIP WHISPERWATT DCA10SPX4
Page 1
WHISPERWATT SERIES MODEL DCA10SPX4 MODEL DCA10SPXU4 50 Hz GENERATORS (KUBOTA D1503-M DIESEL ENGINE) (DCA10SPX4 S/N 3819207~) (DCA10SPXU4 S/N 8710001~) Revision #0 (08/05/09) To find the latest revision of this publication, visit our website at: www.mqpower.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
Page 2
DCA10SPX4/DCA10SPXU4 — PROPOSITION 65 WARNING Diesel engine exhaust and some of PAGE 2 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 3
DCA10SPX4/DCA10SPXU4 — NOTE PAGE DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 3...
❒ ❒ ❒ ❒ ❒ Applicable Model Number All orders are treated as Standard Orders and will ship the same day if received WE ACCEPT ALL MAJOR CREDIT CARDS! DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 5...
DANGER - ELECTROCUTION HAZARDS During operation of this generator, there exists the possibility of electrocution, electrical shock or burn, which can cause severe bodily harm or even DEATH! PAGE 8 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
This can take several hours to burn off the accumulated unburned fuel. DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 9...
Disconnection of any of these devices will void all Manufacturer does not assume responsibility for any warranties. accident due to equipment modifications. Unauthorized equipment modification will void all warranties. PAGE 10 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 11
ALWAYS make sure the generators are properly grounded when handleing or servicing the generator. to a suitable earth ground (GROUND ROD). See installation in this manual. NEVER use gas piping as an electrical ground. DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 11...
Page 12
In case the battery liquid (dilute sulfuric acid) comes in contact with your EYES , rinse eyes immediately with plenty of water and contact the nearest doctor or hospital to seek medical attention. PAGE 12 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 13
Failure to do so could result in electrical shock or burn causing serious injury or even death! DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 13...
Page 14
ALWAYS attach trailer’s safety chains to towing vehicle properly. ALWAYS make sure the vehicle and trailer directional, backup, brake, and trailer lights are connected and working properly. PAGE 14 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 15
NOTE PAGE DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 15...
Page 17
NFPA 110, Chapter 5-4.1). DO NOT remove the metal skids on the bottom of the generator. They are to resist damage to the bottom of the generator and to maintain alignment. DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 17...
(load) is held to a minimum. Use the cable selection chart (Table 6) as a guide for selecting proper extension cable size. PAGE 18 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Fuel Tank Assembly Engine and Radiator Assembly Muffler Assembly Figure 3. Major Components Generator Assembly Battery Assembly Generator Control Panel Assembly Output Receptacles Assembly Ground Terminal Assembly DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 19...
Page 20
18. Main Circuit Breaker – This three-pole, 45A main Speed Control Switch –This switch controls the speed breaker is provided to protect the the generator from of the engine (idle/high). overload. PAGE 20 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 22
Turning the knob clockwise will increase the voltage, turning the knob counter-clockwise will decrease the voltage. Figure 7. CS6369 Twist-Lock Auxiliary Receptacle Figure 10. Voltage Regulator Control Knob PAGE 22 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 23
3-pole, 45A main circuit breaker is provided. Make sure to switch ALL circuit breakers to the OFF position prior to starting the engine. Figure 11. Connecting Loads DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 23...
Page 24
. t f Single Phase 40 amps . t f . t f . t f 200 Volt t l u o r f t l o PAGE 24 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
■ ■ ■ ■ ■ API Service Classification CC/SE ■ ■ ■ ■ ■ API Service Classification CC/SF Table 8. Recommended Motor Oil OIL: SAE Figure 13. Internal Fuel Tank System DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 25...
ONLY! use #2 diesel fuel when refueling. Figure 17. Fuel Expansion 2. Remove fuel cap (internal fuel tank) and fill fuel tank as shown Figure 15. Figure 15. Fueling the Generator PAGE 26 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 27
F - C ° F ° When the antifreeze is mixed with NOTE water, the antifreeze mixing ratio must be less than 50%. DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 27...
Page 28
Tighten all hose clamps and check hoses for leaks. If any hose ( fuel or oil ) lines are defective replace them immediately. Figure 19. Battery Connections PAGE 28 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
4. The generator's frequency meter (Figure 24) should be displaying the 50 cycle output frequency in HERTZ. 4. Close all engine enclosure doors (Figure 21). Figure 21. Engine Enclosure Doors Figure 24. Frequency Meter (Hz) DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 29...
Figure 30. Ammeter (Load) Figure 27. Main, GFCI, and Aux. Circuit Breakers (ON) 11. The generator will run until manually stopped or an abnormal condition occurs. PAGE 30 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Place key in a safe place where it will not be lost. 4. Inspect entire generator for any damage or loosening of components that may have occured during operation. DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 31...
Page 32
This can be air element, press the dust indicator button to reset the reduced by keeping the tank full with diesel fuel. indicator. PAGE 32 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 33
DO NOT spill the fuel during disassembly. place on blocks so tires do not touch the ground or block Vent any air. and completely remove the tires. DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 33...
Page 34
. d i PAGE 34 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 35
SNUG FIT ONLY PARTS MUST ROTATE FREELY SHACKLE BOLT LOCKING NUTS OR COTTER PINS ARE PROVIDED SPRING EYE BOLT TO RETAIN NUT BOLT ASSEMBLY SHOULDER TYPE SHACKLE BOLT DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 35...
Page 36
" 3 " 4 " 5 " 6 Figure 33. Wheel Lug Nuts Tightening Sequence NEVER use an pneumatic air NOTE gun to tighten wheel lug nuts. PAGE 36 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
A blank entry generally indicates that the item is not sold separately or is not sold by Multiquip. Other entries will be clarified in the “Remarks” Column. PAGE 44 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 71
0221700640 RUBBER SEAL 0229400920 RUBBER SEAL 0229200590 RUBBER SEAL 0229200255 RUBBER SEAL 0229400545 RUBBER SEAL 0229400250 RUBBER SEAL 0227500380 RUBBER SEAL 0227500080 RUBBER SEAL 0229400660 RUBBER SEAL DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 71...
Prices are subject to change without prior zation must accompany the return notice. Price changes are effective on a shipment. 4. Freight is at the sender’s expense. All PAGE 74 — DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09)
Page 75
NOTE PAGE DCA10SPX4/DCA10SPXU4 — OPERATION AND PARTS MANUAL — REV. #0 (08/05/09) — PAGE 75...