Table of Contents
Advertisement
Jet intakes
1
2
3
Jet Thrust Intakes
Intake Grates
1
2
3
4
11
12
13
Before launching the boat, carefully
11
12
13
14
check the jet intakes under the boat
21
22
23
for weeds, debris, or anything else
21
22
23
24
31
32
33
that might restrict the intake of water.
If the intakes are clogged, cavitation
31
32
33
34
41
42
43
could occur, reducing jet thrust, and
41
42
43
44
possibly damaging jet pump parts. In
51
52
53
some cases, the engine may overheat
51
52
53
54
because of a lack of cooling water, and
damage could result. Engine cooling
water is fed to the engine by the jet
pumps (see page 3-10).
Refer to Jet pump Clean-out proce-
dures on page 5-5 before attempting
to remove weeds or debris from the jet
intake or impeller areas. WarninG!
rotating parts could cause severe
injury or death. Before attempting to
remove weeds or debris from the jet
intake or impeller areas; shut off the
engines, remove ignition key, then
remove the engine shut-off switch
cord from the shut-off switch.
1
11
21
1
2
3
31
11
12
13
41
4
5
6
7
8
51
21
22
23
5
6
7
8
9
14
15
16
17
18
31
32
33
15
16
17
18
19
24
25
26
27
41
42
43
25
26
27
28
34
35
51
36
52
37
53
35
36
37
38
44
45
46
47
45
46
47
48
54
55
56
57
55
56
57
58
Fuel System
Refer to page 4-10, "FUEL SYSTEM
INSPECTION," for correct procedure.
2
3
4
5
Fuel and Engine oil Levels
12
13
14
15
1) Turn the right switch key to ON. Wait
22
23
24
25
4
5
6
7
8
32
33
34
35
tip: The fuel level is most accurate
14
15
16
17
18
42
43
44
45
when the boat is sitting level on the
9
10
52
53
54
55
24
25
26
27
trailer or in the water.
10
19
20
34
35
36
37
2) Open the engine hatch, then check
20
28
29
30
44
45
46
47
29
30
38
54
39
55
40
56
57
Battery
39
40
48
49
50
Check the battery condition and the
49
50
58
59
60
battery electrolyte level. Make sure con-
nections are tight and that battery is
59
60
properly secured. WarninG! the bat-
tery must always be fully charged
and in good condition. Loss of bat-
tery power may leave you stranded.
never operate the boat if the battery
does not have sufficient power to
start the engine or if it shows any
other signs of decreased power.
Drainage System
Self-Bailing Deck—
Most water which enters the deck area
bails automatically out the stern through
the large drain hole in the deck.
3-7
O
PERATION
6
7
8
9
10
16
17
18
19
20
for the fuel gauge needle to stop
26
27
28
29
moving, then note the fuel level. Add
9
10
fuel if necessary.
36
37
38
39
19
20
46
47
48
49
56
57
58
59
28
29
30
38
39
40
oil level in the engines. Add as nec-
48
49
50
essary (see page 3-2).
58
59
60
3
30
40
50
60
Advertisement
Chapters
Table of Contents
