ELECTRONICS
This Service Manual is a property of Samsung Electronics Co .,Ltd.
Any unauthorized use of Manual can be punished under applicable
International and/or domestic law.
© Samsung Electronics Co., Ltd. SEP. 2003
Printed in Korea
AK82-00404A
DVD-L200W
DVD-L200
SERVICE
PORTABLE DVD PLAYER
Manual
CONTENTS

   Also See for Samsung DVD-L200W

   Summary of Contents for Samsung DVD-L200W

  • Page 1: Portable Dvd Player

    4. Electrical Parts List 5. Block Diagram 6. Schematic Diagrams This Service Manual is a property of Samsung Electronics Co .,Ltd. © Samsung Electronics Co., Ltd. SEP. 2003 Any unauthorized use of Manual can be punished under applicable Printed in Korea International and/or domestic law.

  • Page 2: Precautions

    Metal Part cal return path to the chassis. Any current measured must not exceed 0.5mA. Reverse the instrument power cord plug in the out- ohmmeter let and repeat the test. See Fig. 1-1. Fig. 1-2 Insulation Resistance Test Samsung Electronics...

  • Page 3

    (5) antenna wiring. Always inspect in all areas tinuously and new instructions are issued whenev- for pinched, out-of-place, or frayed wiring, Do not er appropriate. change spacing between a component and the printed-circuit board. Check the AC power cord for damage. Samsung Electronics...

  • Page 4: Servicing Precautions

    Components identi- fied by shading, by( ) or by ( ) in the circuit dia- gram are important for safety or for the characteris- tics of the unit. Always replace them with the exact replacement components. Samsung Electronics...

  • Page 5

    (6) Do not remove a replacement ESD device from its protective package until immediately before your are ready to install it.(Most replacement ESD devices are packaged with leads electrically short- ed together by conductive foam, aluminum foil or comparable conductive materials). Samsung Electronics...

  • Page 6

    ◆ Be sure to put on a wrist strap grounded to the sheet. ◆ Be sure to lay a conductive sheet made of copper etc. Which is grounded to the table. Samsung Electronics...

  • Page 7

    3) Make solder land 3 points short on Pick-up FPC. (See Fig. 1-4) 4) Disassemble the Pick-up. Note : If the assembly and disassembly are not done in correct sequence, the Pick-up may be damaged. ASS'Y-DVD DECK FPC (Bottom View) SOLDER LAND 3 POINTS SHORT Fig. 1-4 Samsung Electronics...

  • Page 8: Troubleshooting

    2. Troubleshooting Samsung Electronics...

  • Page 9

    Troubleshooting Samsung Electronics...

  • Page 10

    Troubleshooting Samsung Electronics...

  • Page 11

    Troubleshooting Samsung Electronics...

  • Page 12

    Troubleshooting Samsung Electronics...

  • Page 13

    Troubleshooting Samsung Electronics...

  • Page 14

    Troubleshooting Samsung Electronics...

  • Page 15

    Troubleshooting Samsung Electronics...

  • Page 16: Exploded Views And Parts List

    3-2 Deck Assembly - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - Notice You can search for the updated part code through ITSELF web site. URL; http://itself.sec.samsung.co.kr...

  • Page 17: Cabinet Assembly

    Exploded Views and Parts List 3-1 Cabinet Assembly...

  • Page 18

    AH66-00224A LEVER-LCD SW;DVD-L200,POM,-,-,-,-,-,- 6001-001618 SCREW-MACHINE;PWH,+,M2,L3,ZPC(YEL),SWRCH 6001-001718 SCREW-MACHINE;BH,+,M2,L5,NI PLT AK92-00215E ASSY PCB-MAIN A;DVD-L200W/XSH,MAIN-A Asia Only AK92-00215K ASSY PCB-MAIN A;DVD-L200W/XEL,MAIN A Other Only AK92-00215J ASSY PCB-MAIN A;DVD-L200W/XST,MAIN A U.A.E Only AK92-00216A ASSY PCB-MAIN B;DVD-L200/XAA,ASSY PCB MA AK92-00217A ASSY PCB-KEY;DVD-L200/XAA,KEY PCB ASSY AH92-01542A ASSY PCB-TERMINAL;DVD-L100,TERMINAL...

  • Page 19: Deck Assembly

    Exploded Views and Parts List 3-2 Deck Assembly H115 H101 H103 H104 H112 S.N.A. H116 H102 H116 H104 H104 H117 H107 H113 H114 H105 H111 H116 H109 H115 H106 H110 H108 H116...

  • Page 20

    Exploded Views and Parts List Loc. No Parts No. Description ; Specification Remark H101 AK63-00023A COVER-PU;DP-P2,SUS 304 T=0.3,-,-,-,-,- H102 AK61-00080A BRACKET-SHAFT;DP-P2,POM,-,-,-,-,- H103 AK61-00081A BRACKET-TILT;DP-P2,POM,-,-,-,-,- H104 AK73-00010A RUBBER-INSULATOR;-,BYUTL,-,50,-,BLK,-,-, H105 AK97-00319A ASSY-FEED MOTOR;-,PORTABLE2,- H106 AK61-00076A BRACKET-SPINDLE MOTOR;DP-P2,POM,-,-,-,-, H107 AK97-00320A ASSY-LEAD SCREW;-,PORTABLE2,- H108 AK66-00020A SHAFT-PU;DP-P2,SUS420J2,-,-,-,-,- H109...

  • Page 21

    Exploded Views and Parts List MEMO...

  • Page 22: Electrical Parts List

    2404-000256 C-TA,CHIP;47UF,20%,16V,GP,TP,7343 AR174 2007-000090 R-CHIP;10Kohm,5%,1/10W,TP,1608 AE155 2404-000299 C-TA,CHIP;22uF,20%,16V,-,TP,6032,- AR175 2007-000090 R-CHIP;10Kohm,5%,1/10W,TP,1608 AE165 2404-001001 C-TA,CHIP;10uF,10%,6.3V,GP,TP,3216,3.2mm AR176 2007-000127 R-CHIP;9.1Kohm,5%,1/10W,TP,1608 AE166 2404-000299 C-TA,CHIP;22uF,20%,16V,-,TP,6032,- AR177 2007-000127 R-CHIP;9.1Kohm,5%,1/10W,TP,1608 AE167 2404-001001 C-TA,CHIP;10uF,10%,6.3V,GP,TP,3216,3.2mm AR178 2007-000086 R-CHIP;5.6Kohm,5%,1/10W,TP,1608 Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 23

    C-CER,CHIP;1.5nF,10%,50V,X7R,TP,1608,- RC13 2203-000975 C-CER,CHIP;47nF,10%,25V,X7R,TP,1608,- 2404-001043 C-TA,CHIP;47uF,20%,10V,GP,TP,6032,- RC14 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608,- 2404-001043 C-TA,CHIP;47uF,20%,10V,GP,TP,6032,- RC15 2203-000975 C-CER,CHIP;47nF,10%,25V,X7R,TP,1608,- 2404-001043 C-TA,CHIP;47uF,20%,10V,GP,TP,6032,- RC16 2203-000257 C-CER,CHIP;10nF,10%,50V,X7R,TP,1608 2404-001043 C-TA,CHIP;47uF,20%,10V,GP,TP,6032,- RC17 2203-006035 C-CER,CHIP;220NF,+-10%,10V,X7R,TP,1608 2404-001043 C-TA,CHIP;47uF,20%,10V,GP,TP,6032,- RC18 2203-000236 C-CER,CHIP;0.1NF,5%,50V,C0G,TP,1608 Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 24

    2203-000257 C-CER,CHIP;10nF,10%,50V,X7R,TP,1608 RR31 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 2203-000491 C-CER,CHIP;2.2nF,10%,50V,X7R,TP,1608,- 2007-000091 R-CHIP;12Kohm,5%,1/10W,TP,1608 2203-000491 C-CER,CHIP;2.2nF,10%,50V,X7R,TP,1608,- 2007-000091 R-CHIP;12Kohm,5%,1/10W,TP,1608 0407-000101 DIODE-ARRAY;DA204K,20V,100mA,C2-3,SOT-23 2007-000086 R-CHIP;5.6Kohm,5%,1/10W,TP,1608 2404-001001 C-TA,CHIP;10uF,10%,6.3V,GP,TP,3216,3.2mm 2007-000077 R-CHIP;470ohm,5%,1/10W,TP,1608 SE101 2404-000259 C-TA,CHIP;47uF,20%,6.3V,-,TP,6032,- 2007-000312 R-CHIP;10ohm,5%,1/4W,TP,3216 SE102 2404-000259 C-TA,CHIP;47uF,20%,6.3V,-,TP,6032,- Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 25

    SR35 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 XCON1 3708-001866 CONNECTOR-FPC/FFC/PIC;40P,0.5MM,SMD-S,SN SR36 2007-000074 R-CHIP;100ohm,5%,1/10W,TP,1608 XCON2 3708-001731 CONNECTOR-FPC/FFC/PIC;50P,0.5MM,SMD-S,SN SR39 2007-000116 R-CHIP;120ohm,5%,1/10W,TP,1608 XCON2B 3809-001387 CABLE-FLAT;30V,80C,70MM,50P,0.5MM,UL758 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 XD501 0404-001173 DIODE-SCHOTTKY;RB081L-20,20V,4000MA,SOD- SR40 2007-000109 R-CHIP;1Mohm,5%,1/10W,TP,1608 XE501 2404-000259 C-TA,CHIP;47uF,20%,6.3V,-,TP,6032,- Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 26

    2007-000052 R-CHIP;10Kohm,1%,1/10W,TP,1608 ZR109 2007-000113 R-CHIP;33ohm,5%,1/10W,TP,1608 XR503 2007-000052 R-CHIP;10Kohm,1%,1/10W,TP,1608 ZR11 2007-000084 R-CHIP;4.7Kohm,5%,1/10W,TP,1608 XR504 2007-000100 R-CHIP;68Kohm,5%,1/10W,TP,1608 ZR110 2007-000113 R-CHIP;33ohm,5%,1/10W,TP,1608 XSW1 3409-001081 SWITCH-DETECTOR;12V DC,0.1A,SPST,30gf,PU ZR12 2011-000816 R-NET;100OHM,5%,1/16W,L,CHIP,8P,TP 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608,- ZR13 2007-000074 R-CHIP;100ohm,5%,1/10W,TP,1608 Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 27

    2007-000821 R-CHIP;390ohm,1%,1/10W,TP,1608 PCON2 3708-001728 CONNECTOR-FPC/FFC/PIC;36P,0.5MM,SMD-A,SN AR134 2007-000821 R-CHIP;390ohm,1%,1/10W,TP,1608 PCON2B 3809-001342 CABLE-FLAT;30V,80C,90MM,36P,0.5MM,UL2896 AR135 2007-000097 R-CHIP;47Kohm,5%,1/10W,TP,1608 PCON3 3711-002612 CONNECTOR-HEADER;BOX,5P,1R,1.25mm,SMD-A, AR143 2007-000097 R-CHIP;47Kohm,5%,1/10W,TP,1608 PD501 0404-001173 DIODE-SCHOTTKY;RB081L-20,20V,4000MA,SOD- AR155 2007-000079 R-CHIP;1.8Kohm,5%,1/10W,TP,1608 PD502 0404-001173 DIODE-SCHOTTKY;RB081L-20,20V,4000MA,SOD- Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 28

    VJ101 3722-001202 JACK-PHONE;7P,3.6PI,AG,YEL,NO PR129 2007-000124 R-CHIP;2.2Kohm,5%,1/10W,TP,1608 VL101 2703-000398 INDUCTOR-SMD;10uH,10%,3225 PR130 2007-000708 R-CHIP;3.9Kohm,1%,1/10W,TP,1608 VQ101 0501-000218 TR-SMALL SIGNAL;2SC4081,NPN,200mW,UMT,TP PR131 2007-000094 R-CHIP;22Kohm,5%,1/10W,TP,1608 VQ102 0501-000218 TR-SMALL SIGNAL;2SC4081,NPN,200mW,UMT,TP PR132 2007-000084 R-CHIP;4.7Kohm,5%,1/10W,TP,1608 VR101 2007-001164 R-CHIP;75ohm,1%,1/10W,TP,1608 Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 29

    2007-000090 R-CHIP;10Kohm,5%,1/10W,TP,1608 BR109 2007-000075 R-CHIP;220ohm,5%,1/10W,TP,1608 UR138 2007-000090 R-CHIP;10Kohm,5%,1/10W,TP,1608 BR110 2007-000102 R-CHIP;100Kohm,5%,1/10W,TP,1608 UR155 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 BR111 2007-000126 R-CHIP;4.3Kohm,5%,1/10W,TP,1608 UR156 2007-000078 R-CHIP;1Kohm,5%,1/10W,TP,1608 BR112 2007-000026 R-CHIP;200ohm,5%,1/8W,TP,2012 UR157 2007-000075 R-CHIP;220ohm,5%,1/10W,TP,1608 BR131 2007-000086 R-CHIP;5.6Kohm,5%,1/10W,TP,1608 Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 30

    R-CHIP;3Kohm,1%,1/10W,TP,1608 2007-001433 R-CHIP;12Kohm,1%,1/10W,TP,1608 2007-001153 R-CHIP;750ohm,1%,1/10W,TP,1608 2007-000857 R-CHIP;4.3Kohm,1%,1/10W,TP,1608 2007-000999 R-CHIP;510ohm,1%,1/10W,TP,1608 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 2007-000509 R-CHIP;2.4Kohm,1%,1/10W,TP,1608 2007-000640 R-CHIP;270ohm,1%,1/10W,TP,1608 2007-000726 R-CHIP;300ohm,1%,1/10W,TP,1608 2007-000040 R-CHIP;150ohm,1%,1/10W,TP,1608 2007-000999 R-CHIP;510ohm,1%,1/10W,TP,1608 2007-000219 R-CHIP;1.2Kohm,1%,1/10W,TP,1608 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 2007-000763 R-CHIP;330ohm,1%,1/10W,TP,1608 2007-001153 R-CHIP;750ohm,1%,1/10W,TP,1608 Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 31

    Electrical Parts List MEMO 4-10 Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 32: Block Diagram

    VIC01 (MM1566) 6dB Amp CVBS Out/In Switch SIC3 (FAN8728) XTC02/03 Motor Drive ZIC2 (NT5SV4M16DT) SIC01 (SAA7114) (74LVX573) 64MBit SDRAM Video Decoder XTC01 U1 (LWT13611) Jag-D Timing Controller Display Scaler Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 33

    Block Diagram MEMO This Document can not be used without Samsung’s authorization Samsung Electronics...

  • Page 34: Schematic Diagrams

    6-11 Inverter - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 6-12 Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 35: Dcdc/battery (main B Pcb)

    Schematic Diagrams 6-1 DCDC/Battery (Main B PCB) Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 36: Power (main A Pcb)

    Schematic Diagrams 6-2 Power (Main A PCB) Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 37: Av-decoder (main A Pcb)

    Schematic Diagrams 6-3 AV-Decoder (Main A PCB) Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 38: Servo (main A Pcb)

    Schematic Diagrams 6-4 Servo (Main A PCB) Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 39: Video 1/audio 2 (main B Pcb)

    Schematic Diagrams 6-5 Video 1/Audio 2 (Main B PCB) Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 40: Video 2 (main A Pcb)

    Schematic Diagrams 6-6 Video 2 (Main A PCB) Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 41: Audio 1 (main A Pcb)

    Schematic Diagrams 6-7 Audio 1 (Main A PCB) Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 42: Display (main A Pcb)

    Schematic Diagrams 6-8 Display (Main A PCB) Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 43

    Schematic Diagrams 6-9 Key/Sub-Micom 6-10 Samsung Electronics This Document can not be used without Samsung’s authorization...

  • Page 44

    Schematic Diagrams 6-10 LCD Samsung Electronics 6-11 This Document can not be used without Samsung’s authorization...

  • Page 45

    Schematic Diagrams 6-11 Inverter 6-12 Samsung Electronics This Document can not be used without Samsung’s authorization...

This manual also for:

Dvd-l200

Comments to this Manuals

Symbols: 0
Latest comments: