Table of Contents
Advertisement
Page 2
AVERTISSMENT. Assurez-vous de bien suivre les instructions données dans cette
notice pour réduire au minimum le risque d'incendie ou d'explosion ou pour éviter
tout dommoge matériel, toute blessure ou la mort
Ne pas entreposer ni utiliser d'essence ou ni d'autres vapeurs ou liquides infl ammables
à proximité de cet appareil ou de tout autre appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur; ne pas vous servir des téléphones se trouvant dans
le bâtiment.
• Appelez immédiatement votre fournisseur de gas depuis un voisin. Suivez les
intructions du fournisseur.
• Si vous ne purvez rejoindre le fournisseur, appelez le service des incendies.
L'installation et l'entretien doivent être assurés par un installateur ou un service
d'entretien qualifi é ou par le fournisseur de gaz.
CONTENTS
Before Your Start ................................................ page 2
Boiler/Water Heater Location ............................. page 3
General Venting Guidelines ................................ page 9
Venting Options .................................................. page 9
Vertical/Chimney Venting ................................... page 9
Horizontal Venting ............................................ page 10
Outdoor Venting ............................................... page 11
Common Vent Systems .................................... page 12
General Piping Requirements .......................... page 13
Heating System Piping ..................................... page 14
Domestic Water Supply Piping ......................... page 18
Gas Supply Piping ............................................ page 21
Electrical Wiring ................................................ page 22
General Operation ............................................ page 22
Operating Instructions ...................................... page 25
Control Description ........................................... page 30
Maintenance ..................................................... page 31
Troubleshooting ................................................ page 34
Repair Parts ...................................................... page 36
Start Up Sheet .................................................. page 44
Mass. Code ....................................................... page 46
Warranty ........................................................... page 48
BEFORE YOU START
This manual covers the application, installation,
operation and maintenance of a LCD Series fi nned
copper heating boiler/water heater/pool heater.
To obtain the safe, dependable, effi cient operation and
long life for which this heating boiler/water heater was
designed, these instructions must be read, understood
and followed.
LCD INSTALLATION AND OPERATION INSTRUCTIONS
The LCD Series finned copper heating boiler/water
heaters have been design certifi ed by CSA for use with
natural and propane gas under the latest revision of
ANSI-Z21.10.3/CSA 4.3, Gas Water Heaters, and ANSI-
Z21.13/CSA 4.9, Gas-Fired Low Pressure Steam and Hot
Water Boilers and CAN1-3.1 Industrial and Commercial
Gas Fired Boilers. Each unit has been constructed and
hydrostatically tested for a maximum working pressure of
160 psi, 1103 kPa in accordance with Section IV of the
A.S.M.E. Boiler and Pressure Vessel Code.
All aspects of the boiler/water heater installation must
conform to the requirements of the authority having
jurisdiction, or, in the absence of such requirements,
to the National Fuel Gas Code, ANSI Z223.1/NFPA 54-
latest revision. Where required by the authority having
jurisdiction, the installation must conform to the Standard
for Controls and Safety Devices for Automatically Fired
Boilers, ANSI/ASME CSD-1.
In Canada, the installation must be in accordance with
the requirements of CSA B149.1 or .2, Installation Code
for Gas Burning Appliances and Equipment.
If installed in the Commonwealth of Massachusetts, you
MUST FOLLOW the additional instructions located in the
back of this manual (MACODE-3).
The owner should maintain a record of all service work
performed with the date and a description of the work
done. Include the name of the service organization for
future reference.
Direct all questions to your RBI distributor or contact
the RBI Customer Service Department, 260 North Elm
Street, Westfi eld, MA 01085 for U.S. or 7555 Tranmere
Drive, Mississauga, ONT L5S 1L4 for Canada. Always
include the model and serial numbers from the rating
plate of the boiler/water heater in question.
Hide quick links:
Advertisement
Table of Contents
