CDMA PORTABLE CELLULAR TELEPHONE SCH-211 SERVICE Manual CDMA PORTABLE CELLULAR TELEPHONE CONTENTS 1. General Introduction 2. Specification 3. Installation 4. NAM Programming 5. Circuit Description S E N D E N D 6. Troubleshooting AB C DE F GH I...
¥ UIS-126 : Mobile Station Loopback Service Options Standard SCH-211 is composed of main handset, rapid charger, cradle, two batteries (1300 mAh, 850 mAh), hands-free kit, and travel charger. Hands-Free Kit is designed to be operated in half-duplex mode taking turn-around delay between the phone and the system into account.
Page 5
General Introduction MEMO Samsung Electronics - Contents may change without notice.
: below – 60 dBm (in 2mS) Compressor Compression Rate : 2:1 Attack Time : 3 mS Recovery Time : 13.5 mS Reference Input : Input level for producing a nominal ± 2.9 kHz peak frequency deviation of transmitted carrier Samsung Electronics-Contents may change without notice.
Page 7
Protection Against Spurious Response Interference : above 60 dB In Band Conducted Spurious Emissions Transmit Band : below – 60 dBm Receive Band : below – 80 dBm Out of Band Conducted Spurious Emissions : below – 47 dBm Samsung Electronics - Contents may change without notice.
Closed Loop TX Power Control Range : Test 1 beyond ± 24 dB Test 2 0 mS ~ 2.5 mS Test 3 beyond ± 24 dB Test 4 beyond ± 24 dB Test 5 beyond ± 24 dB Samsung Electronics-Contents may change without notice.
Page 9
FA NO. CH. NO. CENTER FREQUENCY FA NO. CH. NO. CENTER FREQUENCY 1011 869.640MHz 882.120MHz 870.870MHz 883.350MHz 872.100MHz 884.580MHz 873.330MHz 885.810MHz 874.560MHz 887.040MHz 875.790MHz 888.270MHz 877.020MHz 889.270MHz 878.250MHz 890.910MHz 879.480MHz 892.140MHz 880.890MHz 893.370MHz Samsung Electronics - Contents may change without notice.
Page 10
PWRx : Power Level 0~7 SATx : Supervisory Audio Tone code (0~3) x (Using Frequency Band) : A Band or B Band SIDxxxxx PWR x RSSIxxx RSSIxxx : RSSI value SATx CHxxxx CHxxx : Using Channel Samsung Electronics-Contents may change without notice.
Page 11
Specification MEMO Samsung Electronics - Contents may change without notice.
The lamp marked PHONE on the front panel of the charger lights up red. Extended Battery Pack SCH-211 MAIN Standard Battery Pack Figure 3-1 Charging the Phone and Battery Samsung Electronics-Contents may change without notice.
Page 13
However, the antenna should be higher than the roof of the car. ¥ UIn case of on-glass antenna, you should align the antenna base with the round plate to connect the cables correctly. Samsung Electronics - Contents may change without notice.
Page 14
3-2. Drill holes and mount the lower half of the clamshell by using the screws. Cradle To Antenna To Cellular Telephone To Hands-free Box Vehicle Figure 3-2 Cradle Installation Samsung Electronics-Contents may change without notice.
Page 15
Normal place is the sun visor. Once the microphone has been correctly positioned, connect the microphone wire to the MIC jack on the hands-free box. Mounting Bracket Figure 3-3 Hands-Free Box Installation Samsung Electronics - Contents may change without notice.
Page 16
Connect the other end of the power cable to the PWR jack of the hands-free box. 3A FUSE BAT.(+) BLACK BAT.(-) ORANGE IGN. Switch BROWN STEREO Mute Figure 3-4 Cable Connections Samsung Electronics-Contents may change without notice.
Page 17
Installation MEMO Samsung Electronics - Contents may change without notice.
1234567890 Mobile ID # Mobile ID Number Mobile ID Number. 1234567890 Anlg HomeSID Number Analog System ID Number. Dgtl HomeSID Number Digital System ID Number. Prog. More? or # Exit or Enter Long NAM Samsung Electronics-Contents may change without notice.
Preferred system selection for NAM(1~4). Digital pref or # Up to four NAMs are allowed for the phone. This lists one of the four NAMs and allows you to program both the FM and CDMA settings. Samsung Electronics - Contents may change without notice.
Page 20
Schn Sys B CDMA Home System ID. or # Enables the phone to allow mobile terminated calls while in NAM1 Digital the home system. Controls the types of registration allowed Home SID Reg for the phone. Samsung Electronics-Contents may change without notice.
Page 21
Auto Reg FM Access Overload Class. or # This two-digit number specifies the level of proirity assigned NAM1 Analog to the mobile for accessing the system. ACCOLC Ranges from 0 to 15. Samsung Electronics - Contents may change without notice.
LCD module contains a controller which will display the information onto the LCD by 8-bit data from the MSM. It also consists a DC-DC converter to supply -3.5V for fine view angle and LCD reflector to improve the display efficiency. Samsung Electronics-Contents may change without notice.
Page 23
SLEEP/ changes to LOW, all the pins except for ¥ CHIPX8 : ADC reference clock used in CDMA the TXCO is disabled. RX mode. ¥ FMCLK : Reference clock in FM RX mode. Samsung Electronics - Contents may change without notice.
Page 24
CDMA TXCLK, TXCLK/ MODE BASEBAND TX_IQDATA0~7 PCM_CLK ANALOG 2 VOCODER PCM_SYNC (BBA2) CORE MODE PCM_DIN CODEC FM_RX_IDATA PCM_DOUT FM_RX_QDATA FM_RX_STB FM_RX_CLK PROCESSING TXCO/4 ADC_ENABLE GENERAL ADC_DATA PURPOSE ADC_CLK SUPPORT Figure 6-1 Baseband Block Diagram Samsung Electronics-Contents may change without notice.
Page 25
C145, R145, and C142, amplified at the speaker amp (U111), and comes out to speaker. In hands- free mode, the key tone is applied to RX audio line through the LPF and C153, R142. Samsung Electronics - Contents may change without notice.
The filter also eliminates the image made by the voltage control. product generated at the mixer. THERMISTOR The thermistor (U371) detects temperature. It is used to compensate active component characteristics due to the temperature difference. Samsung Electronics-Contents may change without notice.
U461. a regulated power to each part of transmitter. U483 supplies 4.7V to TX mixer (U461) and OP amp (U463). U482 supplies 3.6 V to TX IF AGC amp (U460). Samsung Electronics - Contents may change without notice.
Page 28
C/F and GND. The secondary AC output of transformor is recti- fied to DC voltage. Secondary filter circuit : L1, L2, C9, C12 It minimizes the high frequency ripple noise, which is caused by primary oscilation. Samsung Electronics-Contents may change without notice.
Page 29
Land side. vert from hands-free mode to private mode, and vice verse. It adjusts speaker volume at 8 steps and attenuates echo and noise occurred during conversation. Samsung Electronics - Contents may change without notice.
Audio Out Audio In Test Cable Directional Coupler To A-Out Test Jig To A-In DC Power Supply (+3.6 V) Items needed to purchase from SAMSUNG. Items Parts # Remark RF Test Cable GH97-00687A Test JIG GH80-10502A Including (RF Interface Pack AssÕy) 1.
Increase value of the last command. (Only for autotest) 36(A4, 0, 0) T_VOLUME_DOWN_I Decrease value of the last command. (Only for autotest) 38(A6, 3, 0) T_VOC_ENC_OFFSET_I Vocoder ENC offset. 39(A7, 3, 0) T_VOC_DEC_OFFSET_I Vocoder DEC offset. Samsung Electronics-Contents may change without notice. 5-11...
Page 33
Change pdm TX AGC in CDMA. 72(D2, 3, 0) T_FM_TXADJ_I2) Change pdm TX AGC in FM. 73(D3, 1, 0) T_SET_PA_R_I2) Set PA R1, R0 in CDMA. 74(D4, 3, 0) T_TXADJ_0DBM_I Sets tx_agc_adj for fm mode. 5-12 Samsung Electronics - Contents may change without notice.
Page 34
AB: Input Argument Byte Number RB: Return Byte Number * SAT 32, 33 are not operating in MSM2 CHIP test * 46 command is required in Rx, and Tx path test at FM mode Samsung Electronics-Contents may change without notice. 5-13...
U1. Battery identity detection determined to voltage detection battery internal between ID and GND. Secondary rectifier circuit : D21, C21 The secondary AC output of transformor is rectified to DC voltage. 5-14 Samsung Electronics - Contents may change without notice.
Page 36
Ripple and noise : 100mVpp Phone with battery pack. Proper fuse capacity : 250V, 2A Charger function Charger for battery pack. Charge time Small Capacity about 2hrs. Medium Capacity about 3hrs. Large Capacity about 41/2hrs. Samsung Electronics-Contents may change without notice. 5-15...
Page 37
Pin no (CLC) Description Pin no (HHP) HP-PWR 5-9-2 Circuit description of SCH-210 V-BAT 12/13/16 POWER SUPPLY This circuit supplies HHP & battery with power received from Cigar Lighter jack of automobile. 2/4/6 5-16 Samsung Electronics - Contents may change without notice.
U121 pin 4 input=4V? U121 pin 6 output=3.3V? Check U121 and its neighboring circuits. U122 pin 4 output=3.3V? Check U122 and its neighboring circuits. U124 pin 4 output=5V? Check U124 and its neighboring circuits. Samsung Electronics-Contents may change without notice.
Page 39
U401 pin 52? Check the LED and its neighboring LED on? circuits. Replace if required. Normal initial Check the LCD pins and its neighboring display on LCD? circuits. Replace if required. Samsung Electronics - Contents may change without notice.
Page 40
Replace if required. through R189? Check R190, R191, R193, R194, Normal Q115 operation? and Q115. Replace if required. The voltage applied to LCD (M101) Resolder R186 and R187. pins 31, 32? Backlight LED on Samsung Electronics-Contents may change without notice.
Page 41
Scanning signals output from U101 pins159, Resolder U101 pins 159, 160, and 163-167. 160, 163-167? Resolder U101 pins 168-170, 172, and 173. Resolder J101. Normal key data input? Replace the Keypad assembly. Samsung Electronics - Contents may change without notice.
Page 42
CLK waveform Resolder R141, C146, R145, C142, applied to U111 pin 2? R136, and C141. CLK waveform Check U111. applied to J101 pins11, Replace if required. and 14? Normal keytone? Replace the Keypad assembly. Samsung Electronics-Contents may change without notice.
Page 43
Check Q120, Q113, R147, R148, D103, CLK waveform applied and D105. Replace if required. to J101 pin 24? Is the buzzer Connect the buzzer correctly. connection correct? Check the buzzer and replace if required. Samsung Electronics - Contents may change without notice.
Page 44
Check IF filter in/output OK? soldering. (Loss: -5dB) Check 2nd Check AGC amp Check PLL(U402) local & AGC control in/output OK? & BBA #80. voltage OK? (Gain: +,-45dB) (170.76MHz) RF RX FM OK. (BBA INPUT: -52dBm) Samsung Electronics-Contents may change without notice.
Page 45
6-2-2 CDMA Mode Start CDMA mode. Normal CDMA SVC Check CDMA Rx path. & ROAM OK? (See '7-2-1 FM Mode'.) Check Transmitter. Setup CDMA call. OK? Measure CDMA FER. Normal CDMA RF? Samsung Electronics - Contents may change without notice.
Page 46
SPAN 5MHZ FM:-24dBm FM:-12dBm TX VCO:270.76MHz CDMA:-30dBm CDMA:-12dBm IF:130.38MHz Check U464 Check U461 Check U467 Check TX power RF out level. OK? out level. OK? POUT level. level. OK? FM:-19dBm FM:2dBm FM:28dBm CDMA:-22dBm CDMA:-1dBm CDMA:25dBm Samsung Electronics-Contents may change without notice.
Page 47
Troubleshooting MEMO 6-10 Samsung Electronics - Contents may change without notice.
Page 48
Rapid Charger Parts List Hands-Free Kit Exploded View Hands-Free Kit Parts List Cradle Exploded View Cradle Parts List Main Packing Layout 7-10 Main Packing Parts List 7-11 Hands-Free Kit Packing Layout 7-12 Hands-Free Kit Packing Parts List Samsung Electronics-Contents may change without notice.
Exploded View and its Parts List 7-10 Main Packing Parts List DESCRIPTION SEC. CODE Q’TY REMARK USERS MANUAL RAPID CHARGER GH44-40034A STANDARD BATT PACK GH43-10104A HANDSET GH90-01223A CUSHION CASE GH69-20638A GIFT BOX-MAIN GH69-11089A Samsung Electronics-Contents may change without notice. 7-11...