Summary of Contents for Generac Portable Products 3500PSI 1540-1
Page 1
Portable Products Pressure Washer Owner's Manual Generac Portable Products is a licensed trademark of Briggs & Stratton Power Products. Generac Portable Products es una marca registrada licenciada de Briggs & Stratton Power Products. Questions? Help is just a moment away!
Generac Portable Products 3500 PSIPressure Washer TABLE OF CONTENTS SAFETY RULES Safety Rules........Know Your Pressure Washer ...... This is the safety alert symbol. It is used to alert you to potential personal injury Assembly ........hazards. Obey all safety messages that follow Operation ........
Page 3
Generac Portable Products 3500 PSIPressure Washer DANGER WARNING WHEN ADDING FUEL Turn pressure washer OFF and let it cool at least 2 minutes before removing gas cap. Operate pressure washer ONLY outdoors. Fill fuel tank outdoors. Use a respirator or mask whenever there is a chance that DO NOT overfill tank.
Page 4
Generac Portable Products 3500 PSIPressure Washer CAUTION WARNING DO NOT tamper with governed speed. DO NOT operate pressure washer above rated pressure. DO NOT touch hot surfaces. CAUTION Stay dear of exhaust gases. Allow equipment to cool before touching. DO NOT secure spray gun in open position.
Generac Portable Products 3500 PSIPressure Washer KNOW YOUR PRESSURE WASHER Read this owner's manual and safety rules before operating your pressure washer. Compare the illustrations with your pressure washer to familiarize yourself with the locationsof various controls and adjustments. Savethis manual for future reference.
Generac Portable Products 3500 PSIPressure Washer ASSEMBLY To prepare your pressure washer for operation, you will need to perform these tasks: IMPORTANT: Read entire owner's manual before you Fill out and send in registration card. attempt to assembleor operate your new pressure washer.
Page 7
Generac Portable P roducts 3500 PSI P ressure Washer Engine Oil and Fuel • Place pressure washer on a level surface. CAUTION use if damaged; clean if dirty. • Refer to engine manual for oil and fuel fill information. • Damage to equipment...
Page 8
Generac Portable Products 3500 PSIPressure Washer Check to make sure there are no kinks, cuts, or Attach nozzle extension to spray gun. Tighten by hand damageto high pressure hose. (Figure 4). Provide a proper water supply (not to exceed 100°F) at an adequate flow.
Page 9
Generac Portable P roducts 3500 PSI P ressure Washer Use Spray Tips Cleaning and Applying Chemical The quick-connect on the nozzle extension allows you to IMPORTANT: Use soaps designed specifically for switch between several different spray tips. The spray tips pressure washers.
Page 10
Generac Portable Products 3500 PSIPressure Washer Make sure garden hose is connected to water inlet Increase (decrease) spray pressure by turning pressure Check that high pressure hose is connected to spray control knob clockwise (counterclockwise) (Figure 7). gun and pump and start engine.
Generac Portable Products 3500 PSI Pressure Washer SPECIFICATIONS PRESSURE WASH ER MAINTENANCE Outlet Pressure ..3,500 psi Flow Rate ..4.0 gallons per minute (gpm) Check and Clean Inlet Screen Detergent ..Use detergent approved for pressure washers Examine the screen on the water inlet. Clean it if the Water Supply ..
Page 12
Generac Portable Products 3500 PSIPressure Washer Check Gun and Nozzle Extension To remove contaminants from the pump, follow these steps: Examine the hose connection to the spray gun and make Set up pressure washer as described in "Preparing sure it is secure. Test the trigger by pressing it and making Pressure Washer For Use".
Page 13
Generac Portable Products 3500 PSIPressure Washer ENGINE MAINTENANCE Reinstall spray tip and in-line filter into nozzle extension. Reconnect nozzle extension to spray gun. See the engine owner's manual for instructions on how to Reconnect water supply, turn on water, and start engine.
Generac Portable Products 3500 PSIPressure Washer Check Level Empty the pump of liquids by pulling the engine recoil handle about 6 times. This should remove most of the Place pressure washer on a level surface. liquid in the pump. While pump and oil is cold, observe oil level visible in Use pump saver to prevent corrosion build up and pump's oil sight gauge.
Generac Portable Products 3500 PSIPressure Washer TROUBLESHOOTING Problem Cause Correction Low pressure spray tip installed. Replacespray tip with high pressure spray tip. Water inlet isblocked. Clear inlet. Inadequate water supply. Provide adequate water flow. Pump has following Inlet hose is kinked or leaking.
Page 19
Generac Portable Products 3500 PSIPressure Washer 2 ¸ PARTS LIST -- PUMP Item Part # Description 18811IGS SEAL, Oil, Crankshaft 192995GS I DOMED, Oil Filler 188118GS I O-RING, Filler Cap 188119GS I GAUGE, Oil Sight w/Gasket 188133GS 3 PLUNGER 188140GS 3...
Page 20
Lavadora dePresibn 3500 PSI d eGenerac Portable P roducts TABLA DE CONTENIDOS REGLAS DE SEGURIDAD ReglasDe Seguridad ......20-22 Conozca Su Generador ......para advertir al usuario de un posible riesgo para "--stees el simbolo de alerta de seguridad. Sirve Ensamblaje ........
Page 21
Lavadorade Presibn 3500 PSIde Generac Portable Products ADVERTENCIA PELIGRO Opere el lavadorade presibn SOLAMENTE al aire libre. CUANDO AI_ADA COMBUSTIBLE Utilice un respirador o m_scara siempre que exista la posibilidadde inhalar vapores. Apague el generador (posici6n OFF) y d6jelo enfriar al menos por 2 minutos antes de remover la tap_ de la gasolina.
Page 22
Lavadora de Presibn 3500 PSIde Generac Portable Products ADVERTENCIA PRECAUCION NO asegure la pistola de rociado en la posici6n (open = abierto). NO abandone [a pistola de rociado cuando la m_quina est_ en funcionamiento. NO toque {assuperficies calientes. NUNCA ud[ice una pistola de rociado que no tenga un seguro para Mant_ngase a[ejado de los gases de escape.
Page 23
Lavadorade Presibn 3500 PSIde Generac Portable Products CONOZCA SU MAQUINA LAVADORA DE PRESION Lea el manual del propietario y las reglas de seguridad antes de poner en mareha su m_quina lavadora a presibn. Compare las ilustracionescon su m_quina lavadora a presibn para familiarizarse con las ubicaciones de los diferentes controles y aiustes.
Page 24
Lavadora de Presi6n 3500 PSIde Generac Portable Products A prepara su arandela de la presi6n para la operaci6n, MONTAJE usted necesitarg a realiza estas tareas: IMPORTANTE: Lea totalmente el manual del propietario antes Llene y mande en la tarjeta de matrtcula.
Page 25
Lavadorade Presibn 3500 PSIde Generac Portable Products Agregar Aceite al Motor y Gasolina Coloque la lavadora a presi6n sobre una superficie nivelada. PRECAUCI( N • Consulte e[ manual de1 propietario del motor p_ra aSadir al motor el aceite y eLcombustible recomendado •...
Page 26
Lavadora de Presi6n 3500 PSIde Generac Portable Products Proporcione el suministro de agua adecuado (que no exceda Coloque el pasador de seguridad al gatillo de la pistola los 100OF). rociadora (Figura 16). Aseg0rese de leer las secciones "Reglas de Seguridad" y "C6mo Darle Arranque a su M_quina Lavadora a Presi6n"...
Page 27
Lavadorade Presi6n 3500 PSIde Generac Portable Products C6mo Usar las Puntas de Rocio Limpieza y Aplicaci6n del Quimico La conexi6n r_pida de la extensi6n para boquillas le permite usar IMPORTANTE: Utilice quimicos disefiados cinco puntas de rocio diferentes. Las puntas de rocto tienen especificamente para mgquinas lavadoras a presi6n.
Page 28
Lavadora de Presibn 3500 PSIde Generac Portable Products Aseg_rese que la manguera de jardfn est_ conectada a la Disminuya o aumente la presi6n de rociado al darle vuelta a entrada del agua. Revise que la manguera de alta presi6n est6...
Page 29
Lavadorade Presibn 3500 PSIde Generac Portable Products ESPECIFICAClONES MANTENIMIENTO DE LA Presi6n de Salida ..3,500 PSi LAVADORA A PRESION Promedio de Fluio ..4.0 galones por minuto (gpm) Revise y Limpie el Colador de Entrada Detergente ... Use el detergente adecuado para lavadores a presi6n Examineel colador de entrada de la manguera de iardin.
Page 30
Lavadora de Presibn 3500 PSIde Generac Portable Products Para retirar los contaminantes de la bomba, siga los Revise la Pistola y la Extensi6n para siguientes pasos: Boquillas Instale la m_quina lavadora a presi6n como est_ descrito en Examine la conexi6n de la manguera a la pistola y cerciorese "Preparandoel lavador a presi6n para su uso".
Page 31
Lavadorade Presibn 3500 PSIde Generac Portable Products MANTENIMIENTO DEL MOTOR Conecte de nuevo la extensi6n de la boquilla a la pistola rociadora. Consulte el manual del propietario del motor para las Conecte de nuevo el suministro de agua, prenda el agua,y...
Page 32
El salvador de la bomba de la marca del uso Generac a Si fuera necesario, ahada lentamente la cantidad adecuada del previene la corrosi6n construye y helado de bomba.
Page 34
Lavadora dePresi6n 3500 PSI d eGenerac Portable P roducts REPARACION DE DAI IOS Causa Soluci6n Problema Est_ usando [a puntas de rocio de baja Cambie la puntas de rocto a una de las presi6n (negra). tres puntas de rocto de alta presi6n. La entrada de agua est_ btoqueada.
Page 35
LIMITADA "Generac Portable Products es una marca licencia de Briggs & Stratton Power Products. Briggs & Stratton Power Products reparar_ o sustituir_ sin cargo alguno cualquier componente del equipo** que presente defectos de materiales y/o mano de obra. Los gastos de transporte de las piezas enviadas para reparar o sustituir conforme a los t_rminos de esta garantia correr_n a cargo del compradon Esta garantfa tiene efecto durante el periodo indicado y conforme alas condiciones estipuladas en la misma.
Page 36
LIMITEDWARRANTY "Generac Portable Products is a licensed trademark of Briggs & Stratton Power Products. Briggs & Stratton Power Products will repair or replace, free of charge, any part, or parts of the equipment** that are defective in material or workmanship or both.
Need help?
Do you have a question about the 3500PSI 1540-1 and is the answer not in the manual?
Questions and answers