Table of Contents
Advertisement
klodeH No. H443:0 (2,500 PSIHigh Pressure VV'asher) klanuaH No. B5786 Revision 2 (8/H4/2000)
Visit our Generac vvebsite:www.genera¢-portabmes.¢om
This is the safety aHerc symbol It is used to aHertyou to potentiaHpersonaH injury hazards.
Obey aHH s afety messagesthac foHHow this symboHto avoid possibHeiniury or death.
Advertisement
Table of Contents
Related Manuals for Generac Portable Products 1443-0
Summary of Contents for Generac Portable Products 1443-0
- Page 1 No. H443:0 (2,500 PSIHigh Pressure VV'asher) klanuaH No. B5786 Revision 2 (8/H4/2000) Visit our Generac vvebsite:www.genera¢-portabmes.¢om This is the safety aHerc symbol It is used to aHertyou to potentiaHpersonaH injury hazards. Obey aHH s afety messagesthac foHHow this symboHto avoid possibHeiniury or death.
-
Page 2: Safety Rules
Generac Portable Products 2_500 PSI Hig.h Pressure VVasher SAFETY RULES EQUmPHENT CAUT|ON! When setting up, transporting, adiusting or making repairs to your high pressure CONGRATULATmONS on your purchase of a washer, always disconnect the spark plug wire from GENERAC high pressure washer. It has been designed_... - Page 3 Generac PortabHe Products 2_500 PSI High Pressure _A/asher ° Before starting the pressure washer in coHd weather, , Never aim the spray gun at peopHe, animaHs or pHants. check aHH parts of the equipment and be sure ice has not The high pressure stream of water that this equipment formed there.
- Page 4 Generac Portable Products 2_500 PSI Hish Pressure VVasher KNOW YOUR PRESSURE WASHER Read this owner's manual and safety rules before operating your high pressure washers Compare the iHHustrations with your high pressure washer to familiarize yourseHf with the Hocations of various controHs and adjustments.
- Page 5 Generac PortabHe Products 2_500 PSI _ Pressure VVasher PREPARING PRESSURE Read entire owner's manuaH before you attempt assembHe or operate your new pressure washer. WASHER FOR USE REMOVE PRESSORE If you have any probHems with the assembHy of your WASHER...
- Page 6 Generac Portable Products 2_500 PSI H igh Pressure VVasher ° Secure hande to the base using the four flange nuts. Hose Reel Tighten the flange nuts with a H 3mm wrench. Use [NPORTANT: You must take the hose off the reel when...
-
Page 7: Add Engine Oil
Generac PortabHe Products 2_500 PSI _ Pressure _A/asher Supply Engine Connect Hose Water mMPORTANT: Any attempt to crank or start the engine before ithas been properHy serviced with the mMPORTANT: You must assemble the nozzle extension recommended oH may resuHt in an engine failure. - Page 8 Generac Portable Products 2_500 PSI H igh Pressure VVasher o Run water t hrough CHECKLIST BEFORE y our garden hose for 30 seconds to clean out any debris. Turn off water. STARTING ENGINE ° Connect the garden hose to the water inlet. Tighten by hand (Figure 9).
- Page 9 Generac PortabHe Products 2_500 PSI _ Pressure VVasher HOW TO USE YOUR * Connect the garden hose to the water inHet on the pressure washer pump. Turn on the water. PRESSURE WASHER CAUTION: Do Not run the pump without water suppHy connected,...
- Page 10 Generac Por_bie Products 2_500 PSI High Pressure VVasher ° Hove throtde iever to "Fast" position_ shown as a to Use Battery Char er rabbit. Use battery charger jack with the provided battery charger ° Position the choke iever to the "Choke"...
-
Page 11: Pressure Washer Rinsing
Generac PortabHe Products 2500PSI _ Pressure _A/asher o PuHH bacH< the coHHaron the quick-connect and puHH the CAUTION! Keep the detergent siphon tube from current nozzHe off. Store the nozzHe in the space provided coming in contact with the hot muffler. This wiHH... - Page 12 Generac Por_bHe Products 2_500 PSI High Pressure V_/asher o AppHy a high pressure spray to an smaHH area and then o Insert the marie end of the hose through the hoHe in the check the surface for damage. If no damage is found_ you hose red hub_ as shown in Figure H5.
-
Page 13: Specifications
Generac Portable P roducts Z500PSI H i_ Pressure _A/asher Adiustabme Hose Ree[ Spring Tension Before Each Use The hose reel is provided with a spring tension adjustment Unplug battery charger from unit. knob (Figure 15), Check engine oil level, Akhough... -
Page 14: Check In-Line Filter
Generac Portable Products 2_500 PSI H igh Pressure VVasher Check In-Line Filter of Air Purge Pump Refer to Figure H 7 and service the in4ine fiker if it becomes dogged_ as follows: To remove air from pump, follow these steps:... -
Page 15: Nozzle Maintenance
Generac Portabie Products 2_500 PSI _ Pressure _A/asher Nozzle Maintenance O-Ring Maintenance If the nozzles becomes restricted or dogged with foreign Through the normal operation of your pressure washer, materiab, such as dirt, excessive pump pressure may o-rings, which keep the connections of the hoses and spray develop. -
Page 16: Storing The Engine
Generac PortabHe Products 2_500 PSI H igh Pressure VVasher ENGINE HAINTENANCE NOTE: To protect the unit from freezing temperatures, draw RV antifreeze (nonoa[coho[) into the pump by pouring See the engine owner's manuaHfor instructions on how to the solution into a 3ofoot section of garden hose connected... -
Page 17: Troubleshooting
Gun leaks. Replace gun. Nozzle is obstructed. Clean nozzle. 10. Pump is fault 7. 10. Contact Generac service facilit 7. Detergent siphoning tube is not Insert detergent siphoning tube into submerged. detergent. Detergent fails to mix with Chemical filter is clogged. - Page 18 Generac Por_bHe Products 2,500 PSI H igh Pressure VVasher...
- Page 19 Generac Portab(e Products 2_500 PSI _ Pressure VVasher SCHEMAT(C W(R(HG D(AGRAM ",_b" i __ i NPU s 'x > TART " SW TCH ..... 27 ,,i1}C ..T ..SA ElRY NQINT] STAR[i DC PI CAT C ,,_,( : \" i ........
- Page 20 Generac Portabie Products 2,500 PSI High Pressure VVasher I __s EXPLODED VIEW- UNIT Setei[ E[ectPice{ Hookup...
- Page 21 Generac Portable Products 2500 PSI High Pressure VVasher 2 jj PARTS L ST UNmT Part # Pare # Qtyo Description totem Description Item AB5721A BASE 186050 DECAL, Battery Charge B2043 BOLT, 5/16" - 18 x 1-3/4" B5786 MANUAL, Owners B3297...
- Page 22 Generac Por_ble Products Z500 PSI Hitch Pressure VVasher i i'-- s EXPLODED VmEW _ PUMP 'i!7 ° ° I I I I I I 000000 ½ >...
- Page 23 Generac PortabHe Products 2_500 PSI High Pressure _A/asher 2 jj ;i --3 PARTS LIST -- PUMP item Part item Part Qty. Qty. Descripdon Description B2218 ..ASSEMBLY, Spindle O-RING, Engine Adapter B2260 ..O-RING, Spindle ADAPTER, Noosing, Cam B2217 ..
- Page 24 UHmTED PRESSURE WASHER WARRANTY GENERAC PORTABLE PRODUCTS (hereafter referred to as the COMPANY) warrants to the original retail purchaser, the pressure washer manufactured by the COMPANY to be free from defects in material and workmanship for the period(s) set forth below from the date of original purchase. This warranty is not transferable.
Need help?
Do you have a question about the 1443-0 and is the answer not in the manual?
Questions and answers