Page 1
www.GEAppfiances.com ..Sa]bty Instructions. Operating h_iructions Aft Di _ectkm ....Heat/Cool Model 2800 AuxiliaIw C(mtIols ..Heat Pum]a Model 3800 Con tIols ....To Remove the Room Cabi_et . .4 Ve_t C(mtrol ....Espa_ol For a Spanish version of this Care Cleaning manual,...
Page 2
IMPORTANT SAFETY INFORMATION. READALLINSTRUCTIONS BEFORE USING. WARNING! For your safe_ the information in this manual must be followed to minimize the risk of fire or explosion, electric shock, or to prevent property damage, personal injury, or loss of life. SAFETY P RECAUTIONS This Zoneline must be properly Replacing an existing unit?
Page 3
About the controlson yourZoneline. .CEA..lia.ces.com TEMPCONTROL MODECONTROL Temp Control Mode Control Co trols HIGH COOL and LOW COOLpr_Mde cooling The temp control is used to maintain The COlll[)i'essoi" will with different tim speeds. I'00111 tell/pei'att/i'e. c_cle on and off to kee I) the room at the HIGHHEATand tOW HE4Tprovide heating same comtort...
Page 4
Otherfeatures of yourZoneline. Ventilation Control Open xentilation control lexer is located at the position upper lett side of the Zoneline unit, behind room cabinet. _,_q_en set at the closed position, onE' inside room is circulated filtered. X,_]_en set at the open position, some...
Page 5
AuxiliarFContrMs--Dip Switches au_liary dip switch controls located behind room cabinet, through an opening in the control panel. ToRemovethe Remove room cabinet. See the Room Cabinetsection. DOWN The ti_cto_) settings will be in the position. Dip Switches The owner is responsible tor checking switches and ensuring...
Page 6
AuMtiary contrMs on your Zone#he. Remote Thermostat--Class 2 _._q_en this switch is enabled (liP), it allows the °"qBBB@BBBB B BBBBBBB1 °"_" unit to operate with a Class 2 Remote Control Wall Them_ostat. The unit controls are disabled. CLASS 2 (Remote Thermostat) Load Shedding (Central Desk Control) This feattu'e...
Page 7
ww'w.GEApp#ences.com Temperature Limiting The fit_t three switches are used to select the TemI)erature limiting can reduce energy/costs by limiting the lowest temperatm'e that can be cooling limits, and the remaining three switches set for cooling and the highest temperatm'e that are used to control the heating limits.
Page 8
Auxiliary controlson yourZoneline. Auxiliaq Controls--Terminal Connections Tile auMlia_ controls are located behind tile owner is responsible fi)r making rooiil cabinet beneath tile access coxei; c(mnections setting tile appropriate dip switches. Remoxe tile room cabinet, See tile ToRemovethe RoomCabinetsection. A CAUTION: Rei/loxe tile tile }l('('ess ('o_ei;...
Page 9
www.GEAppliances.com Door Sensor (Obtained locally) _]/en connected, tile door sensor will detect when tile door in tile i'OOill w;is opened coi_junction closed. This teature nmst be used with tile motion senso_: Tile door i/lotion sensoi3 work together to automaticall_ set back tile room temperature. DoerSensor External Fan (Obtainedlocally) _4]/en...
Page 10
If tile)' are clogged with dirt or soot, they may be protessionally steam cleaned, a service a\_dlable through your GE se_Mce outlet. You will need to remove unit to inspect tile coils because tile dirt buildup occm_ on tile inside.
Page 11
Replacement filtex_ awfilable fl'om salesperson, GE deale_; GE Service Parts Center or authorized Customer Care '_se_'icers.
Page 12
Zoneline Air Installation Conditioners Instructions Questions ? Call 800.GE.CARES (800.432.2737) or Visit www.GEAppliances.com our Website BEFORE YOU BEGIN IMPORTANT ELECTRICAL SAFETY--READ CAREFULLY Read these instructions completely carefully. • IMPORTANT - S_,,e t hese _k CAUTION: instI uctions h)cal inspector's use.
Page 13
This unit is designed to be installed in a GE plastic insulated metal wall case. This mininfizes condensation from limning on the room side of the case. If the current...
Page 14
Tandem Perpendicular Large Tandem electrical codes. 15Amp. 20 Amp. 30Amp. 230/208volt receptacle configuration. Branch Circuit and Proper GE Power Cord Unit Amperage Bating with LCDI Device RA1(3153 ]L_I(3203 1_&K3303':: ':Nol approxed tor use on 7000 BTU models.
Page 15
This wi!l help when the box is being reinsm!led. These models must be installed using the ai)propriate GE power supi)l } kit tor the branch circuit amperage Unitconnector and the electrical resistance heater wattage desired.
Page 16
Installation Instructions 265 VOLT ELECTRICAL SUPPLY [] ATTACH CONDUIT [] REINSTALL JUNCTION 1 Use the round knockout at the botton/of box by engaging • Reinstall the junction the left tabs junction box to attach conduit coming from the on the lower right ta(e oI the unit, aligning branch circuit.
Page 17
Installation Instructions POWER CONNECTION CHART 230/208 Volt Power Supply Kits with Leakage Current Detection Heater Wattage Device Circuit Protective Device (O)230/208 Volts RAK3153 2,55/2.09 K\,\ T_I I1 d eI/l RAK3203 • .4:/2.82 Perpendicular 20 Amp Time Dela'_ Fuse or Breaker 15 Amp Time Delay...
Page 18
Insulated Wall Case This m_it is designed to be im_sta]led im_ a GE plastic or am_im_sulated stee] wall case_ This mil]imizes coildemlsatiol? f}'om fk)rmimlg oral the room side the case. • If vent door is to be operational,...
Page 19
ScI'ev/s tbml_gh the m_it flm_ge boles. NOT]?:: There are several extra holes in the refit side flanges for installation in wall cases other than GE. To avoid damaging the flange insulation, the installer should use an awl or other shaq)
Page 20
Installation Instructions OPTIONAL--DRAIN KIT INSTALLATION Dry Air 25 Series models designed to improve dehumidification by 25%. Since more moisture will be removed from the air, there is a greater possibility that water will drip from the wall case thml with a standm'd unit.
Page 21
• Outdoor grille must have a minimum of 65% flee area. Non-GE grilles ma x be too restrictixe fin" proper i)erfimnance. Consult }our salespei_on fin" assistance.
Page 22
BeforeFoucall forservice... Problem Possible Cagses What To Do The air is get alwaFe rI_e heat pump is not * This is mmrmaL The heat plm/p will pro&we warm air operation electric heat Js ilsed. The fan switches may be This callses the _im to blow room...
Page 23
Normal Operating Sounds _'ol_ may heal" a ph]gin_ noise camed by water beh_g PING! POP! picked I_l) _md through agah_st the tom,denser om_ x_im' days or whe_ the lmmiditv is high. This design " featm'e helps _'emo_ e mo]stm'e amid h_l)_o_ e ma', hear ]'ela',s...
Page 25
Hease phce in envdope and mall to: General Electric Company _ran_ Re_stra_on Department P.O.Box 32150 LouisviUe, KY 40232o2150...
Page 26
FAII.I RE T() C()MPI.ETE AND RE'F[ RN TttIS CARD DOES NOT DIMINISII Y( )l R GE Appl&neos x,_L \RRANTY RIGIH'S. GE Co_momer & htdIJstrhd For intormation about GEA's prixacy and data usage polio?; go to ,,,,avw.GEAppliances.com and click toIJisvilto,...
Page 27
(lefe('t in materials or workananship. During this original purchase full five-year sealed refrigerating system warranty, GE will also provide, free of charge, all lal)or and on-site service to replace the (letecti\'e part, Five Years...
Page 28
Illuch iilox'e... V(X/XX" ScheduleService www.GEAppliances.com Expert GE repair sexs,ice is onl) one step away fl'om xour doox: Get on-line and schedule your service at _{xur, conxenience 24 h{xux_ any elm of tile year! Or call 800.GE.CARES (800.432.2737) dudng n{mnal business houx_.