Troubleshooting Chart - Craftsman EZ3 917.273041 Owner's Manual

TROUBLESHOOTING CHART
PROBLEM
Will not start
Hard to start
Engine will not turn
over
Engine clicks but will
not start
CAUSE CORRECTION
• Out of fuel.
• Engine not "CHOKED" prop-
edy.
• Engine flooded.
• Bad spark plug.
• Dirty air filter.
• Dirty fuel filter.
• Water in fuel.
• Loose or damaged wiring.
• Carburetor out of adjustment,
• Engine valves out of adjust-
ment.
• Dirty air filter.
• Bad spark plug.
• Weak or dead battery.
• Dirty fuel filter.
• Stale or dirty fuel.
• Loose or damaged wiring.
• Carburetor out of adjustment.
• Engine valves out of adjust-
ment,
• Clutch/brake pedal not
depressed.
• Attachment clutch is engaged.
• Weak or dead battery.
• Blown fuse.
• Corroded battery terminals.
• Loose or damaged wiring.
• Faulty ignitionswitch.
• Faulty solenoid or starter.
• Faulty operator presence
switch(es).
• Weak or dead battery.
• Corroded battery terminals.
• Loose or damaged widng.
• Faulty solenoid or starter.
• Fill fuel tank.
• See "TO START ENGINE" in
Operation section.
• Wait several minutes before
attempting to start.
• Replace spark plug.
• Clean/replece air filter.
• Replace fuel filter.
• Drain fuel tank and carburetor,
refill tank with fresh
gasoline and replace fuel filter.
• Check all wiring.
• See "To Adjust Carburetor" in
Service and Adjustments
section.
• Contact an authorized service
center.
• Clean/replace air filter.
• Replace spark plug.
• Recharge or replace battery.
• Replace fuel filter.
• Drain fuel tank and refill with
fresh gasoline.
• Check all wiring,
• See =ToAc
Service an
section.
• Contact a_
center.
• Depress cl
• Disengage
!• Recharge,
• Replace fu
! • Clean battq
• Check all
I" Check/reph
• Checldrepl;
starter.
• Contact an
center.
lust Carburetor" in
JAdjustments
authodzed service
Jtch/brakepedal.
attachment clutch.
)r replace battery.
_,e.
_ryterminals.
_dng.
,ce ignitionswitch.
ce solenoid or
authorized service
I
/
• Recharge c_rreplace battery.
• Clean battery terminals.
• Check all widng.
• Check/replace solenoid or
starter.
32