Page 1
Read and follow all Safety this product, Call: 1-800-659-5917 Rules and Instructions before Sears Craftsman Help Line operating this equipment. 5 am - 5 pm, Mon- Sat Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A. Visit our Craftsman website:www.sears.com/craftsman...
Page 2
Service ......Back Cover LIMITED WARRANTY ON CRAFTSMAN RIDING EQUIPMENT For two (2) years from the date of purchase, if this Craftsman Riding Equipment maintained, lubricated and tuned up according to the instructions in the owner's manual, Sears will repair or replace...
Page 3
IMPORTANT: This cutting machine is capable of amputating hands and feet and throw- ing objects. Failure to observe the following safety instructions could result in serious injury or death. • Never direct discharged material _lb WARNING: In order to prevent toward anyone.
Page 4
I1.SLOPE OPERATION • Never carry children, even with the blades shut off. They may fall off and Slopesare a majorfactor relatedto loss of be seriously injured or interfere with controlandtip-over accidents,which can safe machine operation. Children result in severeinjury or death. Opera- have been given rides in the past may tion on all slopes requiresextra caution.
Page 5
• Removegas-poweredequipmentfrom • Keep machine free of grass, leaves, the truckor trailerand refuelit on the other debris build-up. Clean oil or fuel ground.If this is not possible,then spillage and remove any fuel-soaked refuelsuch equipmentwith a portable debris. Allow machine to cool before container,ratherthan from a gasoline storing.
Page 6
(Gap: .030") AGREEMENTS Forward: Ground Speed Congratulations on making a smart pur- (MPH): chase. Your new Craftsman® product is designed and manufactured for years of dependable operation. But like all products, it may require repair from time to time. That's...
Page 7
(1) Oil Drain Tube For Future Use Slope Sheet Keys (2) Keys...
Page 8
Your newtractor has been assembledat the factory. When right or left hand is mentionedin this manual, it meanswhen you are in the oper- ating position(seatedbehindthe steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON Cut along dotted lines on all four pan- els of carton.
Page 9
CHECK BRAKE SYSTEM Start the engine. After engine started, move throttle control to idle After you learn how to operate your tractor, position. check to see that the brake is properly Depress clutch/brake pedal into full adjusted. See "TO ADJUST BRAKE" in "BRAKE"...
Page 10
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. I',,I SLOW REVERSE NEUTRAL HIGH CHOKE FAST IGNITION SWITCH ENGINE OFF REVERSE ENGINE ON ENGINE START PARKING BRAKE PARKING BRAKE PARKING BRAKE OPERATION LOCKED UNLOCKED...
Page 11
KN OW YOU R TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATINGYOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. "ON" Switch Position Ignition Switch Light Switch Attachment...
Page 12
The operation of any tractor result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard...
Page 13
TO STOP MOWER BLADES • The average lawn should be cut to approxi- mately 2-1/2 inches during the cool season disengage attachment clutch control. and to over 3 inches during hot months. _bCAUTION: Do not operate the mower For healthier and better looking lawns, mow without either the entire...
Page 14
TO OPERATEON HILLS • For cold weather operation you should change oil for easier starting (See the ,_WARNING: Do not drive up or down oil viscosity chart in the Maintenance hills with slopes greater than 15 ° and do section of this manual). not drive across any slope.
Page 15
Insert key into ignition and turn key When mowing large areas, start by clockwise to start position and release turning to the right so that clippings will key as soon as engine starts. discharge away from shrubs, fences, not run starter continuously for more driveways,...
Page 16
F,LL,. DATES AS COMPLETE ..REGULAR SERV,OE f y4 TSERV'OE DATES Check Brake Operation Check Tire Pressure Check Operator Presence ROS Systems Check for Loose Fasteners Sharpen/Replace Mower Blades lI_3 Lubrication Chart Check Battery Level Clean Battery and Terminals Check Transaxle Cooling Check...
Page 17
TRACTOR CHECK REVERSE OPERATION (ROS) SYSTEM Always observe safety rules when per- • When the engine is running with the forming any maintenance. BRAKE OPERATION ignition switch in the engine "ON" posi- tion and the attachment clutch engaged, If tractor requires more than five (5) feet to any attempt...
Page 18
TRANSAXLE COOLING • The blade can be sharpenedwith a file or on a grinding wheel. Do not attempt Keeptransaxlefree from build-upof dirt to sharpen while on the mower. and chaff which can restrict cooling. • Tocheck blade balance,you will need a V-BELTS 5/8"...
Page 19
Unlock drain valve by pushing inward Install cleaned or new cartridge with slightly and turning counterclockwise. the pleated side "out" and seat the To open, pull out on the drain valve. rubber seal onto the edges of the air cleaner base.
Page 20
IN-LINE FUEL FILTER CLEANING The fuel filter should be replaced once • Clean engine, battery, seat, finish, etc. each season. If fuel filter becomes of all foreign matter. • Keep finished surfaces and wheels free clogged, obstructing fuel flow to carbu- of all gasoline, oil, etc.
Page 21
SERVICE OR ADJUSTMENTS: ARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING Depress clutch/brake pedal fully and set parking brake. Place gearshift lever in neutral (N) position. Place attachment clutch in "DISENGAGED" position. Turn ignition key to "STOP" and remove key. Make sure the blades and all moving parts have completely stopped.
Page 22
TO LEVEL MOWER HOUSING Check adjustment on right side of tractor. Measure distance "D" directly in front of Adjust the mower while tractor is parked and behind the mandrel at bottom edge of on level ground or driveway. Make sure mower housing as shown.
Page 23
TO REPLACE MOWER BLADE DRIVE TO ADJUST BRAKE BELT Depress clutch/brake pedal all the way The mower blade drive belt may be re- down and engage parking brake. placed without tools. Park the tractor Measure distance between brake oper- level surface. Engage parking brake.
Page 24
Pull belt toward front of tractor and roll TO ADJUST STEERING WHEEL ALIGN- belt around electric clutch and onto MENT engine pulley. If steering wheel crossbars are not Install belt through stationary idler and horizontal (left to right) when wheels clutching idler.
Page 25
IMPORTANT: Your tractor is equipped KepsNut_ /Hex with a 12 volt system. The other vehicle .._:-;?' .._ Bolt must also be a 12 volt system. Do not use Terminal ;'97'-_" .-,'-- your tractor battery to start other vehicles. Access ._-/ ,.'-_.
Page 26
ENGINE Be sure you have a clean air filter and the throttle control cable is adjusted Maintenance, repair, or replacement properly (see above). the emission control devices and systems, Start engine and allow to warm for five which are being done at the customers minutes.
Page 27
Immediately prepare your tractor for stor- blended fuels (called gasohol or using age at the end of the season or if the trac- ethanol or methanol) can attract moisture tor will not be used for 30 days or more. which leads to separation and formation acids during...
Page 28
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center PROBLEM CAUSE 3ORRECTION Will not start 1. Out of fuel. Fill fuel tank. See "TO START ENGINE" Engine not "CHOKED" properly. in Operation section. Wait several minutes Engine flooded.
Page 29
TROUBLESHOOTING CHART: appropriate section in manual unless directed to Sears service center PROBLEM CAUSE CORRECTION Loss of power Cutting too much grass/too 1. Raise cutting height/reduce fast. speed. Throttle in "CHOKE" position. Adjust throttle control. Build-up of grass, leaves Clean underside of mower and trash...
Page 30
TROUBLESHOOTING CHART: See appropriate section in manual unless directed to Sears service center PROBLEM CAUSE CORRECTION Mower blades will 1. Remove obstruction• 1. Obstruction in clutch not rotate mechanism. Worn/damaged mower drive Replace mower drive belt. belt. Frozen idler pulley. Replace idler pulley.
Page 31
TRACTOR - - MODEL NUMBER 917,274650 SCHEMATIC 02843 193389 BATTERY SOLENOID IGNITION SPARK PLUGS UNIT (2PLUGS ON TW N CYL. ENG NES HOUR jO ....................................METER SOLENOID FUEL (OPTIONAL) LINE CHARGING SYSTEM OUTPUT 15 AMP PC _? 36OORPM REGULATO2 YELLOW ALTERNATOR 28 VOLTS...
Page 32
TRACTOR - - MODEL NUMBER 917.274650 ELECTRICAL...
Page 33
TRACTOR - - MODEL NUMBER 917.274650 ELECTRICAL PART DESCRIPTION 144927 Battery 74760412 Bolt, Hex 1/4-20 x 3/4 7603J Tray, Battery 145211 Bolt, Battery, Front 1/4-20 x 7-1/2 150109 Holddown, Battery, Front 145769 Nut, Push, Nylon, Battery, Front 1/4 176138 Switch, interlock 175688 Harness,...
Page 34
TRACTOR - - MODEL NUMBER 917,274650 CHASSIS AND ENCLOSURES 2094 54/_ 209 __ chassis-stealth,stlt...
Page 35
TRACTOR - - MODEL NUMBER 917,274650 CHASSIS AND ENCLOSURES PART DESCRIPTION 174619 Chassis 176554 Drawbar 193635X428 Dash 72140608 Bolt RDHD SQNK 3/8-16 x 1 167203 Panel, Dash, LH 188702X010 Panel, Dash, RH 17490608 Screw Thdrol 3/8-16 x 1/2 175260X428 Hood Assembly 162026 Plate Battery STD541437...
Page 36
T_CTOR - - MODEL NUMBER 917.274650 GROUND DRIVE d rive-f end e_,stlt_47...
Page 37
TRACTOR - - MODEL NUMBER 917,274650 GROUND DRIVE PART PART DESCRIPTION DESCRIPTION Transaxle Peerless 206-545C 130801 V-Belt, Ground Drive (See Breakdown) 169691 Keeper, Belt, Center Span Screw 3/8-16 x .875 146682 Spring, Return, Brake 17120614 123666X Pulley, Transaxle 123533X Cover, Pedal Pulley, Engine 12000028...
Page 38
TRACTOR - - MODEL NUMBER 917,274650 STEERING ',i_1 steering stealth prem...
Page 39
TRACTOR - - MODEL NUMBER 917,274650 STEERING PART DESCRIPTION 186094X428 Wheel Steering 184706 Axle Asm 169840 Spindle Asm LH 169839 Spindle Asm RH 6266H Bearing Race Thrust Harden 121748X Washer 25132 x 1-5/8 x 16 Ga. 12000029 Ring Klip #t5304-75 175121 Link Drag STD551137...
Page 40
TRACTOR - - MODEL NUMBER 917,274650 ENGINE ,105 OPTIONAL EQUIPMENT Spark Arrester engine-kohler KEY PART PART DESCRIPTION DESCRIPTION 176636X505 Control Throttle 123487X Clamp Hose Black 191611 Screw 10 x 3/4 Single Lead Hex 8543R Line Fuel Engine, Kohler Model 181654 Plug Drain Oil Easy SV590-0002 (See Breakdown)
Page 41
TRACTOR - - MODEL NUMBER 917.274650 SEAT ASSEMBLY /" /" seat It knob PART PART DESCRIPTION DESCRIPTION 180598 Seat 121248X Bushing Snap BIk Nyl 50 Id 180166 Bracket Pivot Fender 72050412 Bolt Rdhd Sqnk 1/4-20 x 1-1/2 STD523710 Bolt Fin Hex 3/8-16 uric x 1 121249X Spacer...
Page 45
TRACTOR- - MODEL NUMBER 917.274650 MOWER DECK KEY PART KEY PART DESCRIPTION DESCRIPTION 182032 Mower Housing 137729 Screw, Thd. Roll 1/4-20 x 5/8 STD533107 Bolt 178515 Washer, Hardened 138017 BracketAssembly,Sway Bar, Fn 155046 Arm, Idler 165460 BracketSway Bar 38142" 165723 Spacer, Retainer STD624008 Retainer Spring...
Page 46
TRACTOR - - MODEL NUMBER 917,274650 PEERLESS TRANSAXLE--MODEL NUMBER 206-545C _ODEL and SERIAL NUMBERS HERE...
Page 47
TRACTOR - - MODEL NUMBER 917.274650 PEERLESS TRANSAXLE--MODEL NUMBER 206-545C KEY PART KEY PART DESCRIPTION DESCRIPTION 790079 Brake Lever Transaxle Cover 772147 Screw 1/4 - 20 x 1-1 /4" 792073A 780086A Needle Bearing 5/8" Screw 1/4 - 20 x 2 1/4" 792085A Transaxle Case 770128...
Page 48
TRACTOR - - MODEL NUMBER 917,274650 KOHLER ENGINE-MODEL NUMBER SV590, TYPE NUMBER 0002 CRANKCASE...
Page 49
TRACTOR - - MODEL NUMBER 917.274650 KOHLER ENGINE-MODEL NUMBER SV590, TYPE NUMBER 0002 HEADNALVE/BREATHER CRANKCASE PART PART DESCRIPTION DESCRIPTION 20 096 07-S Kit, valve cover (Includes Crankcase (USE: Short Block 20 20 041 13-S Gasket, valve cover 522 01) M-645020-S Screw, hex.
Page 50
TRACTOR - - MODEL NUMBER 917.274650 KOHLER ENGINE-MODEL NUMBER SV590, TYPE NUMBER 0002 BLOWER HOUSmNG AND BAFFLES mGNmTmONIELECTRmCALJ...
Page 51
TRACTOR - - MODEL NUMBER 917.274650 KOHLER ENGINE-MODEL NUMBER SV590, TYPE NUMBER 0002 IGNITION/ELECTRICAL PART DESCRIPTION 20 162 02-S Screen, grass 12 086 14-S Screw, hex. flange M10x1.5x46 12 468 03-S Washer, spring 3/16" 20 146 02-S Plate, fan mounting 20 157 01-S X-42-15-S Key, woodruff...
Page 52
TRACTOR - - MODEL NUMBER 917,274650 KOHLER ENGINE-MODEL NUMBER SV590, TYPE NUMBER 0002 OIL PAN/LUBRICATiON '_3 ..
Page 53
TRACTOR - - MODEL NUMBER 917,274650 KOHLER ENGINE-MODEL NUMBER SV590, TYPE NUMBER 0002 STARTING SYSTEM PART DESCRIPTION 20 098 01-S Starter assembly, inertia drive 25 100 31-S Nut, hex. serrated flange (2) OIL PAN/LUBRICATION PART DESCRIPTION 20 040 02-S Kit, dipstick assembly (Includes 20 153 01-S...
Page 54
TRACTOR - - MODEL NUMBER 917.274650 KOHLER ENGINE-MODEL NUMBER SV590, TYPE NUMBER 0002 EXHAUST CRANKSHAFT FUEL SYSTEM...
Page 55
TRACTOR - - MODEL NUMBER 917.274650 KOHLER ENGINE-MODEL NUMBER SV590, TYPE NUMBER 0002 CRANKSHAFT PART DESCRIPTION 20 014 14-S Crankshaft (includes X-42-15-S Key 3/16" 20 043 12-S Gear, crankshaft EXHAUST PART DESCRIPTION 25 072 04-S Stud, exhaust 20 041 12-S Gasket, exhaust 20 522 01...
Page 59
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. down the face of slopes, never across the face, Do not mow ARNING: To avoid serious injury, operate your tractor up and slopes greater than 15 degrees, Make turns gradually to prevent tipping or loss of control.
Page 60
Your Home For repair - in your home - of all major brand appliances, lawn and garden equipment, or heating and cooling systems, iiiiiiiiiiiiiiiii: no matter who made it, no matter who sold it! iiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiii: For the replacement parts, accessories iiiiiiiiiiiiiiiii owner's manuals that you need to do-it-yourself.