Download Print this page

Advertisement

_ MODEL
NO,
_ 298.586190'
owner's
responsibilil),
• mainlenance
• operalion
,,Iroub#e
shootin K
= replacemenl
paris
.••,L
%••-
,
-
. .
I_ublieation
No ....
970-35125-20
!
,. r
t

Advertisement

   Summary of Contents for CRAFTSMAN Gamefisher 298.586130

  • Page 1

    _ MODEL _ 298.586190' owner's responsibilil), • mainlenance • operalion ,,Iroub#e shootin K = replacemenl paris .••,L %••- ,. r I_ublieation No ..970-35125-20...

  • Page 2

    Page No. 'SPECIFICATIONS .._: ..:..:(.._=_..?:....STEERING HANDLE INSTALLATION ::_::. i_.i. i_:_!:::: !MAINTENANCE ... ,..!._i...i:..!:i_ MUFFLER :INSPECTION ...._ "_ _:_i;_; " " :PROLONGED :STORAGE ";:t:" =:;::_!i_ _ ..... OPERATIONS ...._. . ,_: _::_.. ;, ..

  • Page 3

    ..IMPORTANT Owner's Responsibility and Operating Safety Check List BE SURE TO READ.AND DO THE-FOLLOWING BEFORE OPERATING YOUR.OUTBOARD MOTOR :SAFETY CHECK LIST " '" :- ..... Learn observe the boating laws of the U.S. Coast, Guard, state, local author- ities. U.S, Coast Guard regulations require...

  • Page 4

    MAJOR PARTS Spark Plug Eever Choke Lever SteeringHandle Fue! Shul-off Valve Transom 8rackel Tilt Pin Adjuslrnent " ClampSled Handles MolllerPipe. . DriveShall Pipe Exhaust O uttel ilalion Plale CoUerPin GearHousing Fill and l]rain Plu_ Propeller_ GearHousing Cover Figure I Figure 2 ..... Figure 3...

  • Page 5

    MAINTENANCE FEATURE INFORMATION This outboard motor speciaJ design Wilen lubricant has completely drained, features as shown in Figure replace parts refill gear housing Your selection our Marine Products wilt using filling procedure abov e, provide with many hours of enjoyable best results, lubricate...

  • Page 6

    OPERATION BOAT MOUNTING Mount the motor on the center of the boat transom (stern), (See Figure 4). View oow o ow. CAUTION Hand ti9hten xransom bracket and ctarnp stud handles simultaneously. Do not use a wrench any other device that would cause damage brackets.

  • Page 7

    OPERATION 8_ 2-CYCLE ENGINE FUEL MIXTURE Use a good grade of regular gasoline. (See mix- :'AIR ing table below,) CAUTION Always use BIA certified TC-W oil in the 50:1 ratio. Failure to do so m_y result in excessive spark plug fouling, piston scoring,...

  • Page 8

    OPERATION FLOODING To dear engine of excess fu el, move choke lever CARBURETOR "Off_' position throttle ]ever to half throttle position: Pu|l recoil :starter= handte until engine starts andcontinues to,run; CARBURETOR--ADJUSTMENTS Your motor has:a:fixedhigh speed jet. Idte Adjustment been:'p_eset factory. (SeeFigure NLET 8OLT...

  • Page 9

    OPERATION FLYWHEEL MAGNETO IGNITION SYSTEM WITH TRANSISTERIZED ELECTRONIC IGNITOR • " ": The magneto ignition system consists ol the following component Parts: Flywheel, Tran- sisterized Electronic Ignitor and ignition Coil. b. Inspect following if engine fails or =iS hard to start: CENT£R BOLT Spark...

  • Page 10

    TROUBLE SHOOTING CHECK LIST _Take your outboard motor into any one of over 2000 Sears Service Units. Fuel Tank Empty ..Fuel Shut.Off Valve Closed Fuel Line Kinked orl;inched Vent Screw on Fuel Tank Filter Cap Closed Carburetor Passages Clogged or Dirty •...

  • Page 11

    REPLACEMENT PARTS _ ..FOR::I MODEL No.298.586130...

  • Page 12

    FilJo _ I_qIJ ! Ir'_llE _----70 27-- . ,ii...

  • Page 13

    P.P.No. PARTS NAME FIG.! ENGINE 1-002 157_0_000-900 1-003 018_005_6-200 !- 00', OOZ-OOSOO-O0_ I_005 017-00501_Z02 l-OOl 0_I-00000-200 1-O08 1-009 o_&-00500-200 031-00000-200 1-010 1-011 0_6-00551-801 t-012 01_II-02000-200 1-0t l-Olg JOgD-OloOO-ZO0 l_Ol =999-66152-50D t-011 0)8-00000-200 oTz-Oo _a_- l-O_O I-G2_, UII-OZO01-200 0II-0200t-210 1-02£ l-ozq 0110Z001-220 1-02_ 01IrO2OOT-Z_O...

  • Page 14

    ,Jar w _qa_ w a Sl[E FIG,4...

  • Page 15

    REF.No. P.P.No, PAFIfS NAME O'ty FIG.2 TANK, CLUTCH & MUFFLER 5O_'-l_lO0-O0_ I;NK ASS'¥ 300=}5 108,T200 _N,GINE SId&LIU(Jt :fAI4K tJOOL:}51OOZzO:_j SUPI'URE aitibifed l- 3S 100-,"0'_ Ftl6t I ANR $92-0015Q-900 P£1-CO_R &SS*Y 700-Oi|O_-lBO FU_LI'IP[ -fxto.sxlso 680-O0610-ZOX C[IP " _0)-0000[-200 INLET HAtlI[OLQ CASKET _g)-OOO0_-20| "l_t£1 HllllFOiO...

  • Page 16

    ftCI.UIi. _IAKikK I'I_,+ P.P.No. PARFS !_AME +-REE.o+ O'ty FIG.3 RECOIL STARTER _-o00 I_;0053r-900 _+_[Eoll St."+Rrtr, A%_,_' .1- 001 ;_'_3;+O0+J+_Ip-+O0 +_14RltR PtlDY II[__DIL 77t+-Oe+OlS+20_ _+T_RIFR ROP[ RE_L 3-002 ' 3-00_ 1?gLOIOOO-+Ol ,ml'CtHt 5rr+lmr+ ]_OOt+ PI_LL_Y _'+,'b-OlOOt+-+O! _!|A_+ I ?_1-00511+?o0 SIART(R Rt)PE _._,KI_O0 3 - 006 "/_tO-OOl_+tJ!-ZOI...

  • Page 17

    CARBURETOR ...... U..--'0 \ .I l !_'?f / NAME RERNo I P PNo PAR] S O'ly FIG.4 CARBURETOR 455- 22_f_- IJAItltlIII| llilt tt$SIY - 0oo 560- 226ft2-200 ltlltlll £11 I]Jl • Iltlltllllt [k|lt{ ttllllt_lll! 5_1 !" 2Z/_!) ]l"21)0 _llfl¥...

  • Page 18

    FIG.5 HANDLE & BRACKET f 30 "13 ff'O...

  • Page 19

    R0 0:I [ P.P.No. P.,:\RTS IIAME FIG.5 HANDLE & BRACKET 5-ooi YIIROIII.f WlllE C0MPo 68_-005_B-8001 5-002' 810-00569-_00 111€10111.[ tEVflt ASS'Y PLASII[. 5-00) JOJ_H! PIPE I_5-ISI18-200 HOLO_A S- 00.'+ SC_:W _,XlB _--005 S_ H/_SI(EE _90-21Ob0-302 5-006 00). I _X3O 5_OOT S* HASI'_E:_ 5-000 1_0-15118-90t 51E[RING...

  • Page 20

    t'l_oO UKIVE 5HAFT PIPE-& GEAR CASE...

  • Page 21

    rip.No. I p,r,rs s.P,,+o. • ] FtG,6 DRIVE SHAFT:PIPE & GEAR CASE 6-001 0'_0:351|8-900 JOlrll _+ [ l'_" AS S' _I' OlS-b_&Oi_+ZO_ _-00 07b-]SIO0-ZO_ |}RIVE 0_6_5100+Z00 |t_ b.g I N G t_)L()t SPIi I tl_ UI_,Aig I tt_ tii_Lo_ O}_-_S|O0-ZO] PaCgltt_ O_i+_510O-aGZ $OlHt...

  • Page 22

    FIG.7 TOOLS REF.Ho, I P.P.i'-Jo. PARTS :"NAME' 'O'ty FIG.7 TOOLS t-DO0 /'-{)01 PlUS FIDX SPAhlrIER sr^i_K "1-0_2 130 l 2_1(_ ?rio00- _t^III_Ir nx IO r - fjn :It ,_ 2 - 2 Of.) Ol.! - 2011 rIIj_ I)f_IVl...

  • Page 23

    MODE L NO. 9g_L 586130 For quick service or 'repa{r take your Outboald Motor to any Sears Service Unit throughoul FULLONE YEAR.WARRANTY ON LJ.S, and Canada. Each Sewice Unit is staffed OUTBOARD MOTOR trail_ed technicians, usit)g Sears approved o_le ye;3r from first of usa...

Comments to this Manuals

Symbols: 0
Latest comments: