Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Turbo Air TCB-5R
Summary of Contents for Turbo Air TCB-5R
-
Page 2: Table Of Contents
CONTENTS INTRODUCTION SAFETY STICKERS INSTALLATION INSTRUCTIONS Inspection for damage Location of Bakery Case Leveling of Bakery Case PACKAGING MATERIAL LIGHTS SHELVES ELECTRICAL INFORMATION WIRING DIAGRAM OPERATING INSTRUCTIONS Controls Anti Moisture Fans How to place product Shelf placement Replacement of light FRONT CURVED GLASS MAINTENANCE &... -
Page 3: Introduction
INTRODUCTION This owner’s manual has important information. Please read the entire manual before installing your new Turbo Air Refrigerated Bakery Case. After reading manual if you have any questions, please fill free to call: CUSTOMER SERVICE DEPARTMENT TURBO AIR 1250 VICTORIA ST. -
Page 4: Safety Stickers
SAFETY STICKERS The following signs are thru out Turbo Air Bakery Case. If any are missing, Pleae call Customer Service so the sticker can be sent to you. DANGER HIGH VOLTAGE- This sticker is on back of bakery case. CAUTION- This sticker is below the Bakery display pan. -
Page 5: Installation Instructions
If after uncrating there is concealed damaged and crate was in good condition you must call Customer Service at Turbo Air. Concealed damage must be reported within 24 hours of receiving unit. Bill of lading will be requested faxed to claim department. Pictures may be requested of unit and crating. -
Page 6: Packaging Material
PACKAGING MATERIAL Remove all tape that holds lift up glass and doors in place. Some residue will be left and this can be removed with glass cleaner. Remove all plastic ties that hold shelves and brackets for shelves. LIGHTS Make sure lights are in their lamp holders. Also make sure plugs for lamp holders are completely plugged in. -
Page 7: Electrical Information
ELECTRICAL INFORMATION !!! BAKERY CASE MUST BE GROUNDED Only a licensed electrician must install all electrical on Bakery Case. All electrical must be done in accordance with applicable electrical standards. A dedicated breaker is to be used for each Bakery Case. Electrical must be grounded upon installation An access hole is provided thru base of case for running electrical up through floor. -
Page 8: Wiring Diagram
WIRING DIAGRAM(TCB-5R) -
Page 9: Operating Instructions
OPERATING INSTRUCTIONS After installing unit and all electrical to Bakery Case, unit is ready to start up. CONTROLS POWER SWITCH: It is labeled with on/off position. It controls power to the entire Bakery Case. LIGHT SWITCH: The switch controls the power to the lighting circuit. The switch rocker is red in the “on”... -
Page 10: Shelf Placement
SHELF PLACEMENT: The shelves can be installed slanted or straight. To make the shelf slanted do the following; a. Shelf needs to be removed from shelf support. b. Shelf support needs to be held at each end. c. Shelf support needs to be lifted at the back till bracket can inserted into shelf standard slots. Refer to drawing of pages 5. -
Page 11: Front Curved Glass
FRONT CURVED GLASS !!!WARNING The Bakery Case is not intended for self serve. Do not let customers lift front glass. Only trained personnel should lift curved glass. Under normal use hinges will last many years. If any of the following problems occur, plase call Customer Service;... -
Page 12: Maintenance & Cleaning
MAINTENANCE & CLEANING !!! Always before cleaning Bakery Case unit should be turned off at power switch and lights should be turmed off. Removed product and allow display to reach room temperature. !!! Do not wet electrical components. BAKERY CASE SHOULD BE CLEANED THOROUGHLY BEFORE FIRST USE. CLEANING DAILY a. -
Page 13: Condenser Coil
MAINTENANCE CONTINUED CONDENSER COIL a. Turn off unit at power switch. Disconnect power to unit. b. Remove rear grill. c. Clean condenser by either brushing off with stiff wire brush or vacuuming with wet/dry vacuum. Condenser is black and looks like a radiator. This should be cleaned every month or as necessary. -
Page 14: Troble Shooting
TROUBLE SHOOTING For any problems with BAKERY-Case please refer to following check list. If still having a problem or need to ask a question please call Customer Service at 1-800-381-7770 or 1-800-627-0032 BAKERY CASE NOT WORKING a. Check to see if breaker is not tripped. b. -
Page 15: Warranty Statement
Turbo Air and upon proper installation and start-up in accordance with the instruction packet supplied with each Turbo Air unit. Turbo Air's obligation under this warranty is limited to a period of one (1) year from the date of original installation or 15 months after shipment date from Turbo Air, whichever occurs first. - Page 16 THERE ARE NO WARRANTIES, WHICH EXTEND BEYOND THE DESCRIPTION ON THE FACE HEREOF. Outside U.S. and Canada : This warranty does not apply to, and Turbo Air is not responsible for, any warranty claims made on products sold or used outside the continent of the United States and Canada.