Table of Contents
Advertisement
CDST (See-through)
CDCL (Corner-Left)
RETAIN THESE INSTRUCTIONS
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
CDPF (Peninsula)
CDCR (Corner-Right)
FOR FUTURE REFERENCE
WH Report No. J20006712
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
HOMEOWNER'S CARE AND
OPERATION INSTRUCTIONS
DIRECT VENT
MULTI-OPEN SERIES
VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS
P/N 725,001M REV. F 09/2005
MODELS
M
l i
v i l
t l o
M
o
e d
C
D
S
T
C -
M
N
C
D
C
L
C
D
S
T
C -
M
P
C
D
C
L
C
D
P
F
C -
M
N
C
D
C
R
C
D
P
F
C -
M
P
C
D
C
R
A French manual is available upon request. Order Form Number
725,001CF.
Ce manuel d'installation est disponible en francais, simplement en
faire la demande. Numéro de la pièce 725,001CF.
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installeur, agence de service ou le fournisseur de gaz.
s l
E
e l
r t c
n o
c i
M
C -
M
N
C
D
S
T
C -
E
N
C
D
C -
M
P
C
D
S
T
C -
E
P
C
D
C -
M
N
C
D
P
F
C -
E
N
C
D
C -
M
P
C
D
P
F
C -
E
P
C
D
o
e d
s l
C
L
C -
E
N
C
L
C -
E
P
C
R
C -
E
N
C
R
C -
E
P
1
Advertisement
Table of Contents
Troubleshooting
Subscribe to Our Youtube Channel
Related Manuals for Superior MULTI-OPEN SERIES
Summary of Contents for Superior MULTI-OPEN SERIES
-
Page 1: Operation Instructions
HOMEOWNER'S CARE AND OPERATION INSTRUCTIONS DIRECT VENT MULTI-OPEN SERIES VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS P/N 725,001M REV. F 09/2005 MODELS CDST (See-through) CDPF (Peninsula) v i l t l o r t c A French manual is available upon request. Order Form Number 725,001CF. -
Page 2: Table Of Contents
GENERAL INFORMATION Note: Installation and repair should be per- In selecting this SUPERIOR Direct-Vent Gas Appliance you have chosen the finest and formed by a qualified service person. The appli- most dependable fireplace to be found anywhere. It's a beautiful, prestigious alternative ance should be inspected annually by a quali- to a wood burning fireplace. -
Page 3: Operation/Care Of Your Appliance
Carbon Monoxide Poisoning: Early signs of Operation of millivolt and electronic gas con- Do not use these appliances if any part has carbon monoxide poisoning are similar to been under water. Immediately call a qualified, trol systems are different. Before lighting professional service technician to inspect the the flu with headaches, dizziness and/or nau- and operating your appliance determine if... -
Page 4: Variable Flame Adjustment
Note: Clean glass after first two weeks of Variable Flame Height Adjustment Inlet Pressure Port operation. Manifold Pressure Port WARNING: DO NOT USE ABRASIVE CLEANERS. NEVER CLEAN THE GLASS WHEN IT IS HOT. CAUTION: DO NOT TOUCH THE FRONT ENCLOSURE GLASS WITH YOUR HANDS WHILE THE FIREPLACE IS IN USE. -
Page 5: Maintenance Schedule
Maintenance Schedule Annually (Before the onset of the Burning Season) Maintenance Task Accomplishing Person Procedure Inspect valve and ensure it is properly operat- Inspecting/Cleaning Burner, Logs Qualified Service Technician ing. Check piping for leaks. Vacuum the con- and Controls trol compartment, fireplace logs and burner area. -
Page 6: Burner Adjustments
Refer to Figure 4 and remove the front glass Burner Adjustments Air Shutter enclosure panel as follows: The following paragraphs address burner ad- Adjusting Burner Venturi Air Shutter justment concerns and procedures. Opening Tube 1. Remove the top louver assembly or radiant panel. -
Page 7: Glowing Embers (Rockwool)
Log Placement WARNING: LOG SET GETS VERY HOT AND WILL REMAIN HOT UP TO ONE HOUR AFTER GAS SUPPLY IS TURNED OFF. HANDLE ONLY WHEN LOG SET IS COOL. TURN OFF ALL GAS TO THE APPLIANCE BEFORE INSTALLING THE GRATE AND LOG SET. WARNING: THIS APPLIANCE IS NOT DESIGNED TO BURN WOOD. -
Page 8: Electronic Appliance Checkout
Electronic Appliance Checkout Electronic Wiring Diagram (Honeywell) Electronic Wiring Diagram (Honeywell) To light the burner, refer to the lighting instruc- Showing the Blower Wiring for the Optional Showing the Blower Wiring for the Optional tions on page 14 and 15 . Ensure the ignitor FBK-100 and FBK-200 Kits FBK-250 Kits lights the pilot. -
Page 9: Accessory Components
ACCESSORY COMPONENTS Door Frame Kits Two types of decorative door frame kits are available for use with these appliances - one in polished brass finish, the other, in brushed stain- less steel finish. The DFK is designed to attach directly to the front face of the appliance at its extreme edges. - Page 10 ACCESSORY COMPONENTS CONTINUED Clean Faced Panel Kit A clean faced panel kit is available to convert the standard louvered appliances to radiant models more suited for finishing around the firebox open- ing with non-combustible materials such as tile. s t i Remote Control System (Deluxe) H0251 RCL-T...
- Page 11 ACCESSORY COMPONENTS CONTINUED Door Frame Kits (2-Piece, Top and Bottom) Two types of decorative door frame kits are avail- able for use with these appliances - one, in pol- ished brass finish; the other, in brushed stainless steel finish. The DTK is designed to attach directly to the front face of the appliance at the glass enclosure panels top and bottom edges.
-
Page 12: Lighting Instructions - Millivolt
LIGHTING INSTRUCTIONS – MILLIVOLT GAS VALVE FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. This appliance has a pilot which must be lighted with a piezo •... - Page 13 INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A.
-
Page 14: Lighting Instructions - Electronic
LIGHTING INSTRUCTIONS — ELECTRONIC FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. When lighting the appliance, follow these instructions •... - Page 15 INSTRUCTIONS D’ALLUMAGE — ELECTRONIC POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT: SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A.
-
Page 16: Troubleshooting The Millivolt Gas Control System
TROUBLESHOOTING THE MILLIVOLT GAS CONTROL SYSTEM ote: Before troubleshooting, make sure that the appliance main line gas shut-off valve and the gas control valve are in the "OPEN" position and the burner ON/OFF switch is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. POSSIBLE CAUSES SYMPTOM CORRECTIVE ACTION... -
Page 17: Troubleshooting The Electronic Ignition System
TROUBLESHOOTING THE ELECTRONIC IGNITION SYSTEM ote: Before troubleshooting, make sure that the appliance main line gas shut-off valve and the gas control valve are in the "OPEN" position and the burner ON/OFF switch is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION... -
Page 18: Replacement Parts List
REPLACEMENT PARTS LIST . n i . n i , l e . n i , l e . n i . n i . n i , l e . n i , l e . n i i t a , t e , t e i t n... - Page 19 REPLACEMENT PARTS LIST GAS CONTROLS — SIT MILLIVOLT t i n t o l t o l t o l i f i GAS CONTROLS — HONEYWELL ELECTRONIC l l e t o l t i n ) t i i f i t o l NOTE: DIAGRAMS &...
- Page 20 REPLACEMENT PARTS Model CDPF Shown - see table on page 18 and 19 for replacement parts applicable to CDST, CDCR and CDCL Cabinet Firebox NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. The manufacturer reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information.
Need help?
Do you have a question about the MULTI-OPEN SERIES and is the answer not in the manual?
Questions and answers