Troubleshooting; Front Wheels - DAELIM ET-300 Service Manual

14-2 Troubleshooting

HARD STEERING
FRONT WHEEL WOBBLING
BRAKE DRAG
STEERS TO ONE SIDE
POOR BRAKE PERFORMANCE

14-3 Front Wheels

REMOVAL
(The disassemble of front wheel system
in this serials are the same)
Raise the front wheels off the ground by placing a jack
or other support under the frame.
Remove the front wheel nuts, washer and wheels.
INSTALLATION
Install and tighten the four-wheel nuts
Torque: 24 N.m (17.7 lbf.ft)
Remember put a cotter pin in the castle nut.
★ Faulty tire
★ Insufficient tire pressure
★ Faulty tire
★ Worn front brake drum bearing
★ Bent rim
★ Axle nut not tightened properly
★ Incorrect brake adjustment
★ Sticking brake cable
★ Bent tie rods
★ Wheel installed incorrectly
★ Unequal tire pressure
★
Incorrect wheel alignment
★ Brake shoes worn
★ Worn brake drum
★ Brake linings oily, greasy or dirty
★ Improper brake adjustment
Wheel nuts