Electrical System - Volvo S60 2001 Manual

2001 Volvo S60
Trunk lighting
Glove compartment lighting 2 W
Vanity mirror
pg. 199 Electrical system

Electrical system

12- volt system with voltage controlled generator. Single wire system in which the chassis and engine
block are used as conductors, grounded on the chassis.
Battery
Voltage 12 V
Cold start capacity (CCA) 600 A
Reserve capacity (RC) 115 min
If you must replace your battery, be sure to replace it with a battery of the same cold start capacity and
reserve capacity as the original (See the decal on the battery).
Generator max. current 120 A
Starter motor, power 1.4 kW
Spark plugs P/ N272313- 8 or equivalent
Gap 0.028- 0.032 in. 0.7- 0.8 mm
Tightening torque 22 ft. lbs. (30 Nm)
Firing order 1- 2- 4- 5- 3
Replacing spark plugs
The spark plugs should be changed every 30,000 miles (48,000 km). However, city driving or fast
highway driving may necessitate changing after 15,000 miles (24,000 km) of driving. When installing
new plugs, be sure to fit the right type and use correct torque. When changing the plugs, check that the
suppressor connectors are in good condition. Cracked or damaged connectors should be replaced.
When changing the spark plugs, clean the terminals and the rubber seals.
file:///K|/ownersdocs/2001/2001_S60/01s60_12.htm (8 of 11)12/30/2006 3:47:15 PM
5 W SV 8.5
BA 9 s
1.2 W SV 5.5