Table of Contents
Advertisement
Quick Links
French Manual: https://bit.ly/3di85j9
Manuel en Français : https://bit.ly/3di85j9
WARNING:
Improper installation, adjustment, alteration,
service or maintenance can cause injury,
property damage, or loss of life.
Refer to this manual. For assistance or
additional information consult an authorized
installer or service agency.
Tested by:
IMPORTANT: SAVE THESE INSTRUCTIONS
4001609
FPI FIREPLACE PRODUCTS INTERNATIONAL, LTD. 6988 VENTURE ST., DELTA, BC, CANADA V4G 1H4
920-552b
Greenfire
TECHNICAL MANUAL
Freestanding
Pellet Stove
FOR YOUR SAFETY:
Do not store or use gasoline or other flammable
vapours and liquids in the vicinity of this or
any other appliance.
Installation and service must be performed
by an authorized installer or service agency.
GF55-2
®
10.21.22
Advertisement
Table of Contents
Related Manuals for Greenfire GF55-2
Summary of Contents for Greenfire GF55-2
- Page 1 Greenfire GF55-2 ® TECHNICAL MANUAL Freestanding Pellet Stove French Manual: https://bit.ly/3di85j9 Manuel en Français : https://bit.ly/3di85j9 WARNING: FOR YOUR SAFETY: Improper installation, adjustment, alteration, Do not store or use gasoline or other flammable service or maintenance can cause injury, vapours and liquids in the vicinity of this or property damage, or loss of life.
- Page 2 The authority having jurisdiction should be consulted before installation to determine the need to obtain a permit. Emissions and Efficiency - GF55-2: This manual describes the installation and operation of the Regency GF55-2 pellet heater. This heater is U.S. ENVIRONMENTAL PROTECTION AGENCY certified to comply with 2020 particulate emission standards.
-
Page 3: Table Of Contents
Corner Through Wall Install ........10 Horizontal Exhaust Through Wall Install ....11 Vertical Rise with Horizontal Termination ....12 Through Concrete Wall with Vertical Rise .....12 Inside Vertical Installations .........12 Outside Vertical Installations .......13 Hearth Mount Installations ........13 Greenfire Pellet Stove Technical Manual... -
Page 4: Safety Label
SAFETY LABEL On the GF55-2 the safety label is located on the underside of the hopper lid. GF55 DECAL LOCATION Locate the rating plate on the GF55 by lifting up the hopper lid. The rating plate will be located on the underside of the hopper lid. -
Page 5: Unit Dimensions
24" (610mm) UNIT DIMENSIONS GF55-2 FREESTANDING PELLET STOVE " (586mm) " (40mm) " (494mm) " (866mm) " (332mm) " (620mm) " 24" (586mm) (610mm) " (146mm) 3" (76mm) " (41mm) " (866mm) " (508mm) " " (516mm) (356mm) " "... -
Page 6: Installation
A Greenfire dealer will fly ash. This is a very mild abrasive and will not damage the glass. -
Page 7: Removing Pellet Stove From Pallet
One screw can be easily seen from behind but to access the second screw the ashpan must be removed. See figure 1. Figure 1: Removing GF55-2 From Pallet. OPENING THE DOOR The door lever can be found inbehind the right side of the door frame. To open the door, pivet the lever outwards and upwards until it unlocks. -
Page 8: Gf55 Freestanding Pellet Stove
(152mm) *NOTE: If the unit is installed as a corner installation, clearances change from 2" to 3", see "Corner thru Wall Installation" section. Figure 4: Minimum Clearances to Combustibles Figure 6: Mobile Home Install Mounting Greenfire Pellet Stove Technical Manual... -
Page 9: Vent Termination Requirements
5. If the unit is incorrectly vented or the air to fuel mixture is out of balance, a slight discoloration of the exterior of the house might occur. Since these factors are beyond the control of FPI, we grant no guarantee against such incidents. NOTE: Venting terminals shall not be recessed into walls or siding. Greenfire Pellet Stove Technical Manual... -
Page 10: Exhaust & Fresh Air Intake Location
Fresh Air Intake " (508mm) " (356mm) 3" (7.5 cm) Wall thimble manufactured by pellet vent manufacturer. " " 1" (291mm) (170mm) (25mm) Figure 8: Freestanding Inlet and Outlet Location 3" (7.5 cm) Figure 10: Corner Installation Greenfire Pellet Stove Technical Manual... -
Page 11: Horizontal Exhaust Through Wall Install
45° elbow can be used as termination. The elbow must be turned down to prevent rain from entering. Figure 12: Straight through Wall Installation - Side View Greenfire Pellet Stove Technical Manual... -
Page 12: Vertical Rise With Horizontal Termination
(30cm) above the ground. Vertical vent pipe Clean out tee with Pipe adapter NOTE: All vent sections must maintain 3" (76 mm) clearances to combustibles. Figure 15: Inside Vertical Installation Figure 14: Vertical rise with Horizontal Termination Greenfire Pellet Stove Technical Manual... -
Page 13: Outside Vertical Installations
Masonry Fireplace Combustible Floor the ash dump. 3" (7.5cm) Support Figure 17: Hearth Mount - Side View bracket Tee with cleanout Type "L", "PL" or all fuel vent Fresh air intake Figure 16: Outside Vertical Installation Greenfire Pellet Stove Technical Manual... -
Page 14: Top Vent Adaptor Kit & 3'' To 6'' Flue Adaptor
A chimney when going through the wall or ceiling when using Simpson Duravent Duraplus/Duratech chimney systems. Not required with DuraTech Premium or DuraTech Canada. DTC ceiling supports feature a built-in flue extension which eliminates the need for this Simpson Duravent DVL adaptor. need for this Simpson Duravent DVL adaptor. Greenfire Pellet Stove Technical Manual... -
Page 15: Plated Door Installation
Clean all plated surfaces before starting the stove. Refer to "Cleaning wire and install Plated Surfaces in Routine Cleaning and Maintenance in the Owner's Manual. thermostat wires here. Figure 38: Thermostat wire placement Figure 37: Inner side of door Greenfire Pellet Stove Technical Manual... - Page 16 • If the flame is in the middle of these two characteristics with a bright yellow/orange, active flame with no black tips then the air is set for proper operation. Figure 42: Damper Knob Location Greenfire Pellet Stove Technical Manual...
-
Page 17: Troubleshooting Faq's
Pinch, break or blockage in Vacuum Hose - Check hose for pinch points or damage, replace or re-route as required. Blow out Vacuum Hose Blocked Hose Barb on Exhaust Channel - Use a paper clip to clean out Hose Barb or remove the Vacuum Hose from the Vacuum Switch and blow into the hose to remove blockage. Greenfire Pellet Stove Technical Manual... - Page 18 If the stove goes out and there are partially burned pellets left in the burn pot liner, the stove has shut down due to a lack of air, exhaust temperature, or power failure. Adjust the Slider / Damper. Check to see if the stove needs a more complete cleaning. Did the power go out? Contact your local Dealer for service. Greenfire Pellet Stove Technical Manual...
-
Page 19: Wiring Diagram
Green White Black White Thermostat Yellow Auger Motor 5 Amp Fuse Convection Blower Black Yellow White Blue Brown White Brown Purple Purple Grey Grey Orange High Limit Orange Temperature Switch 200 °F Connect Thermostat Here Greenfire Pellet Stove Technical Manual... -
Page 20: Parts List
63) GF55-063 Cabinet Side - Left GF55-036 Cleaning Rod Heat Tube 64) GF55 -100 Cabinet Side - Right 65) GF55-065 Pedestal Assembly 13) GF55-037 Burn Pot Assembly 14) GF55-038 Auger GF55-039 Auger Brass Bushing & Plate Greenfire Pellet Stove Technical Manual... -
Page 21: Pellet Stove Components
PARTS LIST PELLET STOVE COMPONENTS Greenfire Pellet Stove Technical Manual... -
Page 22: Gf55 Freestanding Pellet Stove
PARTS LIST GF55 FREESTANDING PELLET STOVE Greenfire Pellet Stove Technical Manual... -
Page 24: Warranty
All claims must be complete and provide full details as requested by FPI to receive consideration for evaluation. Incomplete claims may be rejected. Revision Date: February 2019 Regency Pellet Products Warranty Greenfire Pellet Stove Technical Manual... - Page 25 Freight damages for products or parts are not covered under the terms of the warranty. Products made or provided by other manufacturers and used in conjunction with the FPI appliance without prior authorization from FPI may void this warranty. Revision Date: February 2019 Regency Pellet Products Warranty Greenfire Pellet Stove Technical Manual...
- Page 26 To provide the best support for your product, we request that you complete a product registration form at http://www.regency-fire.com/Customer-Care/Warranty-Registration.aspx within ninety (90) days of purchase. Revision Date: February 2019 Regency Pellet Products Warranty Greenfire Pellet Stove Technical Manual...
- Page 27 For fireplace care and tips and answers to most common questions please visit our Customer Care section on our Web Site. Please feel free to contact your selling dealer if you have any questions about your Regency product. Greenfire Pellet Stove Technical Manual...
- Page 29 Notes Greenfire Pellet Stove Technical Manual...
- Page 30 Notes Greenfire Pellet Stove Technical Manual...
- Page 32 Dealer Name & Address: _______________________________________ ___________________________________________________________ Installer: ___________________________________________________ Phone #: ___________________________________________________ Date Installed: _______________________________________________ Serial #: ____________________________________________________ Printed in Canada Greenfire is a trademark of FPI Fireplace Products International Ltd. © Copyright 2022, FPI Fireplace Products International Ltd. All rights reserved.
Need help?
Do you have a question about the GF55-2 and is the answer not in the manual?
Questions and answers