Scheppach HP1100S User Manual
Plate compactor
Hide thumbs
Also See for HP1100S:
- Translation from the original instruction manual (49 pages) ,
- Original instruction manual (48 pages) ,
- Translation of the original instruction manual (45 pages)
Related Manuals for Scheppach HP1100S
Summary of Contents for Scheppach HP1100S
-
Page 1: Table Of Contents
Scope of delivery PLATE COMPACTOR Intended use HP1100S Safety regulations Assembly Pre-Operation Operation Maintenance Technical data Storage and transport Disposal and recycling Troubleshooting Declaration of Conformity AFTER SALES SUPPORT 00800 4003 4003 service.GB@scheppach.com Vers.No. 200908 Original instructions MODEL: HP1100S... - Page 2 Overview Overview HP1100S 200 ml Exciter Exciter Shaft Faster Slower 13.1 0.6 - 0.8 mm...
-
Page 3: Explanation Of Symbols
Wear ear muffs! Do not smoke in the Fuel lever. working area! Oil fill plug. Wear safety shoes! Throttle speed. Wear protective gloves! Warning! Hot Surface! Keep away from rotating parts! AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... -
Page 4: Introduction
I. INTRODUCTION Congratulations on choosing to buy a scheppach product. All products brought to you by scheppach are manufactured to the highest standards of performance and safety, and as part of our philosophy of customer service and satisfaction, are backed by our comprehensive 3 Year Warranty. -
Page 5: Layout
14. Bracket 15. Paving pad 16. Bolt M10x65 17. Bolt M10x30 18. Bolt M10x20 19. Lock washers 20. Lock nut 21. Lock nut 22. Washer 23. Washer 24. Spark plug spanner AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... -
Page 6: Scope Of Delivery
Attention! The device and packaging materials are not toys! Children must not be allowed to play with plastic bags, film and small parts! There is a risk of swallowing and suffocation! AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... -
Page 7: Intended Use
Engine may create sparks which may ignite the dust or fumes. Never run engine in an enclosed area. Exhaust gases contain deadly, poisonous carbon monoxide, which has no odour or taste. Exposure may AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... - Page 8 Never douse or squirt the unit with water or any other liquid. Keep handles dry and clean; free from oil and grease. Allows for better control of the plate compactor. AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S...
- Page 9 10) Never operate the unit at high transport speeds on hard or slippery surfaces. 11) Exercise extreme caution when operating on or crossing gravel drives, AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S...
- Page 10 • Even when all safety measures are taken, some remaining hazards which are not yet evident may still be present. • Remaining hazards can be minimized by following the instructions in “Safety regulations”, “Intended use”, and in the entire operating manual. AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S...
-
Page 11: Assembly
Using the lifting handle (10), lift the front of the plate compactor with one hand and with the other hand, pull the paving pad forward to align with the holes in compacting plate (11). AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... -
Page 12: Pre-Operation
WARNING! Do not overfilll the fuel tank. m WARNING! Do not smoke while re-fueling. Use unleaded petrol with a minimum of Octane 91. AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... -
Page 13: Air Filter
Make sure that the electrode is clean and the air gap is correct (refer to the specs of the spark plug manufacturer). To remove, install and inspect the spark plug refer to the maintenance section of this instruction manual. AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... -
Page 14: Operation
Move the throttle lever (1) downwards to slow the engine speed and allow to idle for 10-20 seconds. Turn the engine On/Off switch (7) to the OFF position and move the fuel lever to the left/closed position. (Fig. 11) AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... -
Page 15: Maintenance
Using the spark plug spanner (24), remove the spark plug. Clean the electrode with a metal brush and remove any carbon build-up. Using a thickness gauge, check for the right gap (0.6-0.8mm) between the AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... -
Page 16: Tensioning V-Belt(S)
When the V-belt tension is correct, tighten the 4 engine mount bolts (C) and the lock nuts (B). Replace the belt guard. m WARNING! When removing or installing the drive belt(s), be careful not to get your fingers caught between the belt and pulley. AFTER SALES SUPPORT 00800 4003 4003 MODEL: HP1100S... -
Page 17: Exciter Lubrication
5500 Centrifugal force Compaction depth Travel speed m/min Plate size 530x350 Weight Subject to technical modifications! AFTER SALES SUPPORT AFTER SALES SUPPORT 1300 855 831 support@scheppach.com.au 00800 4003 4003 MODEL: HBS20 PRODUCT CODE: 53496 05/2016 MODEL: HP1100S... -
Page 18: Storage And Transport
(Fig. 20) Attention! The machine must be lifted by two persons. AFTER SALES SUPPORT AFTER SALES SUPPORT support@scheppach.com.au 1300 855 831 00800 4003 4003 MODEL: HBS20 PRODUCT CODE: 53496 05/2016 MODEL: HP1100S... -
Page 19: Disposal And Recycling
Defective components must be disposed of as special waste. Ask your dealer or your local council. AFTER SALES SUPPORT AFTER SALES SUPPORT 1300 855 831 support@scheppach.com.au 00800 4003 4003 MODEL: HBS20 PRODUCT CODE: 53496 05/2016 MODEL: HP1100S... -
Page 20: Troubleshooting
Set the throttle lever at lower speed. hard ground. (machine jumps or lurches forward) AFTER SALES SUPPORT AFTER SALES SUPPORT support@scheppach.com.au 1300 855 831 00800 4003 4003 MODEL: HBS20 PRODUCT CODE: 53496 05/2016 MODEL: HP1100S... - Page 21 HBS20 HP1100S <Chapter> AFTER SALES SUPPORT AFTER SALES SUPPORT 1300 855 831 support@scheppach.com.au 00800 4003 4003 MODEL: HBS20 PRODUCT CODE: 53496 05/2016 MODEL: HP1100S...
-
Page 22: Declaration Of Conformity
UE i normami erklærer herved følgende samsvar under EU-di- rektiv og standarder for følgende artikkel izjavlja sledeco skladnost z EU-direktivo in normami za artikel Plate Compactor - HP1100S 2014/29/EU 2006/42/EC Annex IV 2014/35/EU 2000/14/EC_2005/88/EC...
Need help?
Do you have a question about the HP1100S and is the answer not in the manual?
Questions and answers