Page 1: Table Of Contents
Connecting the pump for more information Other Products 15,16 manual. Failure to do so could result in property damage, about the PHCC-1000 Connecting the battery serious injury, or death. Battery Backup Sump Connecting the charger Pump System...
Page 2: Important Safety Warnings And
Important Safety • DO NOT pull on the float switch cord. • Wear eye and clothing protection and avoid • Remove personal metal items such as rings, touching your eyes while working with bracelets, watches, etc. when working with Warnings & Instructions •...
Page 3: Introduction
Introduction The battery-operated Pro Series 1000 backup sump pump system, designed as an emergency backup to support your main AC sump pump, automatically will begin pumping any time the float switch is activated by rising water. Should any malfunction or emergency occur that involves the sump pump, the battery, or the AC power, the Pro Series Battery Box...
Page 4: Pump & Pipe
Pump & Pipe NORMAL SUMP PIT Installation Instructions INSTALLATIONS Two basic methods can be used to install the pump: a direct discharge to the outside of the building or a connection to an existing discharge pipe. The same two options apply in very narrow sump pits where the backup pump must be mounted above the main pump.
Page 5 Pipe & Pump The pump’s strainer must be kept clear. The including vertical and horizontal runs in the pump should not be set directly onto a clay, installation, install a check valve in place Installation Instructions earthen, or sand base. Install a sump foot of the union.
Page 6: Connection To Existing Discharge
Pump & Pipe Installation Instructions INSTALLATION B: CONNECTION TO AN EXISTING DISCHARGE PIPE (Diagram B) Depending on your installation requirements, PVC pipe lengths will vary. Cut the pipes and assemble them as shown in photo #7. Do not cement them together until you are sure they are cut to the correct lengths.
Page 7: Direct Discharge For Narrow Sumps
Pump & Pipe attach the strainer to the “L” bracket. (c) When directly discharging to the outside arrow pointing up or it will not prevent the Once the strainer is attached, simply press of the building, no check valve is required. backflow of water.
Page 8: Connection To Existing Discharge
Pump & Pipe 1. Attach an “L” bracket to the discharge pipe 5. Install a check valve on the top of the the discharge pipe with the wye extension of the main AC pump with two (2) stainless- PVC pipe attached to the Pro Series facing down toward the backup pump.
Page 9: Battery Instructions
Battery Instructions The Pro Series Maintenance Free Standby Battery (B12-100) has been designed to run this system for an extended period of time. Typically the pump will turn on and off, and the battery will run the pump intermittently for days. The unique materials in this battery enable it to last longer in standby service.
Page 10: Understanding The Warning
Understanding the plugged into the wall outlet. Verify the During a power outage or times when the outlet is working. pump is activated repeatedly, you can Warning Lights & Alarms temporarily silence the alarm by sliding 3. Check the charger plug that fits into the the “Audible Alarm”...
Page 11: Cleaning Battery Terminals
➂ CLEANING THE BATTERY the BLACK wire to the NEGATIVE (-) bolt. • If the battery terminals have been cleaned System is operating Tighten the battery bolts. and the light is still on, the controller or TERMINALS AND CABLES the battery could have an issue. The best 11.
Page 12: Replacing The Battery
6. Clean any corrosion off of the ring 9. If any of the alarms are sounding, press 4. Unscrew the battery bolts and remove the connectors on the ends of the battery the RESET button on the front of the battery cables.
Page 13: Maintenance Checklist
Troubleshooting Guide empty all the water in the sump pit. While the pump is active, water will come out of Read safety warnings & instructions before attempting any repairs or maintenance. DANGER ″-inch hole that was drilled into the PVC discharge pipe. This is normal. The hole BATTERY PROBLEM Potential Cause Solutions...
Page 14 LIMITED WARRANTY By opening this package and using this GLENTRONICS, INC. product, you are agreeing to be bound by the terms of the GLENTRONICS, INC. limited warranty (“warranty”) as set out below. Do not use your product until you have read the terms of the warranty. If you do not agree to the terms of the warranty, do not use the product and return it within the return period stated on your purchase receipt from the retail store or authorized distributor where you purchased it for a refund.
Page 15 This proprietary powder is made from a naturally occurring compound, is 100% The Pro Series Pumps line of AC sump pumps If you’ve spent any time in your basement, biodegradable and environmentally friendly, and sewage pumps are strong, dependable, you’ve probably noticed the sump pump turning...
Page 16 Water Alarms & Accessories Water Alarm 360° Sensor 360° Water Alarm Pro Series CONNECT High Water Accessory PWA2 PS-WS360 PWA-360 PS-WS FEATURES AND BENEFITS: FEATURES AND BENEFITS: FEATURES AND BENEFITS: ƒ Patented 360˚ sensing technology detects FEATURES AND BENEFITS: water when placed on any side, top or ƒ...

Pro Series Pumps PHCC-1000 Instruction Manual & Safety Warnings

Quick Links

Table of Contents

Need help?

Questions and answers

Related Manuals for Pro Series Pumps PHCC-1000

Summary of Contents for Pro Series Pumps PHCC-1000

Table of Contents