Summary of Contents for Kärcher TRAILER 3500H HDS 4.7/35
Page 1
TRAILER 3500E HDS 4.7/35 Operator Manual English TRAILER 3500H HDS 4.7/35 per- fuel torch per- where RISK open amme FIRE. . Ne opérati / PR Operat e only liquids. où les. RISQU e est el fuego o llama FUEGO EXPLO SION.
Machine Data Label MODELS: 1.103-850.0 Trailer Karcher 3500E HDS 4.7/35 1.103-851.0 Trailer Karcher 3500H HDS 4.7/35 Introduction Thank you for purchasing this Pressure Washer. We reserve the right to make changes at any time without incurring any obligation. Owner/User Responsibility: The owner and/or user must have an understanding of the manufacturer’s operating instructions and warnings before using this pressure washer.
How To Use This Manual This manual contains the following sections: The SAFETY section contains important information regarding hazardous or unsafe practices of the • How to Use This Manual machine. Levels of hazards are identified that could • Safety result in product damage, personal injury, or severe •...
Safety Important Safety Information 4. Follow engine fuel recommendation in the engine manual provided. WARNING: To reduce the risk of 5. Use only kerosene, No. 1 home heating fuel, or WARNING injury, read operating diesel for the hot water burner. If diesel is used, instructions carefully before add a soot remover to every tankful.
Page 6
Safety WARNING: High pressure spray WARNING: Risk of injury. Hot WARNING can cause paint chips or other surfaces can cause burns. Use WARNING particles to become airborne and only designated gripping areas fly at high speeds. To avoid of spray gun and wand. Do not personal injury, eye, hand and place hands or feet on non- foot safety devices must be...
Page 7
Safety WARNING: High pressure WARNING: Risk of asphyxiation. WARNING developed by these machines WARNING Use this product only in a well will cause personal injury or ventilated area. equipment damage. Keep clear of AVERTISSEMENT: Risque nozzle. Use caution when d'asphyxie : Utiliser ce produit operating.
Safety Checklist - Before Your First Trip 19. Do not overreach or stand on unstable support. Keep good footing and balance at all times. • Tire Pressure and Tire Condition 20. Do not operate this machine when fatigued or • Wheel Lugs* under the influence of alcohol, prescription medica- •...
Important Trailer Safety Information Referencing the Utility Trailer in this Understanding Tire Pressure and Load Manual Limits Tire inflation pressure is the level of air in the tire that All references to the trailer or component parts to either provides it with the load-carrying capacity and affects the left or right are made with the assumption that you are overall performance of the trailer.
Important Trailer Safety Information Tire Size NOTE: Checking all of the above steps before every trip is key for safety. To maintain the trailer's carrying capacity and safety, IMPORTANT: The load must be distributed equally purchase only the same size tires as what were origi- on the bed of the trailer if possible.
Important Trailer Safety Information Trailer Ball & Couplers Bolting Instructions: WARNING: Failure to properly engage the hitch ball Align holes in coupler and mounting bracket. in the coupler ball socket and securely lock the NOTE: Coupler must be secured to mounting bracket coupler latch mechanism can cause the trailer to using two sets of holes in the mounting bracket.
Safety Repeat the above steps. the coupler onto the ball with the coupler latch in the vertical position. Continue to lower the trailer tongue until 5. OPTIONAL: Place a 5/16” pin or lock in hole shown the jack clears the ground, then flip the coupler latch to To Uncouple: its locked (horizontal) position.
Safety The GVWR is the maximum carrying capacity of the trailer with its respective tires. It may not necessarily equal the total GVWR of the trailer less the empty weight of the trailer because there may be another controlling factor such as frame strength that reduces the carrying capacity to what is listed on the VIN tag.
What To Check and How to Check it Tire Pressure Proper air pressure for your tires is printed on the TIRE AND LOADING INFORMATION RENSEIGNEMENTS SUR LES PNEUS ET LE CHARGEMENT sidewall. Check pressure while tires are cold. Do not The weight of cargo should never exceed raise or lower pressure to meet load.
What to Check and How to Check Correct Ball Seating Ball Coupler Hitches NOTE: Tire wear should be checked frequently because once a wear pattern becomes firmly Coupler assembly includes a latch lever and latch lever established in a tire it is difficult to stop, even if the safety pin or hitch pin.
What to Check and How to Check Breakaway Switch & D.O.T. Wet Cell 4. Replace pin and secure to tow vehicle. Do not loop over hitch ball. Battery 5. Plug 12V connector into tow vehicle receptacle. After hitching to the tow vehicle, pull the safety pin on the breakaway switch.
Maintenance Brake Adjustment Brake Cleaning & Inspection Brakes should be adjusted (1) after the first 200 miles Your trailer brakes must be inspected and serviced at of operation after the brake shoes and drums have yearly intervals or more often as use and performance “seated”, (2) at 3000 mile intervals and (3) as use and require.
Page 18
Maintenance Trailer Storage CAUTION: Do not get grease or oil on brake linings or magnet face. Preparation ATTENTION: Ne pas permettre à de la graisse ou de If your trailer is to be stored for an extended period of l'huile d'entrer en contact avec les garnitures de time or over the winter, it is important that the trailer be frein ou l'aimant.
Maintenance Pressure Washer Troubleshooting Problem Possible Cause Solution Faulty pressure gauge Install new gauge. Use larger supply hose; clean filter at water Insufficient water supply inlet. Match nozzle number to machine and/or Old, worn or incorrect spray nozzle replace with new nozzle. Belt slippage Tighten or replace;...
Page 21
Maintenance Problem Possible Cause Solution Clogged burner nozzle Clean as required. Thermostat faulty or slow engine speed Increase engine RPM to increase voltage. BURNER WILL Remove, test for continuity and replace as NOT LIGHT Flow switch malfunction needed. Flow solenoid malfunction Replace if needed.
Page 22
Maintenance Pressure Washer Troubleshooting Problem Possible Cause Solution Incoming water to machine warm or hot Lower incoming water temperature. Fuel pump pressure too high See specifications for proper fuel pressure. Fuel pump defective Replace fuel pump. Tighten all clamps. Check detergent lines for WATER Detergent line sucking air holes.
Page 23
Maintenance Problem Possible Cause Solution Check water supply and possibility of air Pump sucking air seepage. PUMP RUNNING Valves sticking Check and clean or replace if necessary. NORMALLY BUT PRESSURE LOW Check and replace if necessary (See serial Nozzle incorrectly sized ON INSTALLATION plate for proper size).
Maintenance This pressure washer was produced with the best available materials and quality craftsmanship. However, you as the owner have certain responsibilities for the correct care of the equipment. Attention to regular preventative maintenance procedures will assist in preserving the performance of your equipment. Contact your dealer for maintenance.
Maintenance Preventative Maintenance This trailer was produced with the best available materials and quality craftsmanship. However, you as the owner, have certain responsibilities for the correct care of the equipment. Attention to regular preventative maintenance procedures will assist in preserving the performance of your equipment. MAINTENANCE SCHEDULE Tire Air Pressure Inflate to proper pressure indicated on sidewall...
Page 26
THANK YOU! MERCI! GRACIAS! DANKE! Register your product and benefit from many advantages. Enregistrez votre produit et bénéficiez de nombreux avantages. Registre su producto y aproveche de muchas ventajas. Registrieren Sie Ihr Prudukt und Sie von vielen Vorteilen. www.kaercher.com/welcome Rate your product and tell us your opinion. Évaluez votre produit et donnez-nous votre opinion.
Need help?
Do you have a question about the TRAILER 3500H HDS 4.7/35 and is the answer not in the manual?
Questions and answers