Subscribe to Our Youtube Channel
Related Manuals for Napoleon PT308RB
Summary of Contents for Napoleon PT308RB
- Page 1 This Owner's Manual is provided and hosted by Appliance Factory Parts. Napoleon PT308RB Owner's Manual Shop genuine replacement parts for Napoleon PT308RB Find Your Napoleon Grill Parts - Select From 264 Models -------- Manual continues below --------...
- Page 2 Notice to Installer: Leave these instructions with the grill owner for future reference. Manufactured by: Napoleon Appliance Corp., 214 Bayview Dr., Barrie, Ontario, Canada L4N 4Y8 Phone: (705)726-4278 Fax: (705)725-2564 email: care@nac.on.ca web site: www.napoleongrills.com...
- Page 3 NAPOLEON will not be responsible for the installation, labor or any other costs or expenses related to the re-installation of a warranted part, and such expenses are not covered by this warranty.
-
Page 4: Safe Operating Practices
WARNING! Failure to follow these instructions could result in property damage, personal injury or death. Read and follow all warnings and instructions in this manual prior to operating grill. Safe Operating Practices • Read the entire instruction manual before operating the gas grill. •... -
Page 5: General Information
General Information This gas barbecue is CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS, CSA 1.6-2007 AND ANSI Z21.58-2007 RESPECTIVELY FOR outdoor gas grills and should be installed TO CONFORM WITH LOCAL CODES. In absence of local codes, install to the current CAN/CSA-B149.1 Propane Installation Code in Canada or to the National Fuel Gas Code, ANSI Z223.1 in the United States. -
Page 6: Leak Testing Instructions
Bubbles will indicate a gas leak. Either tighten the loose joint or have the part replaced with one rec- ommended by the Napoleon Customer Care department and have the grill inspected by a certified gas installer. -
Page 7: Lighting Instructions
Lighting Instructions 308 Series 450 Series Rear Burner Lighting Hole Lighting Hole Igniter Left Burner Rear Burner Right Burner Igniter Left Burner Centre Burner Right Burner Off Position WARNING! Open lid WARNING! Ensure all burner controls are in the off position. Slowly turn on the gas supply valve. -
Page 8: Cooking Instructions
Should a flare-up occur, move food away from the flames and reduce the heat. Leave the lid open. See Your All Season Grill cookbook by Napoleon for more detailed instructions. Direct Cooking: Place food to be cooked on the grill directly over the heat. This method is generally used for searing or for foods that do not require prolonged cooking times such as hamburgers, steaks, chicken pieces, or vegetables. -
Page 9: Cleaning Instructions
Cleaning The Outer Grill Surface: Do not use abrasive cleaners or steel wool on any painted, porcelain or stain- less steel parts of your Napoleon Grill. Doing so will scratch the finish. Exterior grill surfaces should be cleaned with warm soapy water while the metal is still warm to the touch. To clean stainless surfaces, use a stainless steel or a non-abrasive cleaner. -
Page 10: Maintenance Instructions
Maintenance Instructions We recommend this gas grill be thoroughly inspected and serviced annually by a qualified service person. WARNING! Always wear protective gloves and safety glasses when cleaning your grill. WARNING! Turn off the gas at the source and disconnect the unit before servicing. To avoid the pos- sibility of burns, maintenance should be done only when the grill is cool. -
Page 11: Troubleshooting
WARNING! Hose: Check for abrasions, melting, cuts, and cracks in the hose. If any of these conditions exist, do not use the gas grill. Have the part replaced by your Napoleon Gas Grill dealer or qualified gas installer. Aluminum Castings: Clean castings periodically with warm soapy water. Aluminum will not rust, but high temperatures and weathering can cause oxidation to occur on aluminum surfaces. - Page 12 Cracked ceramic tile. Allow burner to cool and inspect very closely for cracks. If any cracks are found, contact your authorized Napoleon dealer to order a replacement burner assembly. Leaking gasket surrounding the ceramic Contact your authorized Napoleon dealer for...
- Page 13 CAUTION! During unpacking and assembly we recommended you wear work gloves and safety glasses for your protection. Although we make every effort to make the assembly process as problem free and safe as possible, it is characteristic of fabricated steel parts that the edges and corners might be sharp and could cause cuts if handled incorrectly.
- Page 14 2 X N570-0026 (#14 x 1/2”) 3/8”(10mm) If necessary the center panel can be tapped down with a rubber mallet. Si nécessaire, le panneau central peut être enfoncé avec un maillet en caoutchouc. 4 X N570-0026 (#14 X1/2”) 3/8”(10mm) www.napoleongrills.com...
- Page 15 2 x N570-0026 (#14 x 1/2”) 3/8”(10mm) If necessary the cross beam can be tapped down with a rubber mallet. Si nécessaire, le barre de traverse peut être enfoncé avec un maillet en caoutchouc. 308 Only 308 Seulement 4 x N570-0026 (#14 x 1/2”) 3/8”(10mm) 2 x N485-0012 2 x N485-0011...
- Page 16 450 Only 450 Seulement 4 x N570-0026 (#14 x 1/2”) 3/8”(10mm) Propane Only Propane Seulement 1 x N485-0009 If necessary the Insert push magnet bracket pin here can be tapped down with a Insérez la rubber mallet. goupille- poussoir ici. Si nécessaire, le support à...
- Page 17 4 x N570-0026 (#14 x 1/2”) 3/8”(10mm) Two people are required for this step. Deux personnnes son nécessaires pour cette étappe. www.napoleongrills.com...
- Page 18 2 x N570-0026 (#14 x 1/2”) 3/8”(10mm) Propane Only Propane Seulement www.napoleongrills.com...
- Page 19 1 x N570-0026 (#14 x 1/2”) 3/8”(10mm) 4 x N570-0029 (1/4-20 X 3/8”) 3/8”(10mm) 4 x N735-0002 (1/4”) www.napoleongrills.com...
- Page 20 10 x N570-0076 (#8 X1/2”) 3/8”(10mm) 4 x N570-0026 (#14 X1/2”) Twist tab to lock in place. Tournez la patte pour verrouiller. www.napoleongrills.com...
- Page 21 450 Series N305-0021 N305-0022 308 Series N305-0055 N305-0056 Ensure holes in sear plates are postitoned to the front of the grill. Assurez-vous que les trous dans les plaques de brûleur soient placés à l’avant du gril. 450 Series 308 Series www.napoleongrills.com...
- Page 22 Rotisserie Kit Assembly Instruction (included with most rear burner units) Assemble rotisserie kit components as shown. Instructions D’assemblage De L’ensemble De Rôtissoire (inclus avec la plupart des appareils avec brûleur arrière) Assemblez les composantes de la rôtissoire tel qu’illustré. Ensure stop bushing is tightened on the inside of hood casting.
- Page 23 Propane Only – Proper Hose Connection Propane Seulement - Branchement Adéquat Du Boyau WARNING! Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. AVERTISSEMENT! Assurez-vous que le boyau ne touche à aucune surface à haute température sinon il risque de fondre, de provoquer une fuite et causer un feu.
- Page 24 WARNING – FIRE HAZARD ATTENTION - RISQUE D’INCENDIE WARNING! Do not route hose underneath drip pan. AVERTISSEMENT! Ne pas passer le tuyau d’alimentation sous le tiroir d’égouttement afin de garder. WARNING! Hose must be routed through right side panel only. Do not route hose through left side panel and underneath drip pan.
- Page 25 Bubbles will indicate a gas leak. Either tighten the loose joint or have the part replaced with one recommended by the Napoleon Customer Care department and have the grill inspected by a certified gas installer. If the leak cannot be stopped, immediately shut off the gas supply, disconnect it, and have the grill inspected by a certified gas installer or dealer.
- Page 26 Description n135-0018g n135-0020g left side lid casting / moulage gauche du couvercle n385-0129 n385-0129 NAPOLEON logo/ logo NAPOLEON w450-0005 w450-0005 logo spring clips / écrous à ressort pour logo n510-0002 n510-0002 black silicone lid bumper / pare-chocs du couvercle (silicone noir)
- Page 27 Parts List / Liste Des Pièces Item 308 Part # 450 Part # Description n570-0026 n570-0026 #14 x 1/2” screw / vis #14 x 1/2” n510-0006 n510-0006 caster plug - each / prise de roulette (unité) n475-0133g n475-0129g rear cart enclosure panel / panneau arriére pour chariot n590-0108g n590-0155g bottom shelf / tablettes inférieur...
- Page 28 www.napoleongrills.com...
Need help?
Do you have a question about the PT308RB and is the answer not in the manual?
Questions and answers