Table of Contents
Advertisement
Quick Links
This gas grill must be used only outdoors in a well-ventilated space and must not be used inside a
building, garage, screened-in porch, gazebo or any other enclosed area.
DANGER
IF YOU SMELL GAS:
• Shut off gas to the appliance.
• Extinguish any open flame.
• Open lid.
• If odor continues, keep away from the
appliance and immediately call your gas
supplier or fire department.
Notice to Installer: Leave these instructions with the grill owner for future reference.
Fax: (705)725-2564 email: wecare@napoleonproducts.com web site: www.napoleongrills.com
Napoleon Appliance Corp.,
214 Bayview Dr., Barrie, Ontario, Canada L4N 4Y8 Phone: (705)726-4278
Serial No.
XXXXXX000000
MODEL NO.
PRESTIGE II 450
INFRARED
WARNING
Do not try to light this appliance without
reading the "LIGHTING" instructions section of
this manual.
Do not store or use gasoline or other flammable
liquids or vapors in the vicinity of this or any
other appliance. An L.P. cylinder not connected
for use must not be stored in the vicinity of
this or any other appliance. If the information
in these instructions is not followed exactly, a
fire or explosion may result, causing property
damage, personal injury or death.
APPLY SERIAL NUMBER LABEL FROM CARTON
N415-0201 APR 21/11
Advertisement
Table of Contents
Related Manuals for Napoleon N415-0201
Summary of Contents for Napoleon N415-0201
- Page 1 This gas grill must be used only outdoors in a well-ventilated space and must not be used inside a building, garage, screened-in porch, gazebo or any other enclosed area. DANGER IF YOU SMELL GAS: • Shut off gas to the appliance.
-
Page 2: Conditions And Limitations
This warranty defines the obligation and liability of NAPOLEON with respect to the NAPOLEON gas grill and any other warranties expressed or implied with respect to this product, its components or accessories are excluded. -
Page 3: Safe Operating Practices
Maintain proper clearance to combustibles (18” (457mm) to rear of unit, 7” (178mm) to sides). Additional clearance of (24” (610mm) is recommended near vinyl siding or panes of glass. • Gas must be turned off at the propane cylinder or at the natural gas supply valve when the gas grill is not in use. •... -
Page 4: General Information
The regulator supplies a pressure of 11 inches. water column to the gas grill and has a QCC1 type fitting. Cylinders to be used with this unit must be supplied with a QCC1 cylinder valve. A QCC1 cylinder has a positive seating connection, which will not allow gas flow until a positive seal has been achieved. -
Page 5: Leak Testing Instructions
(complete with a quick disconnect) designed for natural gas and certified for outdoor use. The gas grill is designed to operate at an inlet pressure of 7 inches water column. Piping and valves upstream of the quick disconnect are not supplied. The installation must comply with CAN B149.1 Natural Gas and Propane installation code in Canada, or to the National Fuel Gas Code, ANSI Z223.1 in the United States. -
Page 6: Lighting Instructions
Lighting Instructions Lighting Hole WARNING! Open lid WARNING! Ensure all burner controls are in the off position. Slowly turn on the gas supply valve. Main Tube Burner Lighting 1. Open grill lid 2. Turn left burner control to high position. 3. -
Page 7: Cooking Instructions
Cooking Instructions Initial Lighting: When lit for the first time, the gas grill emits a slight odor. This is a normal temporary condition caused by the “burn-in” of internal paints and lubricants used in the manufacturing process and does not occur again. - Page 8 Infrared Heat Most people don’t realize that the heat source we are most familiar with, our sun, warms the earth using mainly infrared energy. This is a form of electro-magnetic energy with a wavelength just greater than the red end of the visible light spectrum but less than a radio wave.
-
Page 9: Cleaning Instructions
Do not use oven cleaner to clean any part of this gas grill. Do not use a self-cleaning oven to clean cooking grids or any other parts of the gas grill. Barbecue sauce and salt can be corrosive and will cause rapid deterioration of the gas grill components unless cleaned regularly. -
Page 10: Maintenance Instructions
(flashback) at the air shutter underneath the control panel. To clean the inside of the burner, it must be removed from the gas grill: Remove the screw (s) that attaches the burner to the back wall. - Page 11 WARNING! Hose: Check for abrasions, melting, cuts, and cracks in the hose. If any of these conditions exist, do not use the gas grill. Have the part replaced by your Napoleon Gas Grill dealer or qualified gas installer. Aluminum Castings: Clean castings periodically with warm soapy water. Aluminum will not rust, but high temperatures and weathering can cause oxidation to occur on aluminum surfaces.
-
Page 12: Troubleshooting
Normal occurrence on hot days. Solution Ensure lighting procedure is followed carefully. All gas grill valves must be in the off position when the tank valve is turned on. Turn tank on slowly to allow pressure to equalize. See lighting instructions. - Page 13 Clean burner orifice. Clean out venturi tube. Ensure lighting procedure is followed carefully. All gas grill valves must be in the off position when the tank valve is turned on. Turn tank on slowly to allow pressure to equalize. See lighting instructions.
-
Page 14: Ordering Replacement Parts
KEEP YOUR RECEIPT AS PROOF OF PURCHASE TO VALIDATE YOUR WARRANTY. Ordering Replacement Parts Warranty Information MODEL: DATE OF PURCHASE: SERIAL NUMBER: (Record information here for easy reference) Before contacting the Customer Care Department, check the NAC Website for more extensive cleaning, maintenance, troubleshooting and parts replacement instructions at www.napoleongrills.com. -
Page 15: Getting Started
CAUTION! During unpacking and assembly we recommended you wear work gloves and safety glasses for your protection. Although we make every effort to make the assembly process as problem free and safe as possible, it is characteristic of fabricated steel parts that the edges and corners might be sharp and could cause cuts if handled incorrectly. - Page 16 2 X N570-0086 (#14 x 1/2”) If necessary the center panel can be tapped down with a rubber mallet. Si nécessaire, le panneau central peut être enfoncé avec un maillet en caoutchouc. 4 X N570-0086 (#14 X1/2”) www.napoleongrills.com 3/8”(10mm) 3/8”(10mm)
- Page 17 2 x N570-0086 (#14 x 1/2”) If necessary the cross beam can be tapped down with a rubber mallet. Si nécessaire, le barre de traverse peut être enfoncé avec un maillet en caoutchouc. 4 x N570-0086 (#14 x 1/2”) 3/8”(10mm) 3/8”(10mm) Propane Only Propane Seulement...
- Page 18 1 x N485-0009 If necessary the magnet bracket can be tapped down with a rubber mallet. Si nécessaire, le support à aiment peut être enfoncé avec un maillet en caoutchouc. www.napoleongrills.com Insert push pin here Insérez la goupille- poussoir ici.
- Page 19 4 x N570-0086 (#14 x 1/2”) Two people are required for this step. Deux personnnes son nécessaires pour cette étappe. 2 x N570-0086 (#14 x 1/2”) 3/8”(10mm) 3/8”(10mm) Propane Only Propane Seulement www.napoleongrills.com...
- Page 20 disposable grease tray jetable du récipient à graisse 1 x N570-0086 (#14 x 1/2”) 3/8”(10mm) www.napoleongrills.com...
- Page 21 2 x N570-0029 (1/4-20 X 3/8”) 3/8”(10mm) 2 x N735-0002 (1/4”) www.napoleongrills.com...
- Page 22 10 x N570-0076 (#8 X1/2”) 4 x N570-0086 (#14 X1/2”) www.napoleongrills.com Twist tab to lock in place. Tournez la patte pour verrouiller. 3/8”(10mm)
- Page 23 Ensure holes in sear plates are positioned to the front of the grill. Assurez-vous que les trous dans les plaques de brûleur soient placés à l’avant du gril. N305-0021 N305-0022 www.napoleongrills.com...
- Page 24 Rotisserie Kit Assembly Instruction (included with most rear burner units) Assemble rotisserie kit components as shown. Instructions D’assemblage De L’ensemble De Rôtissoire (inclus avec la plupart des appareils avec brûleur arrière) Assemblez les composantes de la rôtissoire tel qu’illustré. www.napoleongrills.com Ensure stop bushing is tightened on the inside of hood casting.
- Page 25 Propane Only – Proper Hose Connection Propane Seulement - Branchement Adéquat Du Boyau WARNING! Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. AVERTISSEMENT! Assurez-vous que le boyau ne touche à aucune surface à haute température sinon il risque de fondre, de provoquer une fuite et causer un feu.
- Page 26 WARNING – FIRE HAZARD ATTENTION - RISQUE D’INCENDIE WARNING! Do not route hose underneath drip pan. AVERTISSEMENT! sous le tiroir d’égouttement afin de garder. WARNING! Do not route hose over top of rear panel. AVERTISSEMENT! panneau arrière. WARNING! Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire.
- Page 27 Leak Testing Instructions WARNING! A leak test must be performed annually and each time a cylinder is hooked up or if a part of the gas system is replaced. WARNING! Never use an open flame to check for gas leaks. Be certain no sparks or open flames are in the area while you check for leaks.
- Page 28 Parts List / Liste Des Pièces Item Part # Description n135-0040g left side lid casting / moulage gauche du couvercle n385-0129 NAPOLEON logo/ logo NAPOLEON w450-0005 logo spring clips / écrous à ressort pour logo n510-0002 black silicone lid bumper / pare-chocs du couvercle (silicone noir) n335-0059 stainless steel lid insert / couvercle en acier inoxydable n585-0071...
- Page 29 Parts List / Liste Des Pièces Item Part # Description n010-0219l manifold assembly / ensemble du collecteur n380-0015 burner control knob / bouton de contrôle n380-0015r burner control knob red / bouton de contrôle rouge n357-0015 electronic ignition / allumeur électronique n475-0222g left/right cart enclosure panel / panneau pour chariot gauche/droite n570-0086...
- Page 30 www.napoleongrills.com...
- Page 31 FAX TO: 705 727 4282 ACCESSORIES & PARTS ORDER FORM PLEASE PRINT CLEARLY CONTACT NAME:______________________________________________________________________ SHIP TO :_____________________________________________________________________________ _________________________________________________________________________________________ _________________________________________________________________________________________ _________________________________________________________________________________________ TEL :_________________________________ FAX :______________________________ EMAIL: __________________________________________________________________ VISA OR MASTERCARD # :_______________________________________ EXPIRY DATE: _____________ SIGNATURE:_____________________________________________________________________________ QUANTITY PART NUMBER DESCRIPTION TAXES MAY APPLY SHIPPING EXTRA IF CONFIRMATION IS REQUIRED PLEASE INCLUDE A FAX NUMBER OR EMAIL ADDRESS...
- Page 32 Notes www.napoleongrills.com...