Weber SUMMIT 425 LP Operating Manual
Lp gas barbecues
Hide thumbs
Also See for SUMMIT 425 LP:
- Operating manual (16 pages) ,
- Operating manual (20 pages) ,
- Step-by-step manual (17 pages)
Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Weber SUMMIT 425 LP
Summary of Contents for Weber SUMMIT 425 LP
- Page 1 This Owner's Manual is provided and hosted by Appliance Factory Parts. Weber SUMMIT 425 97 LP CART (PRIOR 2000) Owner's Manual Shop genuine replacement parts for Weber SUMMIT 425 97 LP CART (PRIOR 2000) Find Your Weber Grill Parts - Select From 2037 Models -------- Manual continues below --------...
- Page 2 LP Gas Barbecues Operating Guide Read before assembly Summit 450 LP Summit 425 LP Serial Number Serial Number FOR YOUR SAFETY WARNING: F o l l ow all leak ch e ck pro c e d u r e s 1.
-
Page 3: Warnings
LP unit or LP gas in a natural Do not operate the Weber Gas Barbecue if there is a gas unit is dangerous and will void your warranty. gas leak present. -
Page 4: Table Of Contents
*REFER TO YOUR STEP-BY-STEP SECTION AT Crossover Ignition System Operations THIS TIME Troubleshooting Lighting Exploded Views and Replacement Crossover Ignition System Parts Lists 16-19 To Extinguish Summit 425 LP 16-17 Manual Lighting Summit 450 LP 18-19 To Extinguish Patents and Trademarks Cooking Storage Cleaning... -
Page 5: Warranty
Weber does not authorize any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return, or replacement of its equipment; and no such representations are binding on We b e r. -
Page 6: Standards And Codes Information
Keep the cooking area clear of flammable vapors and liquids, such as gasoline, alcohol, etc., and The Weber Gas Barbecue is portable so you can easily combustible materials. change its location in your yard or on your patio. -
Page 7: Lighting
LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTLY. 1) Open the lid. Figure 1. Summary lighting instructions are on the control panel. 2) Check that the fuel scale reads more than “E”. Note - E = empty; F = full. 3) Make sure all burner control knobs are OFF. (Push each burner control knob down and turn clockwise.) WARNING: The b urner control knobs must be in the High... -
Page 8: Manual Lighting
MANUAL LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTL Y. DANGER When the excess flow control is activated, a small amount of gas is still flowing to the burners. After turning OFF the tank and burner control knobs,wait at least 5 minutes for the gas High Medium to clear before attempting to light the barbecue. -
Page 9: Cooking
COOKING CLEANING The Weber Gas Barbecue should not be moved when CAUTION: Turn your Weber Gas Barbecue OFF and operating or hot. wait for it to cool before cleaning. CAUTION: Do not clean your Flavorizer Bars or cooking grills in a self-cleaning oven. Replacement... -
Page 10: Steam-N-Chips Smoker
As a starting point, place a handful of FireSpice Chips or a S m o ke r. To a lesser degree a "smoke" residue will a c c u mulate on the inside of your Weber Gas Barbecue. few FireSpice Chunks in the bottom of the smoker body. -
Page 11: Maintenance
Spider Stopper Guards with a soft bristle brush (an old toothbrush for example). Check that there are no gaps in the Spider Stopper Guards’ seams or in the fit around the burners or valves. Weber Spider Stopper Guard Figure 6... -
Page 12: Main Burner Flame Pattern
Main Burner Flame Pa t t e r n Replacing Main Burners 1. Your Weber Gas Barbecue must be OFF and cool. The Weber Gas Barbecue burners have been factory set for the correct air and gas mixture. The correct flame 2. - Page 13 MAINTENANCE 9. Unlatch the Spider Stopper Guards and remove. 11. Slide the burner assembly from each Heat Zone. The Figure 12. left and right burners are connected by the Crossover tube. Figure 14 (a). Pull out of here Crossover tube Figure 12 10.
-
Page 14: Crossover Ignition System Operations
Check to see if the igniter is loose in the frame. Orifice Tighten if necessary; See Step “Install igniter” for correct procedure. If the Crossover Ignition System still fails to light, contact Weber-Stephen Customer Service. White wire Black wire Figure 16 Figure 18... -
Page 15: Troubleshooting
Fuel scale shows that there is gas in the Check adjustment of fuel scale. Fuel scale must be adjusted with LP tank, but tank is empty. an empty tank. If problems cannot be corrected by using these methods, please contact Weber-Stephen Customer Service. -
Page 17: Summit 425 Lp
EXPLODED VIEW FOR THE SUMMIT 425 LP... - Page 18 While we give much attention to our products, Manifold assembly unfortunately an occasional error may occur. If a part is Manifold mounting clips (2) missing, do not go back to the store. Call the Weber Control panel Customer Service Center toll free 1-888-33-SUMMIT Igniter button (2) (1-888-337-8664) to receive immediate assistance.
-
Page 19: Summit 450 Lp
EXPLODED VIEW FOR THE SUMMIT 450 LP... - Page 20 Gas catcher ignition chamber (2) unfortunately an occasional error may occur. If a part is Spider stopper guard (4) missing, do not go back to the store. Call the Weber Manifold assembly Customer Service Center toll free 1-888-33-SUMMIT Manifold mounting clips (2) (1-888-337-8664) to receive immediate assistance.
-
Page 21: Patents And Trademarks
Flavorizer and Crossover are registered U.S. trademarks; Summit, Grill Cozy, Gas Catcher, Spider Stopper, and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Summit Series Gas Barbecues are covered by U.S. Patent Nos. 4,677,964; 4,727,853; 4,777,927;...
Need help?
Do you have a question about the SUMMIT 425 LP and is the answer not in the manual?
Questions and answers