Tennant T560 Manual
Tennant T560 Manual

Tennant T560 Manual

Small ride-on scrubber

Advertisement

T560 Small Ride-on Scrubber

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the T560 and is the answer not in the manual?

Questions and answers

Summary of Contents for Tennant T560

  • Page 1 T560 Small Ride-on Scrubber...
  • Page 2: Table Of Contents

    ………… Freeze Protection …………………… During machine operation ………… Specifications Floor scrubbing method General Machine Size/Capacity ………………… …………………………… Solution tank water level transparent tube Type … …………………………… Recovery tank sewage sensor Tires ………… Battery consumption indicator light Machine Dimensions Tennant T560...
  • Page 3 Tennant Company PO Box 1452 Minneapolis, MN 55440 Phone:(800)553-8033 www.tennantco.com Tennant Cleaning System Equipment (Shanghai) Co., Ltd Address: Lane 928, Shenhong Road, Minhang District, Shanghai Room 608, Building 5, Jiahui, Hongqiao Tel: (8621) 6700 8000 Fax: (8621) 6700 8006 Specifications and components are subject to change without prior notice.
  • Page 4 - Use gaskets or accessories not provided or Warning approved by Tennant. The use of other mats may affect safety. To reduce the risk of fire, explosion, electric - Outdoor area. This machine can only be used shock or injury: indoors.
  • Page 5 - Empty the water tank before loading the - Contact Tennant's authorized local and machine. regulatory lithium battery transportation and - Using slopes, trucks, or trailers that can storage organization.
  • Page 6: Operation

    9. Water valve handle 10. Waterproof rubber strip 11. Guiding wheel 12. Sewage pipe 13. Solution tank cover 14. Brush plate 15. Big casters 16. Squeegee guide wheel 17. Squeegee castor 18. Squeegee components 19. uction pipe 20. Hanger Tennant T560...
  • Page 7: Control Box Instrument

    There are two available plate brushes with a brush head width of 350mm (13 inches). Note: The number and type of dirt particles will Tennant T560...
  • Page 8: Scrubbing Method

    350mm scrubbing brush+NP-500 buckle Install brush plate/needle hold- FBP180002. er/scouring pad If you want to install a brush plate or scouring pad, please refer to the section "Replacing the Brush plate, Needle holder, and Scouring pad" in this manual. Tennant T560...
  • Page 9: Inject Clean Water Into The ........................ Solution Tank

    Attention: If using traditional floor scrubbing methods, please always use the recommended cleaning agent. If the machine is damaged due to improper use of cleaning agents, the manufacturer shall not be liable for warranty. Tennant T560...
  • Page 10: Scrubbing The Floor

    When scrubbing the floor, do not operate the machine on a slope with a gradient exceeding 7% (4 °). For safety reasons: When using the machine, move slowly on slopes and smooth surfaces. Tennant T560...
  • Page 11: During Machine Operation

    Do not operate the machine in areas with ambient temperatures exceeding 43 ℃ (110 ° F) Make a machine. Do not turn on the floor scrubbing function in areas with an ambient The battery meter displays the battery level. Tennant T560...
  • Page 12: Battery Consumption Indicator Light

    3. Remove the drain pipe from the recovery tank. When holding the drain pipe upwards, please open the upper cover and slowly place the drain pipe in the floor drain or sink. Tennant T560...
  • Page 13 Warning: Flammable substances may cause explosions or fires. Do not use flammable substances in the tank. Do not use steam to clean the water tank, as high heat can damage the water tank and components. Tennant T560...
  • Page 14 Wipe the bottom of the cover, first install the sealing ring of the solution tank, and then reinstall the cover. 14. After the solution tank is drained, install the upper cover of the clean water injection port and replace the sewage pipe in its original position. Tennant T560...
  • Page 15: Machine Troubleshooting

    Adding water to the solution tank Poor floor scrubbing Debris on the needle holder or cleaning pad Remove garbage effect Worn washing brush Replacing the brush Charge the battery until the Low battery power charger is turned off Tennant T560...
  • Page 16 Tennant T560...
  • Page 17: Maintenance

    500 hours of operation) 500 hours Check the motor brush (check every 100 hours after the first DRIVE-MOTOR 500 hours of operation) Big casters Check for damage and wear Note: more frequent maintenance may be required under extreme dusty conditions. Tennant T560...
  • Page 18: Battery Charging

    2.Please turn off the machine key switch. For safety reasons: when leaving or repairing the machine, stop the machine on a level surface, turn off the machine and pull out the key. Tennant T560...
  • Page 19: Squeegee Rubber Strip

    After pressing the front and rear blade into the corresponding clamping holes, tighten the yellow hand tightened nuts at both ends. As shown in Figure below. Unscrew the fixing nut counterclockwise Tennant T560...
  • Page 20: Adjusting The Squeegee Rubber

    13MM (6 threads are exposed by visual inspection of the nut);The cement floor is: 12MM (with 5 threads exposed by visual inspection of the nut), Tennant T560...
  • Page 21: Pushing, Dragging, And ............ Transporting Machines

    5.Bind the rack of the machine with ropes and then tie it to the trailer or truck to prevent the machine from tilting. For safety reasons: when transporting the machine, use ropes to fix the machine on the vehicle plate. Tennant T560...
  • Page 22: Storing Machines

    Remarks 1. Load short circuit Several situations 2. Wire connection reversed when LED2 lights up with a red light 3. Short circuit in battery line 4. Over temperature - LED2 lights up with an orange light Tennant T560...
  • Page 23: Specifications

    Battery (standard) 176Ah 10hr 46Kg x 2 Type Brush Plate Motor 0.4x2 Vacuum motor 0.55 Electric motor Driving motor Type Ampere Charger (intelligent) Tires Position Type Size Front wheel (1) Solid 250mm(0D) ×80mm wide Rear-wheel Solid 270mm(0D) ×80mm wide Tennant T560...
  • Page 24: Machine Dimensions

    800MM 1200MM 1310MM 1049mm/973mm Tennant T560...
  • Page 25 Product Warranty Card(Main Card) (The product warranty card is the main evidence for warranty service, Keep Properly Warranty: Within the warranty period, if any fault condition happens by normal use under the instruction of operation manual, it will be repaired for free. Please take the warranty card and purchasing invoice for free repair.
  • Page 26 Product Warranty Card(Vice Card) 1.Product information: Product Model and Name: _______________________________________ Serial No: ____________________________________________________ 2. User Information: ____________________________________________ Final User Company: ___________________ Tel: _________________ Address: ________________________ Fax: ____________________ E-mail: ________________________ Post Code:___________________ 3. Sales Company Information: ___________________________________ Address: _____________________________________________________ Contact: ___________________________ Tel: __________________ Post Code: __________________ Sales Date: _____________________...

Table of Contents