GL Sciences 600SP Instruction Manual

★ READ THIS INSTRUCTION MANUAL AND THE INSTRUCTIONS OF THE COMPRESSED BREATHING
AIR SAMPLING SYSTEM (P-41R) PRIOR TO USING THIS PRODUCT.
★ DO NOT DISCARD THIS INSTRUCTION MANUAL UNTIL ALL THE TUBES IN THIS BOX ARE
USED UP.
1. PERFORMANCE:
Substance to
be measured
Tube No.
Measuring 2.5 - 5ppm 5 - 100ppm
Range
Sampling 4 minutes
Time
Flow Rate
(L/min.)
Detectable
Limit
2nd Pressure
Operating
Temperature
Colour Change Yellow
1. THE DETECTOR TUBE CONTAINS CHEMICAL REAGENTS.
2. DO NOT TOUCH THESE REAGENTS DIRECTLY ONCE TUBES WERE BROKEN.
3. KEEP THE TUBES OUT OF THE REACH OF CHILDREN.
NOTICE
1. USE ONLY WITH THE COMPRESSED BREATHING AIR SAMPLING SYSTEM (P-41R).
OTHERWISE, CONSIDERABLE ERROR IN INDICATION MAY OCCUR.
2. DO NOT USE THIS TUBE OUTSIDE THE STATED OPERATING TEMPERATURE RANGE.
3. STORE TUBES IN A COOL AND DARK PLACE ( 0-25 ℃/32-77°F), AND USE BEFORE
EXPIRATION DATE PRINTED ON THE TOP OF THE BOX.
4. PRIOR TO USE, READ CAREFULLY ITEM 6. USER RESPONSIBILITY.
5. READ THE CONCENTRATION IMMEDIATELY AFTER MEASUREMENT.
6. UPON USE OF NO. 602SP OIL MIST TUBES, ORANGE COLOUR STAIN WILL BE PRODUCED BY
WATER VAPOUR IN THE SAMPLE GAS BUT DISCOLOURATION BY OIL MIST IS NOT
INTERFERED. THE TOP OF PALE BLUE DISCOLOURATION SHALL BE READ IRRESPECTIVE
OF THE ORANGE COLOUR STAIN.
7. UPON USE OF NO. 603SPA AND 603SP2 WATER VAPOUR TUBES, MEASURE THE
CONCENTRATOIN IMMEDIATELY AFTER BREAK BOTH ENDS OF THE DETECTOR TUBE TO
AVOID THE COLOUR CHANGING BY WATER VAPOUR IN AIR.
8. THE COLOUR STAIN OF NO. 603SPA WATER VAPOUR TUBE IS YELLOWISH GREEN AT LESS
THAN APPROX. 60mg/m
2. SAMPLING AND MEASUREMENT:
COMPRESSED BREATHING AIR TEST TUBES
Carbon
monoxide
600SP
2 minutes
2
1ppm
(4 minutes sampling)
2
0.6Kgf/cm
(0.059MPa)
0 - 40 ℃ (32-104°F) (No correction is necessary.)
→ Dark brown
3
OF WATER VAPOUR, AND BLUE OVER 60mg/m
① Part to connect gas cylinder
② 2nd pressure gauge
③ Handle of pressure regulator
④ Flow meter
⑤ Needle valve
⑥ Open/Shutoff valve
⑦ Inlet to gas detector tube
⑧ Gas detector tube
⑨ Tube protector
Fig.1
INSTRUCTION MANUAL
Carbon Oil mist
dioxide
601SP 602SP
100 - 3000ppm 0.3 - 5mg/m
2 minutes 25 minutes
1
20ppm 0.1mg/m
2
1.0Kgf/cm 1.0Kgf/cm
(0.098MPa) (0.098MPa)
Purplish blue Yellow
→ Pale pink → Pale blue
CAUTION
No.600SP, 601SP, 602SP, 603SPA, 603SP2
Water vapour
603SPA
3
20 - 160mg/m
1 minute
3 2
3
15mg/m
2
1.0Kgf/cm
(0.098MPa)
Yellow
→ Yellowish
green or Blue
3
603SP2
3
100 - 1000ppm
20 seconds
3
3
30ppm
2 2
1.0Kgf/cm
(0.098MPa)
Yellow
→ Greenish
blue
OF WATERVAPOUR.