PIONEER Service Manual. A subscription to, or additional copies of, Also test with plug reversed Earth PIONEER Service Manual may be obtained at a nominal (Using AC adapter ground charge from PIONEER. plug as required)
1.2 NOTES ON REPLACING ............................... 5 1.3 CAUTION..................................5 1.4 NOTES ON ASSEMBLING............................. 6 2. SPECIFICATIONS................................. 7 2.1 SC-65 SPECIFICATIONS ............................... 7 2.2 SC-1527-K/SC-1522-K SPECIFICATIONS........................9 3. BASIC ITEMS FOR SERVICE ............................11 3.1 CHECK POINTS AFTER SERVICING ......................... 11 3.2 PCB LOCATIONS .................................
Page 4
11.21 FAN CONNECT_S ASSY and MIC HP GUARD ASSY ..................248 11.22 BIND DM CABLE ASSY and P WIRE GUARD ASSY ....................252 11.23 FFC GUARD, BIND FAN CABLE, VREG GUARD, TRANS VREG STYL and IR EDGE GUARD ASSYS....254 12. PCB PARTS LIST ................................256 SC-65...
AWX1210 ------------------- Land is under parts Q4601,4602 ASSY Q4701,4702 Q4801,4802 Q4901,4902 1.3 CAUTION • Discharging Before starting the diagnosis, wait for three minutes until the electricity of the unit is discharged. • Ground Points Please refer to “Ground Points”. SC-65...
Accessory of Panel Base D-AMP_S ASSY Rear Panel • Front View If a screw at any of these points needs to be removed for service, be sure to check that the swarf is not on the screw before refastening. SC-65...
2. SPECIFICATIONS 2.1 SC-65 SPECIFICATIONS Amplifier section Continuous average power output* 8 Ω ..........................130 W** per channel 6 Ω ..........................170 W*** per channel * Measured pursuant to the Federal Trade Commission’s Trade Regulation rule on Power Output Claims for Amplifiers ** 1 kHz with no more than 0.08 %**** total harmonic distortion...
Page 8
Safety Brochure Warranty sheet Note Specifications and the design are subject to possible modifications without notice, due to improvements. This product includes FontAvenue ® fonts licensed by NEC Corporation. FontAvenue is a registered trademark of NEC Corporation. SC-65...
Frequency Range (AM)......................530kHz to 1700 kHz Antenna (AM)......................... Loop antenna (balanced) Video Section Signal level Composite Video ........................1 Vp-p (75 Ω) Component Video ................ Y:1.0 Vp-p (75 Ω), PB/PR: 0.7 Vp-p (75 Ω) Corresponding maximum resolution Component Video ..................1080p(1125p) (Video convert off) SC-65...
Page 10
The AirPlay logo is a trademark of Apple Inc. Windows and the Windows logo are trademarks of the Microsoft group of companies. MHL, the MHL Logo, and Mobile High-Definition Link are trademarks or registered trademarks of MHL LLC in the United States and other countries. SC-65...
Disturbed image (video jumpiness) Volume too high Too dark Volume fluctuating Mottled color Cleaning Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools. Name Cleaning paper Refer to “9.4 CHASSIS SECTION”. SC-65...
30P + 28P board to board extension jig cable GGD1806 Diagnosis for DAC HIGH ASSY 28P + 14P board to board extension jig cable GGD1763 [2] Lubricants and Glues List Name Lubricants and Glues No. Remarks Silicone Grease ZLB-PN397B Refer to “9.5 FRONT SECTION” SC-65...
Page 17
(T2A H/250V) (T5A L/250V) (T1A L/250V) (T800mA L/250V) (T1A L/250V) (T800mA L/250V) POWER SW ASSY (SC-65 : AWX1135) CN7400 (SC-1527-K/ SC-1522-K : AWX1151) 1.S1-1 CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, 2.S1-C 3.S1-2 REPLACE WITH SAME TYPE AND RATINGS OF FUSE.
Page 31
Check the circuits arround RY71 when press power key? or replace PRIMARY ASSY Check DVCPOW signal path Check DIGITAL MAIN ASSY DISPLAYA-REG CN601 13 pin (DVCPOW) DIGITAL MAIN ASSY LH when press power key? Diagnose or replace DIGITAL MAIN ASSY SC-65...
Page 33
SP system setting.) Zone3 Audio no output Digital inoutput Refer to speaker (front is OK) flow. Analog inoutput from Zone 3 line from Zone 3 line out? (MAIN is OK) Which channels correspond to zone, refer to instruction manual. SC-65...
Page 34
DIGITAL MAIN ASSY Diagnose FRONT HDMI USB ASSY (arround IC8003) or replace FRONT HDMI USB ASSY or HDMI Cable from FRONT HDMI USB Assy Diagnose DIGITAL MAIN ASSY MEDIA SERVER in (arround IC9204,IC9203) (Other Digital OK) or replace DIGITAL MAIN ASSY SC-65...
Page 35
"Pure Direct", Replace IC2501 Check the analog signal path Other results Dignose and repair NG point e.g. if selecting "CD", check INL11 58 pin / INR11 57 pin, outputs is FROUT 8 pin / FLOUT 7 pin SC-65...
Page 36
Continue the following flow or replace DAC HIGH ASSY Diagnose NG part of DAC HIGH ASSY DA part (MAIN) around IC2011-2014,2017 DA part (zone 2) arround IC2471 AD part arround IC2431 DIR part arround IC2001 SC-65...
Page 37
(arround IC8301) Component out or or replace COMPONENT ASSY zone 2 Component out? Diagnose or replace HDMI inHDMI out? DIGITAL MAIN ASSY Composite Diagnose or replace (Component) in DIGITAL MAIN ASSY HDMI out? Diagnose or replace GUI? DIGITAL MAIN ASSY SC-65...
Page 38
Diagnose INTERFACE ASSY Remote Control (IR,SR circuits) or replace INTERFACE ASSY Check the signal path of Repair or replace IR-IN,SR-IN,RMC INTERFACECONNECT NG point DIGITAL MAINV-REG DISPLAY ASSY No problem Diagnose DISPLAY ASSY (IR,SR,RMC signal path, arround U3201) or replace DISPLAY ASSY SC-65...
BERR port becomes "L". Refer to “How to Enter MCACC LED failure (IC3001 84pin) Release Mode” . detection [How to Enter Release Mode] During Standby mode, simultaneously press and hold the "TUNE [] " and "MULTI-ZONE ON/OFF" keys for 5 seconds. SC-65...
Page 44
4.1V or lower Power ON detection and XVDDERR port is set to "L" XVDDERR Circuit FRONT HDMI USB ASSY V+5_USB_DC DISPLAY ASSY V+5EV CN8002 CN3004 UCOM IC3001 Q8004 2SC4154-11(EF) GNDU GNDCH SC-65...
Page 45
XMHLPERR port is MHL equipment is set to "L". acknowledged after second power-on. XMHLPERR Circuit FRONT HDIM USB ASSY V+5_MHL CN8002 XMHLPERR V+5_USB_DC DIGITAL MAIN ASSY DISPLAY ASSY V+3R3_E CN3004 CN3001 CN601 IC101 R3161 R742 R263 GNDD SC-65...
[ ↑ ] [↓] Display number of times D E R R Digital Power abnormality is detected. [ ↑ ] [↓] Display number of times B REG power supply B E R R failure is detected. [ ↑ ] [↓] SC-65...
Page 49
1 kHz square wave. If the square wave is output, ↓ 5 sec the CEC line is considered to be normal. Power OFF (All zone OFF) FAN TEST : The function for making the FAN to be forced to rotate. SC-65...
Before turning the unit ON, be sure to ground the marked points with the Chassis 65. Or, you may short-circuit the ground points on the solder surface, using pieces of wire. Screws for Rear Panel BBZ30P080FTB BMZ30P040FTB BPZ30P100FTC ABA7078 ABA1207 SC-65...
Page 51
Front (5) Cut the Binder. ADX7776 (6) Release the 15P FCC (ADD7765) from the ∗2 PCB binder. USB RECT ASSY Notes on assembling ∗2: PCB binder tilt in the direction of the blue arrow. 15P FCC Front V-REG ASSY SC-65...
Page 52
DIGITAL MAIN ASSY HDMI Cable FRONT HDMI USB ASSY Front Section Note: Always connect the HDMI Cable because the iPod iPhone iPad LED blinks, which causes a shutdown, if the power is turned on JA8003 without the cable connected. SC-65...
Page 53
∗2 (8) Disconnect the two connectors. CN7901 (9) Remove the screw. (BBZ30P060FCC) PF04PG-S10 V-REG ASSY Notes on assembling CN7554 VREG GUARD ASSY Front ∗2: PCB binder tilt in the direction of the blue arrow. Doesn't touch the other cables. SC-65...
Page 54
∗7: Don’t touch the FAN Cable to the other cables and screw. FAN CONNECT_S ASSY Cushion Circle 14B CN3652 ∗7 ∗6 ∗7 ∗7 FAN Cable Insulating Sheet 65 (18) Remove the Insulating Sheet 65 (with the Cushion Circle 14B). SC-65...
Page 55
(2) Insert the Insulation Sheet. (3) Connect the Rear Panel to the Chassis 65 Ground and GND point of the D-AMP_S ASSY. (Refer to the “Ground Points” for the GND AUDIO ASSY point of the D-AMP_S ASSY.) Insulation Sheet D-AMP_S ASSY Chassis 65 SC-65...
Page 56
CN7802 (8) Connect the two pair board to board CN7801 extension jig cables. (GGD1798) 20P + 14P board to board (DIGITAL MAIN CN602 <-> CONNECT CN7802) extension jig cable (GGD1798) CONNECT ASSY (DIGITAL MAIN CN603 <-> CONNECT CN7801) SC-65...
Page 57
(2) Release the cable (ADX7778) from hook of Front the BIND FAN CABLE ASSY. IR Cover IR Cover 4P Housing ASSY Front (3) Remove the Acetate Tape. (4) Remove the two screws. (BSZ30P060FCC) (5) Remove the PRIMARY ASSY PRIMARY ASSY Acetate Tape PRI Angle Front SC-65...
Page 58
IR INTERFACE ASSY may be loosened. Attach the connectors securely. IR INTERFACE ASSY D-AMP_S ASSY Front Rear Panel [3-2] Diagnosis (1) Temporarily attach the IR Cover to the Rear Panel , using the three screws. (BBZ30P080FTB) IR Cover SC-65...
Page 59
23P + 23P board to board extension jig cables. (GGD1804) extension jig cable (GGD1804) (IR BUFFER CN6803 <-> IR INTERFACE CN3802) (IR BUFFER CN6802 <-> IR INTERFACE CN3801) IR BUFFER ASSY CN6803 CN6802 IR INTERFACE ASSY CN3802 CN3801 Front SC-65...
Page 60
(2) Remove the IR INTERFACE ASSY. IR INTERFACE ASSY D-AMP_S ASSY Front (3) Disconnect the five connectors. CN4003 CN4004 CN4000 CN4001 CN4002 D-AMP_S ASSY (4) Remove the six screws. (BBZ30P060FCC) (5) Remove the five screws. (IBZ30P150FCC) (6) Remove the D-AMP_S ASSY. D-AMP_S ASSY SC-65...
Page 61
HDMI connector. Always connect the HDMI Cable because the iPod iPhone iPad LED blinks, which causes a shutdown, if the power is turned on without the cable connected. Notes on assembling ∗1: Don't touch the cables to the Fuse Holder. SC-65...
Page 62
ADX7791 (11) Remove the nine screws. (BMZ30P040FTB) (12) Remove the screw. (BBZ30P080FTB) CONNECT ASSY (13) Disconnect the two connectors. (14) Unhook the hook. (15) Disconnect the connector and then remove the DIGITAL MAIN ASSY. COMPONENT ASSY DIGITAL MAIN ASSY SC-65...
Page 63
(DIGITAL MAIN CN603 <-> CONNECT CN7801) (7) Connect the 27P board to board extension CN602 jig cable. (GGD1799) DIGITAL MAIN ASSY (COMPONENT CN8301 <-> DIGITAL MAIN CN901) CN7802 27P board to board CN7801 extension jig cable (GGD1799) CN8301 CONNECT ASSY COMPONENT ASSY Front SC-65...
Page 64
(1) Remove the D-DAC BRIDGE ASSY. (2) Remove the A-DAC BRIDGE ASSY. Screwdriver AUDIO ASSY A-DAC BRIDGE ASSY DAC HIGH ASSY D-DAC BRIDGE ASSY Front (3) Remove the six screws. (BBZ30P080FTB) (4) Remove the DAC HIGH ASSY. DIGITAL MAIN ASSY DAC HIGH ASSY Front SC-65...
Page 65
Amplifier Block by wrong steps, sound quality would deteriorate. Therefore assemble it correctly following the procedure shown below. [1] Attach the D-AMP_S ASSY (1) Allocate the D-AMP_S ASSY attached with the Heat Cond Sheet, the Heat Sink Spacer and the Heat Sink 85. Don’t fix it with screws. D-AMP_S ASSY SC-65...
Page 66
(2) and (3). (BBZ30P080FTB) D-AMP_S ASSY (6) Remove the Rear Panel (with other ASSY). (7) Attach the five screws. (IBZ30P150FCC) (8) Attach the screw. (BBZ30P060FCC) D-AMP_S ASSY (9) Connect the five connectors. CN4003 CN4004 CN4000 CN4001 CN4002 D-AMP_S ASSY SC-65...
Page 67
(7) Remove the five screws temporarily fixed in accordance with step (3) and (4). (BBZ30P080FTB) (8) Remove the Rear Panel (with other ASSY). (9) Attach the two screws. (AMZ30P060FTC) Refer to the step (5) to (1) of “[3-1] Remove the IR Cover” of “Disassembly” henceforth. SC-65...
No setting file Mismatching between the setting file and the specification of the A/V RECEIVER type to be loaded back Error due to Checksum, Signature Check, and Size Check Ejecting of USB device (during reading of the setting file) SC-65...
S C - 6 5 / U X J C B 5. Pull out the AC cord. [Cautions] Writing of destination is not completed until the BridgeCo software starts. It takes about 45 seconds before the BridgeCo software starts. SC-65...
3. Connect the USB Memory to the USB terminal (A type) of the front panel. [Procedures] 1. While holding down "TUNE↑" key on the front panel, press "STANDBY ON/OFF" key and moves to the UPDATE PANEL mode. 2. The updating process is as follows. SC-65...
Page 72
Update Confirmation U P D A T E [PRESET ← ] [←] [→] Update Confirmation U P D A T E Y E S [ENTER] File searching A c c e s s i n g UPDATE FILE searching completed SC-65...
Page 73
Time required for updating varies, because only the programs that require updating will be updated. [Confirmation] Enter UPDATE PANEL mode and check that the programs have been updated. [Cautions] You cannot perform an update until the BridgeCo software starts. It takes about 45 seconds before the BridgeCo software starts. SC-65...
Screws adjacent to b mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 9.1 PACKING SECTION SC-65...
Page 75
See Contrast table (2) 14 Remote Control Unit MSW AXD7668 NSP 15 Dry Cell Battery (R3) VEM1051 (2) CONTRAST TABLE SC-65/UXJCB, SC-1527-K/CUXJ and SC-1522-K/UXJCB are constructed the same except for the following: SC-65/ SC-1527-K/ SC-1522-K/ Mark No. Symbol and Description...
ASSY CN8001 FRONT HDMI USB ASSY JA8003 AUDIO ASSY FRONT HDMI USB JP3001 ASSY JP8001 CONPONENT ASSY JP8402 MIC HP ASSY CN3472 Refer to “9.5 FRONT SECTION” Double side tape 10 x 110mm DISPLAY ASSY JP3001 DISPLAY ASSY CN3001 SC-65...
9.3 REAR SECTION PRIMARY ASSY JP51 FRONT HDMI USB ASSY CN8001 A-REG ASSY CN7502 V-REG ASSY CN7554 Refer to “9.4 CHASSIS SECTION” SC-65...
Page 79
18 9P FFC (J0006) ADD7781 19 Rear Panel See Contrast table (2) 20 Right Angle 85 ANG7687 (2) CONTRAST TABLE SC-65/UXJCB, SC-1527-K/CUXJ and SC-1522-K/UXJCB are constructed the same except for the following: SC-65/ SC-1527-K/ SC-1522-K/ Mark No. Symbol and Description UXJCB...
Power Transformer DIGITAL MAIN ASSY CN9501 Acetate Tape Tape Tape Cleaning paper GED-008 Accessory of Panel Base IR REG ASSY CN7241 IR REG ASSY CN7271 IR REG ASSY CN7251 Accessory of Panel Base IR REG ASSY CN7401 COMPONENT ASSY CN8401 SC-65...
Note ∗2: Please tape up at four (4) places to protect Panel Base 55U as shown on the photograph when you remove the Panel. Left side Right side Note ∗3: Double Side Tape (10mm x 30mm) affixing position on the Panel. Center line +0mm -1.5mm Inside SC-65...
Page 83
18 Damper ASSY (240) LX AXA7156 19 VOL. Knob LX55 AAA7068 20 STDBY BTN LX85 ASSY AAD7804 (2) CONTRAST TABLE SC-65/UXJCB, SC-1527-K/CUXJ and SC-1522-K/UXJCB are constructed the same except for the following: SC-65/ SC-1527-K/ SC-1522-K/ Mark No. Symbol and Description UXJCB...
*R3956 awx1114 awx1115 *R3957 R3991 awx1273 *R3958 DAC OUT<-> PRE OUT R3992 J2501 AKB7246-A pattern A J2502 AKB7247-A R3993 J2503 GNDA J2504 AKB7246-A R3995 HP<-> J2505 AKB7247-A : Audio Signal Route ZONE OUT R3996 pattern A GNDA GNDA SC-65...
Page 85
The > mark found on some component parts indicates the importance of the safety factor of the part. HP<-> ZONE OUT R3996 pattern A Therefore, when replacing, be sure to use parts of identical designation. : The power supply is shown with the marked box. GNDA GNDA SC-65...
Page 93
Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. 1000p or less : CCSRCH, Over 1000p : CKSRYB 3. NM: No Mount mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. SC-65...
YB:CKSRYB, QYB:CKSQYB, SYB:CKSSYB, CH:CCSRCH, SCH:CCSSCH C2058 R2232 AT:CEAT, ZL:CEHAZL, QHX:CFHXSQ 3. NM: No Mount GNDD AWX1103- 2.2u/10 CCG1222-A 39k(1/8W) AWX1294- mark found on some component parts should be replaced AWX1307- CN3783 with same parts (safety regulation authorized) of identical designation. SC-65...
3. NM : NO MOUNT CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND RATINGS OF FUSE. mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. SC-65...
Page 101
USB RECT ASSY (AWX1166) 50-A IBZ30P080FCC V+UN_USB C3657 CN3652 V+UN_USB GNDUSB JP8001 C3656 B2B-EH NDUSB KN3651 AKF7002-A OF FIRE, SC-65...
Page 105
Rear Side GNDD PRIMARY SHIELD REAR PANEL CN7802 KN601 KN602 GND1 GND1 GND3 GND3 GND2 GND2 GND4 GND4 VNE1948-A GNDD mark found on some component parts should be replaced GNDD with same parts (safety regulation authorized) of identical 2/11 designation. SC-65...
6/11 27MHz R7X2- Data2- GNDD V+1R3_PP Data2 Shield R7X2+ V+3R3_HHH mark found on some component L9614 L9617 Data2+ parts should be replaced with same VTL1129-A parts (safety regulation authorized) VTL1129-A of identical designation. CEC_IO_1 GNDD 6/11 3/11 GNDD GNDD SC-65...
0.1u/16 L1636 VTL1129-A C1647 330p/50 IC1613 P1_SPDIF/DSDSL V+1R3_ 7/11 R1782 HDSPDIFRX R1783 DSPI2S RX_SPDIF/DSDSL R1741 7/11 R1742 R1784 TC74VHCT126AFK GNDD mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. 6/11 SC-65...
Page 113
V+3R3_HHH R1789 R1790 Hot Plug Detect L1642 HDMI ZONE 3/11 (1608) C1642 0.1u/50 C1643 330p/50 IC1615 V+5_HD GNDD IC1612 HDMI OUT ZONE PP2SS (ZONE 4 OUT) PP2SDO SO/SIO1 HOLD R1632 SCLK R1633 SI/SIO0 MX25L4006EM2I-12G-K GNDD AYW7379- /J GNDD 6/11 SC-65...
CH : CCSRCH , CFTLA : CFTLA *JA7003 NO MARKED : CKSRYB or CEAK 3. NM: No Mount 12V TRG1 *Q7003 RT1N241M 12V TRG2 mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical AKN-209-A 12VTRG2 designation. GNDV SC-65...
Page 125
ISA1602AM1(EF) GNDD JV7001 Q7024 R7085 2SC4154-11(EF) Q7023 2SC4154-11(EF) GNDD GNDD GNDV GNDD GNDV GNDF GNDV GNDV GNDD R7088 Near AMP and 12V TRG KN7006 AKF7002-A : Video Signal Route 12V TRG1 : Audio Signal Route 12V TRG2 GNDV GNDD SC-65...
Unit: p-pF or u-uF unless otherwise noted. *C8615 Ratings: Capacity(F)/Voltage(V) unless otherwise noted. *C8619 10p/50 *R8630 AK : CEAK *R8634 1000p or less : CCSRCH, Over 10u and 2125 : CKSQYB *C8616 NO MARKED : CKSRYB 3. NM: No Mount *R8631 GNDCH232 GNDD GNDV SC-65...
Page 127
: Video Signal Route C8393 with same parts(safety regulation authorized) of identical erwise noted. (V) unless otherwise noted. designation. : Video Signal Route *C8394 ver 10u and 2125 : CKSQYB 47p/50 *R8629 : Video Signal Route GNDV GNDD SC-65...
R3019 3 GND S3005 JOGA JOG_A ASG7029-A C3346 JOGB JOG_B TUNER EDIT GNDD (HOME THX/STEREO) CHEMICON2 BOTTOM 51048-0300 SOUND GNDD GNDD CN3501 mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical designation. SC-65...
Page 157
3216 SIZE mark found on some component parts should be replaced RS1/16S*** RS1/10S*** RS1/8S*** 2125 3216 RN1/16S*** with same parts(safety regulation authorized) of identical RS1/8SQ*** RS1/4SA*** 2125 3216 1/8W 1/4W CCSR*** designation. CCSQ*** CCS*** 6/10 CKSR*** 2125 3216 CKSQ*** CKS*** SC-65...
CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND SAME RATING OF FUSE. JV71 JUMPER *S81 JV87 *CN81 JUMPER_JV 2VOL-SW *JV81 MAIN JUMPER TRANS INC2002AC1 *JV82 JUMPER B2P3-VH *JV83 JUMPER JV84 *CN82 JV85 JV86 MAIN TRANS G_CHASSIS1 G_CHASSIS1 SC-65...
Page 167
MUF : RD1/4MUF 2. CAPACITORS designation. Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CH : CCSRCH , CFTLA : CFTLA AK : CEAK NO MARKED : CKSRYB or CEAT 3. NM: No Mount SC-65...
JH7254 JH7255 AEF7008-A AEF7008-A AEF7008-A AEF7008-A FU13 H7252 H7251 D7251 1SR154-400 AKR1004-A-T D7252 1SR154-400 D7253 FU14 1SR154-400 D7254 H7254 H7253 AKR1004-A-T 1SR154-400 CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND RATINGS OF FUSE. SC-65...
Page 174
2125 : RS1/8SQ MUF : RS1/4MUF 2.CAPACITORS Unit: p-pF, or F unless otherwise noted. Ratings: Capacity( F)/Voltage(V) unless otherwise noted. NP : CEANP CFTLA ; CFTLA AK : CEAK NO MARKED : CEAT or CKSRYB 3. NM : NO MOUNT SC-65...
Page 175
V-5_V GNDV V-5V V-12 V-5V mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. CAUTION- FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND RATINGS OF FUSE. SC-65...
CH : CCSRCH , CFTLA : CFTLA NP : CEANP , AK : CEAK NO MARKED : CKSRYB or CEAT 3. NM: No Mount mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical designation. SC-65...
LOCK DET MIC HP GUARD ASSY BIND DM CABLE ASSY (AWX1152) (AWX1168) AEF7008-A AEF7008-A AEF7008-A JH5924 JH3551 JH5921 P WIRE GUARD ASSY FFC GUARD ASSY (AWX1229) (AWX1167) JH3560 AEF7008-A AB AC AD AE AF AB AC AD AE AF SC-65...
10.55 BIND FAN CABLE, VREG GUARD, TRANS VREG STYL, IR EDGE GUARD and PANEL GUARD ASSYS BIND FAN CABLE ASSY VREG GUARD ASSY (AWX1231) (AWX1153) TRANS VREG STYL ASSY IR EDGE GUARD ASSY (AWX1256) (AWX1230) PANEL GUARD ASSY (AWX1154) AG AH AI AJ AK AG AH AI AJ AK SC-65...
Q8001 C8010 IC8002 IC8002 Q8005 C8004 Q8008 MHL_CTL C8002 [[ G ]] Q8006 R8001 2 3 4 A30C5/C7 Q8006 R8005 Q8009 Q8009 D8006 F-HDMI USB ASSY (ANP7827-A) SIDE B SIDE B FRONT HDMI USB ASSY (ANP7827-A) JA8003 JP8001 CN8001 SC-65...
PAR LE FUSIBLE PAR UN MODELE IDENTIQUE EN INTENSITE C3658 AWX1166 C3666 C3665 JV3651 R3651 1.V+UN_USB 2.GND_USB JH3651 [[ G ]] USB RECT ASSY KN3651 D3651 (ANP7832-A) SIDE B SIDE B USB RECT ASSY C3662 C3661 R3653 (ANP7832-A) CN3653 SC-65...
SIDE A SIDE A MIC HP ASSY 1148 AWX 1149 J3459 CN3472 HP R MICDET J3456 J3458 J3454 V+7_A AMUTE GNDA J3457 C3484 C3483 C3478 JA3476 KN3472 KN3471 MIC HP Ass'y [[ G ]] J3451 (ANP7828-A) GNDCH1 JA3471 C3474 SC-65...
11.11 VOL, POWER SW and ENCODER ASSYS SIDE A SIDE A VOL ASSY VOL Ass'y S3371 NO CLICK AWX1134 J3371 GNDD CN3371 (ANP7828-A) POWER SW ASSY 1.V+5_EV_1 2.POWLED 3.POWER_KEY 4.GNDD (ANP7828-A) ENCODER ASSY S3501 Click ENCODER Ass'y AWX1150 J3501 CN3501 (ANP7828-A) K L M SC-65...
Page 217
GNDD CN3371 (ANP7828-A) POWER SW ASSY ¡AWX1135 ¡AWX1151 ¡AWX POWER SW Ass'y 1.V+5_EV_1 2.POWLED 3.POWER_KEY 4.GNDD Q3401 CN3401 C3401 V+5_EV [[ G ]] (ANP7828-A) ENCODER ASSY C3501 C3502 [[ G ]] ENCODER Ass'y 1150 CN3501 (ANP7828-A) K L M SC-65...
C4601 L4100 L4600 L4200 L4700 L4500 C4200 C4100 C4700 C4600 RY4100 RY4700 RY5000 RY4500 DATA C5110 XOLERR XBERR BOND ICEMUTEA ICEMUTESB C4710 MUTEFH RY FW RY AF C4110 RY CR RY FH RY B AMPTEMP XTEMPERR5 XDCERR GNDHD GNDHD SC-65...
11.15 PRIMARY ASSY SIDE A PRIMARY ASSY PRIM SECONDARY PRIMARY SIDE SIDE KN50 The Parts must not enter this area. BOND SC-65...
Page 229
SIDE A AC CORD AC CORD MAIN TRANS JA71 JA71_1 CN81 PRIMARY Ass'y T2A H 250V CAUTION -REPLACE FUSE LINKS AS MARKED. FU4 215002. MFD.BY LITTELFUSE INC. (ANP7828-A) SC-65...
11.21 FAN CONNECT_S ASSY and MIC HP GUARD ASSY SIDE A FAN CONNECT_S ASSY CN3651 [[ G ]] FAN_CONNECT_S ASSY A30C5/C7 ¡AWX ¡AWX1130- CN3651 JP7291 MIC HP GUARD ASSY JH5921 DO NOT THROW! JANGAN BUANG AB AC SC-65...
Page 249
SIDE A (ANP7825-A) CN3652 AWX1152 UANG MIC HP GUARD Ass'y JH5924 (ANP7828-A) SC-65...
Page 250
SIDE B FAN CONNECT_S ASSY 1.V+FAN 2.V-FAN 3.LOCK_DET CN3652 CN3652 MIC HP GUARD ASSY AWX1152 MIC HP GUARD?@Ass'y AB AC SC-65...
Page 251
SIDE B FAN_CONNECT_S ASSY ¡AWX1130- ¡AWX 1.V+FAN 2.V-FAN 3.LOCK_DET CN3651 (ANP7825-A) CN3651 DO NOT THROW! [[ G ]] JANGAN BUANG (ANP7828-A) SC-65...
BIND DM CABLE ASSY [[ G ]] AWX1168 JH3551 BIND DM CABLE ASSY DO NOT THROW! JANGAN BUANG! (ANP7832-A) P WIRE GUARD ASSY [[ G ]] JH3560 RIVET BIND AWX1229 DON'T THROW! RIVET P_WIRE_GUARD ASSY JANGAN BUANG (ANP7832-A) AD AE SC-65...
Page 253
SIDE B SIDE B BIND DM CABLE ASSY [[ G ]] AWX1168 BIND DM CABLE ASSY DO NOT THROW! JANGAN BUANG! (ANP7832-A) P WIRE GUARD ASSY BIND AWX1229 DON'T THROW! P_WIRE_GUARD ASSY JANGAN BUANG (ANP7832-A) AD AE SC-65...
BUANG TRANS VREG STYL ASSY (ANP7832-A) BIND FAN CABLE ASSY DON'T THROW! (ANP7831-B) IR EDGE GUARD ASSY AWX1230 IR EDGE GUARD ASSY (ANP7832-A) [[ G ]] DO NOT THROW rivet A30C5/C7 JANGAN BANG (ANP7829-A) AF AG AH AI AJ SC-65...
Page 255
VREG GUARD ASSY NO USE AWX1153 DO NOT THROW! JANGAN BUANG (ANP7828-A) TRANS VREG STYL ASSY (ANP7832-A) AWX1256 DON'T THROW! BIND FAN CABLE ASSY JANGAN BUANG TRANS-VREG_STYL ASS'Y (ANP7831-B) IR EDGE GUARD ASSY (ANP7832-A) (ANP7829-A) AF AG AH AI AJ SC-65...
Page 257
CCSRCH100D50 Not used POWER SW ASSY AWX1135 and AWX1151 are constructed the same except for the following: Mark Symbol and Description AWX1135 AWX1151 Q3401 RT1N431M Not used D3402 SLR343BC4T(JKLM) Not used R3401 RS1/10SR151J Not used C3401 CCSRCH221J50 Not used SC-65...
Page 258
PCB PARTS LIST FOR SC-65/UXJCB UNLESS OTHERWISE NOTED Mark No. Description Part No. Mark No. Description Part No. C 2683,2699,2701,2702 CKSRYB103K50 C 2693,2694,2828,2836 ACH1479 AUDIO ASSY C 2695,2696,2834,2835 CFHXSQ103J16 C 2700,2703,2704,2759 CCSRCH101J50 C 2705,2706,2761,2762 CKSRYB103K50 SEMICONDUCTORS IC 2501,3273 BD3473KS2 C 2751-2758,2760,2826...
Page 259
R 2321,2328,2330,2335 RS1/4SA182J R 2331,2333 RS1/4SA222J C 2179,2184,2187,2432 CEAK101M35 R 2350-2352,2363,2364 RS1/16SS101J C 2182 CKSQYB225K16 C 2188,2190,2192,2195 CKSQYB103K50 R 2380-2382,2386-2394 RS1/16SS0R0J C 2191,2196,2197,2238 CFHXSQ103J16 R 2384,2385,2432 RS1/16SS100J C 2208,2212,2217,2220 CKSQYB104K50 R 2425-2429,2440 RS1/16SS0R0J R 2433-2435,2437-2439 RS1/16SS101J R 2441,2442,2471,2480 RS1/16SS101J SC-65...
Page 260
JH 8002 PCB BINDER AEF7008 JP 8001 HOUSING ADX7760 SEMICONDUCTORS IC 101 UPD61110GM-100UEVA RESISTORS IC 102,9201 M12L2561616A-5TG2A R 8005,8011,8052-8054 RS1/8SQ0R0J IC 103 AYW7377 R 8009 RS1/10SR473J IC 104,604,1808 TC7WHU04FK R 8014,8015 RS1/16SS2202F IC 601,607,612,1502 TC74VHCT08AFKS1 R 8022 RS1/10SR0R0J R 8044 RS1/16SS1801F SC-65...
Page 261
CN 9003 B TO B CONNECTOR AKP7269 > Q 9503 RZQ045P01 CN 9202 CONNECTOR AKM1277 CN 9501 CONNECTOR B7B-EH Q 9507 RTQ040P02 > JH 9501,9502 PCB BINDER AEF7008 D 601,9201 RB501V-40 D 1601,1602,9151 RKZ5.1KG(B2) D 9401 1SR154-400 D 9504 1SS355 SC-65...
Page 262
R 9475 RS1/16SS8200D C 679,732,737 CCSSCH100D50 R 9476 RS1/16SS1501D C 690-692,697 CCSSCH101J50 R 9514 RS1/8SQ365J C 693,734,750,1040 CCSSCH221J50 R 9515 RS1/8SQ475J C 698-701,704,713 CCSSCH331J50 C 705-708,717,718 CCSSCH101J50 R 9641 RS1/8SQ105J R 9720,9726,9727,9744 RAB4CQ680J R 9729,9733 RAB4CQ220J Other Resistors RS1/16SS###J SC-65...
Page 263
C 1845,9003,9013,9015 CCSSCH331J50 C 1289,1297,1305,1318 CKSSYB104K16 C 1846,1854,1905 CKSSYB104K16 C 1294,1311,1323,1325 CCSSCH331J50 C 1903,9409 CKSSYB682K25 C 1299,1637,1756,1835 CCSSCH221J50 C 1917-1922,1931,1932 CKSSYB104K16 C 1313,1326 CCSSCH150J50 C 1933,9248 CKSQYB225K16 C 1319,1324,1334,1342 CKSSYB104K16 C 1935,9005,9029,9169 CEVW101M4 C 1322,1333,1339,1392 CCSSCH101J50 C 1943-1947,1962,1969 CKSSYB104K16 SC-65...
Page 264
C 9723,9726,9729,9731 CKSSYB104K16 C 9273,9301,9401,9402 CCSSCH100D50 C 9727 CEVW101M4 C 9279,9297,9326 CCSSCH102J50 C 9734,9741,9743,9745 CKSSYB104K16 C 9280,9288,9294,9311 CKSSYB104K16 C 9736,9739,9742,9750 CCSSCH101J50 C 9281,9296,9319,9487 CCSSCH331J50 C 9738,9740,9748,9752 CCSSCH331J50 C 9283,9286,9290,9292 CKSSYB103K25 C 9747,9749,9760,9772 CKSSYB104K16 C 9287,9293,9295,9310 CCSSCH101J50 C 9751,9771,9783 CCSSCH101J50 SC-65...
Page 265
C 7095 CEAK100M50 C 8395,8401,8522,8523 CKSRYB104K50 C 7101,7143 CCSRCH101J50 C 7108 CEAK470M25 C 8406,8407,8503,8509 CCSRCH101J50 C 7111,7113 CCSRCH331J50 C 8409,8414 DCH1201 C 8410,8413,8415,8421 CCSRCH102J50 C 7112 CEAK221M16 C 8418,8520,8521,8613 CEAK101M16 C 7120,7121 CKSQYB105K25 C 8419,8420 CEAK221M16 C 7135 CCSRCH102J50 SC-65...
Page 266
C 3007,3008,3011,3205 CCSRCH471J50 Other Resistors RS1/10SR###J C 3010,3042 CCSRCH101J50 CAPACITORS C 3012 CKSRYB472K50 C 3451,3452 CKSRYB822K50 C 3015,3016 CKSRYB473K50 C 3457,3475,3479,3494 CCSRCH101J50 C 3017,3022,3102,3202 CCSRCH331J50 C 3460 DCH1165 C 3018,3035,3045 CKSRYB103K50 C 3473 CCSRCH471J50 C 3023,3025,3027,3038 CKSRYB104K50 C 3476,3477 CCSRCH330J50 SC-65...
Page 267
C 7477 CEAK220M50 C 7495 CCSRCH100D50 MISCELLANEOUS S 3501 ROTARY ENCODER ASX7054 CN 3501 3P JUMPER CONNECTOR 52147-0310 BUFFER GND ASSY RESISTORS All Resistors RS1/10SR###J MISCELLANEOUS KN 6961 SCREW PLATE VNE1948 CAPACITORS KN 6962 SCREW PLATE(MTL) ANG7591 C 3501,3502 CKSRYB103K50 SC-65...
Page 268
ISA1602AM1 RESISTORS Q 4501,4502,4601,4602 IRF6775MPBF R 4042 RS1/8SQ0R0J > Q 4503-4505,4508 2SC4154-11 R 4057 RS1/8SQ471J R 4060 RS1/10SR5602F Q 4507,4511,4513,4606 ISA1602AM1 R 4061 RS1/10SR3302F Q 4510,4610,4710,4810 2SA1514K R 4101,4201,4301,4401 RS1/10SR3001F Q 4512,4712,4912,5012 RT1N140M Q 4603-4605,4608 2SC4154-11 Q 4607,4611,4613,4706 ISA1602AM1 SC-65...
Page 269
R 4925,4926 ACN7094 R 4507,4587,4588,4607 ACN7180 R 4927 RS1/4SA104J R 4511-4514,4611-4614 RS1/4SA2R2J R 4929 RS1/8SQ182J R 4515,4615,4715,4815 ACN7192 R 4930,4931,4934,5029 RS1/8SQ103J R 4516,4578,4616,4678 ACN7198 R 4932 RS1/8SQ123J R 4519,4520,4567,4619 RS1/10SR1001F R 4933,4977 ACN7197 R 4522,4523,4622,4623 ACN7196 R 4935 RS1/8SQ752J SC-65...
Page 270
C 4920,4923,5000 CFHXSQ102J50 C 4101,4201,4301,4401 CFTLA474J2A C 4921,4922 CFHXSQ103J16 C 4108,4109,4208,4209 ACH7320 C 4934,4936 ACH7376 C 4113,4213,4313,4413 CKSRYB104K50 C 4119,4219,4319,4419 ACG7110 C 4949,4950 ACH7359 C 4120,4123,4205,4220 CFHXSQ102J50 C 4956 CKSRYB473K50 C 4959,4960 ACG7107 C 4961,4975 ACG7105 C 5080,5082,5180,5182 ACE7090 SC-65...
Page 271
H 7201-7204,7241,7242 FUSE CLIP AKR1004 C 52 BCH1044 H 7251-7254 FUSE CLIP AKR1004 C 58 ACH7369 CN 7201 8P TOP POST B8B-EH C 61 CCSRCH101J50 CN 7241 PLUG(2P) KM200NA2 CN 7251 PLUG(7P) KM200NA7 > C 73 XCG3010 C 74,75 CCSRCH220J50 SC-65...
Page 272
MISCELLANEOUS RESISTORS H 7551-7554 FUSE CLIP AKR1004 R 7808-7820,7891-7897 RS1/10SR100J CN 7551 5P TOP POST B5B-EH Other Resistors RS1/8SQ###J CN 7552,7553 PLUG(7P) KM200NA7 CN 7554 PLUG(4P) KM200NA4 CAPACITORS CN 7661 B TO B 19PIN JACK AKN7071 C 7813,7816 CCSRCH100D50 SC-65...
Page 273
CN 6951,6952 B TO B 23PIN PLUG AKM7107 FAN CONNECT_S ASSY MISCELLANEOUS CN 3651,3652 PLUG(3P) KM200NA3 JH 3651 PCB BINDER AEF7008 MIC HP GUARD ASSY MISCELLANEOUS JH 5921,5924 PCB BINDER AEF7008 BIND DM CABLE ASSY MISCELLANEOUS JH 3551 PCB BINDER AEF7008 SC-65...