Wolf BBQ242BI Installation Instructions Manual page 16

W O L F
L P G A S
AT T A C H I N G T H E R E G U L A T O R
The pressure regulator and hose assembly
supplied with this appliance must be used.
The pressure regulator and hose assembly
provided is factory set at an outlet pressure of
10" (25 mb) WC; .4 psi (2.8 kPa). The BBQ grill
regulator is equipped with a coupling nut.
Refer to the illustrations below. Do not attempt
to connect to any LP gas cylinder not equipped
with a mating quick connect closing (QCC-1)
cylinder valve.
The coupling nut connects to the large outside
thread on the valve outlet. To complete the
connection, follow these steps:
Make sure all grill burner valves (including
open burner and rotisserie if so equipped)
are in the OFF position.
Make sure the cylinder valve handwheel is
in the closed position. Turn clockwise (left
to right) to full stop.
Remove the protective caps from the
cylinder valve and coupling nut.
16
G A S B B Q G R I L L S
R E G U L AT O R
Manifold Pipe
LP Gas
Cylinder
LP gas hook-up
Hold the regulator in one hand and insert
the nipple into the cylinder valve. Be sure
the nipple is centered in the valve outlet.
Hand tighten the coupling nut. Do not
cross-thread the connection.
Turn the coupling nut clockwise (left to
right) to tighten to a full stop.
IMPORTANT NOTE: In the connection
process, the grill side of the connection will
seal on the backcheck in the valve, resulting in
a slight resistance. An additional
will be required to complete the connection.
Tighten by hand only. Do not use tools.
If you cannot complete the final connection,
disconnect the regulator and repeat the last
two steps. If you are still unable to complete
the connection, do not use this valve and
regulator. Call your Wolf dealer or Wolf author-
ized service center to order the replacement
parts.
DO NOT insert any foreign objects into
the valve outlet. The backcheck may be
damaged. A damaged backcheck can be
the source of a leak. Leaking LP gas may
result in explosion, fires, severe personal
injury or death.
Coupling Nut
Coupling Nut
Regulator
LP Gas
Cylinder
LP gas regulator
1 3
/ to / turn
2 4
Regulator
To Grill
Vent Points Down