Related Manuals for Cal Spas Home Resorts FA-1325
Summary of Contents for Cal Spas Home Resorts FA-1325
- Page 1 SWIM & SWIM PRO SPAS Family Fun Spas Model: FA-1325 Cal Spas Home Resorts Owner’s Manual ™...
- Page 2 Lloyd’s Material Supply Company, Inc. Lloyd’s Material Supply Company, Inc. Copyright 2023. All rights reserved. Duplication without written consent is strictly prohibited. Lloyd’s Material Supply Company, Inc. Customer Service Department 1462 East Ninth Street Pomona, CA 91766. LTR2023.1146 REV D-4 LTR2023.1146, REV.
-
Page 3: Table Of Contents
Important Safety Instructions............ Preparing for Your New Spa..............Foundation Requirements & Service Clearance......240 Volt Electrical Requirements............GFCI Wiring Diagram..............Filling and Powering Up the Spa............Priming & Bleeding Water Pump............TP500 Control System..............Spa Behavior....................Temperture Range................... Ready and Rest Mode................Set Time of Day &... -
Page 6: Preparing For Your New Spa
Pre-Delivery Checklist � T T h h a a n n k k y y o o u u f f o o r r p p u u r r c c h h a a s s i i n n g g o o u u r r F F a a m m i i l l y y F F u u n n s s p p a a Before Delivery w w e e l l c c o o m m e e t t o o t t h h e e C C a a l l s s p p a a s s F F a a m m i i l l y y . -
Page 7: Foundation Requirements & Service Clearance
Service Area Clearances Service Area Clearances 3 feet / 1 meter 3 feet / 3 feet / 1 meter 1 meter 3 feet / 1 meter Foundation Requirements Foundation Requirements Your spa needs a solid foundation. The area that it sits on must be able to support the weight of the spa, filled with water and with occupants in it. -
Page 8: 240 Volt Electrical Requirements
240 Volt Electrical Specifications 240 Volt Electrical Specifications Wiring Specifications and GFCI Requirement Wiring Specifications and GFCI Requirement Control System Spa Model GFCI Breaker Wires Required Wiring Diagram FA-1325 BP501X One 50 Amp GFCI Four #6 AWG Cop- See Page 10 Breaker per Wires for reference only... -
Page 9: Gfci Wiring Diagram
GFCI Wiring Diagram USA/Canada GFCI Wiring Diagram 1 USA/Canada 60 Hz House Breaker Box GFCI Breaker Box RED (Hot) BLACK (Hot) WHITE RED (H OT) (Neutral) BLACK (H OT) WHITE (Neutral) WHITE BLACK WHITE GREEN (Ground) (Hot) (Hot) (LOAD NEUT RAL) Bottom View of GFCI One 220V circuit breaker One GFCI... -
Page 10: Filling And Powering Up The Spa
Priming the Spa Pump Filling and Powering Up Your Portable Spa This applies to all spa owners EXCEPT those with the Cal Clarity II bromine generator. See instructions on page 31 for bromine generator operating instructions and spa filling procedures. 1 . - Page 11 4 . Turn on power to the spa . When the spa is filled to the correct level, turn on the power at the GFCI breaker. (Ensure that the 120V spas are connected to the proper electrical outlet.) 5 . Prime the pump . 6 .
-
Page 12: Priming & Bleeding Water Pump
Priming the Pump New spa owners often have difficulty the first time they The pump will not work properly while start their spa and the pump fails to prime. This can be air is trapped in it. Continuing to operate frustrating, but these simple instructions can help you. - Page 13 Navigation / TP-500 Navigating the entire menu structure is done with 2 or 3 buttons on the control panel. Some panels have separate WARM (Up) and COOL (Down) buttons, while others have a single Temperature button. In the navigation diagrams Temperature buttons are indicated by a single button icon.
-
Page 31: Tp500 Control System
Cal Connect RF Set Up Guide Congratuations! Welcome to Cal Connect Control My Spa, the smart control system for spa monitoring on the go. With Cal Connect you will be able to control/monitor water temperture, control pump operation, adjust filtration, and monitor/control any activity occuring within your spa. This Quick Start guide will help you with inital set up of your RF module. - Page 32 Download the Control My Spa App To Begin the inital set up of the Cal Connect system, download the “Control My Spa” app by Balboa Water Group from the App Store or Google Play Store. Before starting the app, have your CMS code in hand. This is a unique code provided to you by your dealer.
- Page 33 Control My Spa Set-Up 5- The App will begin scanning for the spas wifi module. within a few seconds the module serial number should appear. 6- Select the “Yes” option once the serial number appears on screen and proceed with the following steps.
-
Page 35: Energy Consumption Tips
Energy Consumption Tips Energy Consumption Tips Spa Jets Spa Jets LED Lighting LED Lighting... -
Page 36: Water Clarity Information
Water Clarity Information Water Clarity Information The Four Rules of Water Clarity The Four Rules of Water Clarity Water Diverters Water Diverters Air Venturis Air Venturis Hydro Streamers Hydro Streamers... -
Page 37: Testing & Adjusting Spa Water
Testing and Adjusting Spa Water Testing and Adjusting Spa Water... -
Page 38: Chemical Sanitation
Chemical Sanitation Chemical Sanitation produces low chemical odors. Unlike chlorine, it can beak down baceria and other impurities to a safe level with a low burn-out rate. -
Page 39: Bather Loads
Bather Load Bather Load Filter Cleaning Filter Cleaning Ozonator Ozonator 39 63... -
Page 40: Maintence Schedule
Factory Filtration Factory Filtration Maintenance Schedule Maintenance Schedule Clean and polish the acrylic surface Clean and treat the spa cover and pillows Troubleshooting Water Clarity Problems Troubleshooting Water Clarity Problems... - Page 41 41 65...
-
Page 42: Cleaning & General Maintence
Spa Maintenance & Care Spa Maintenance & Care Pillow Removal & Reinstallation Pillow Removal & Reinstallation Jet Removal & Installation Jet Removal & Installation Cleaning The Hydro Streamers Cleaning The Hydro Streamers 42 74... -
Page 43: Installing The Spa Cover
Spa Cover and Locking System Installation Spa Cover and Locking System Installation... -
Page 45: Draining The Spa
Draining the Swim Spa Draining the Swim Spa... -
Page 46: Winterization
Winterization (Cold Climate Draining) Winterization (Cold Climate Draining) Cleaning and Replacing filter Cleaning and Replacing filter Vacation Care Vacation Care... -
Page 47: Cleaning Your Spa
Cleaning Your Swim Spa Cleaning Your Swim Spa Cleaning Your Family Spa Cleaning Your Family Spa Freedom Sound System Freedom Sound System Aquatic AV 72 78... -
Page 48: Air Injection System
Working Out With Your Swim Spa Working Out With Your Swim Spa Air Injection/ More Resistance Air Injection/ More Resistance Swim Tether Swim Tether The swim tether and anchor points are placed in the Family Fun spa to place a tether point for the use of swim spa attachments or fitness bands. -
Page 49: Replacement Parts
MFD 3.5” Maxi Flow Directional PLUCS2295091SL PSD 5” Power Storm MED 3” XL Cluster Storm Directional PLUCS2295131SL PLUCS2295031SL mfd 3” Micro Flow Directional PLUCS2295141SL PLUCS2295061SL PST 5” Power Storm Wagon Wheel MM 3” Mini Storm Massage PLUCS2295191SL PLUCS2297061SL-8... - Page 50 Esc., CDG/HLG Part # CS2444049S-CDHL Power Storm Internal, Twister, Velocity Esc. – CDG/HLG Part # CS2444019S-CDHL Pwr. Storm Int. Cal Spas Tri Directional Eyeball, Velocity Esc., Metal CDG/HLG Part # CS2444059S-CDHL Power Storm Internal, Multi-Massage, Velocity Esc., Metal – CDG/HLG...
- Page 51 CLUSTER JETS Part # CS2441009S-CDHL Part # S2442059S-CDHL Cluster Storm Internal, Directional, Mini Storm Internal, Multi-Massage, Velocity Esc., Metal – CDG/HLG Velocity Esc., Metal – CDG/HLG Part # CS2441029S-CDHL POLY JETS Cluster Storm Internal, Twin, Velocity Esc., Metal – CDG/HLG Part # CS2443009SSCDHL Poly Storm Internal, Metal...
- Page 52 JET INSERTS (Updates) PILLOWS Black Cascade Pillow Carbon Fiber Black “Y” Pillow Carbon Fiber Power Stream Swim Jet Black “Y” Pillow Carbon Fiber Swim Jet Rip Current Metal DSG/clear Power Stream Swim Jet Design S-01-4325 Design S-01-4324 Design S-01-4324 w/ Load Washer PLU210-0821S PLU210-0821S ACC01401103...
- Page 53 DYNA-FLO PLUS FILTER, 75SF 2"CKV 4SCLP; HIGH VOLUME; LESS CARTRIDGE Part # FIL510-9559-CDCL TELEWEIR FILTER, 50SF 2"CKV 6SCLP LESS CARTRIDGE 2-TONE CDG/HLG Part # FIL510-4609-CDCL 50 sq ft female threaded - antibacterial for Teleweir skimmer shown above) FIL11100208 SUCTION Part # 644-5419CDHL V 5"DESIGNER PRO-SUCT.
- Page 54 AIR CONTROL Part # CS6603709-CDHL "Cal Spas 1” Air Control Complete Assembly, Velocity Style, CDG/HLG Part # PLUCS6054309-CDCL "Cal Spas 1” Air Control Complete Assembly, Velocity Style, CDG/HLG" Part # CS6053309-CDHL "Cal Spas 2 ”Top Access Diverter Valve Sub-Assembly, Velocity Style,CDG/HLG“...
- Page 55 EXC12000008 EXC12000007 Exercise Kit Attachment Plate EXC11000065...
-
Page 59: Thermal Creep
To obtain service in the event of a defect covered by this Limited Warranty, notify your Cal Spas dealer or Cal Spas as soon as possible and use all reasonable means to protect the spa from further damage. Upon proof of purchase, a designated service representative will correct the defect subject to the terms and conditions contained in this Limited Warranty. -
Page 60: Warranty Information
To obtain service in the event of a defect covered by this Limited Warranty, notify your Cal Spas dealer or Cal Spas as soon as possible and use all reasonable means to protect the spa from further damage. Upon proof of purchase, a designated service representative will correct the defect subject to the terms and conditions contained in this Limited Warranty. - Page 61 The Manufacturer disclaims all warranties, expressed or implied, in fact or in law, to the extent allowed representative using authorized Cal Spas parts, No agent, dealer, distributor, service company or other party is authorized to change, modify or extend the terms of this limited warranty in any manner what- soever.
- Page 62 Lloyd’s Material Supply Company, Inc. LTR2023.1146 REV D-4 LTR2023.1146, REV. C-4 10/19/2023 6/28/2023...