Summary of Contents for Rinnai Energysaver RHFE-559T
Page 1
Service Manual Rinnai UK RHFE-559T Manual...
Page 2
Date of Issue: 29/08/2013 Last revision: 18/09/2013 Quality System Standard ISO 9001 - 2000 The Design, Development, and Manufacture of Gas Heating Appliances done under Rinnai’s Quality Management System is certified under the Quality Management System Standard ISO 9001. Registration Number JQ0003D Registered since: February 1994 Certified by JIA—QA Centre.
Before Making a Service Call ......15 Wiring Diagram ..........49 Fault Codes ............ 16 Exploded View ………...…………………...50-55 Troubleshooting ..........17 CE CERTIFICATE ..........56 CONFORMITY DECLARATION ......57 CONSUMER SUPPORT Warranty Information ........58 Limited Warranty ..........58 CONTACT…………………………………………..59 Rinnai UK RHFE-559T Manual...
Therefore Rinnai recommends outdoor models be used for these locations where possible. The appliance, venting and vent termination(s) should not be installed in any areas where the air may contain these corrosive compounds.
Due to high temperatures, the appliance should be Do not install damaged heater: if the heater is located out of traffic and away from furniture and damaged, contact Rinnai or your supplier for advice. draperies. Before installing the heater check the label for the ...
Nominal gas rate Max 0.59 m Max 0.22 m Rinnai is continually updating and improving products. Therefore, specifications are subject to change without prior notice. The efficiency rating of this appliance is a product thermal efficiency rating determined under continuous operating conditions and was determined independently of any installed system.
Power Failure: The appliance will shut off the gas Fusible Link: In case the overheat feature does if it loses electrical power. not prevent an overheat then the fusible link could break, shutting off the appliance. Rinnai UK RHFE-559T Manual...
Page 10
AIR FILTER Pull up to remove GAS INLET CONNECTION 1/2” (15mm) FLUE Male TERMINAL Exhaust vent & ROOM TEMP. Combustion air intake SENSOR POWER CORD Exhaust pipe Plug 230vAC 50 Hz Air Intake Hose Rinnai UK RHFE-559T Manual...
Page 12
DIMENSIONS A full size template is provided on the NOTICE RHFE-559T cardboard packaging. DO NOT DISCARD until installation is completed. Rinnai UK RHFE-559T Manual...
Page 13
Wiring Diagram Rinnai UK RHFE-559T Manual...
Page 14
If the flame goes out during operation this device shuts off the gas to the burner. To reset, turn the unit `OFF`, then `ON` again. ELECTRICAL FUSE The electrical circuits are protected by an electrical fuse When the fuse blows, the heater will not operate. The cause of this occurrence must be ascertained. This page is intentionally blank Rinnai UK RHFE-559T Manual...
Whenever the appliance starts heating again, the “Economy” indicator will light. The Economy function can only be turned off while the heater is operating (heating) and when the “Economy” indicator is lit. Rinnai UK RHFE-559T Manual...
[L] - temperature is controlled at set temperature “Low”. b) b) [16°C] to [26°C] in 1°C steps - thermostatic control to preset temp selected. Combustion rate varies as required to maintain the selected temperature. c) c) [H] - continuous combustion on “High”. Rinnai UK RHFE-559T Manual...
Carefully insert a screwdriver and gently bend the vertical louvers either to the right or to the left. The horizontal louvers are fixed and cannot be adjusted. Do not bend repeatedly adjust louvers (no more than 5 times) or they will break. Rinnai UK RHFE-559T Manual...
Snow Accumulation Keep the area around flue terminal free of snow and ice. The appliance will not function properly if the intake air or exhaust is impeded by obstructions. Rinnai UK RHFE-559T Manual...
Page 19
BASIC FAULT GUIDES Rinnai UK RHFE-559T Manual...
Page 20
NOTE: service calls for general cleaning, maintenance and wear and tear are not covered under the war- ranty. Service calls of this nature may be chargeable. Faults caused by insufficient gas supply, gas quality, installation errors or operation errors are not cov- ered by the Rinnai warranty. Rinnai UK RHFE-559T Manual...
Keep burner the ON/OFF button on the control panel. and control compartment clean. 3. Locate the manual gas valve on the side of the unit. Turn the manual valve clockwise to the full OFF position. Rinnai UK RHFE-559T Manual...
When operating normally the burner flame should appear as long, clear, blue, stable, streaks. Yellow flames or an orange color is abnormal and maintenance is required. ABNORMAL NORMAL Flame Rod Flame Rod Yellow flames or orange color Long, clear, blue, stable flames Final Assembly Install the front panel and bottom cover. Rinnai UK RHFE-559T Manual...
Page 29
13. Remove manometer and install the two pressure TORS AND CORRECT DAMPER MUST point screws. BE FITTED 14. Operate the unit and: check the normal operating sequence visually inspect the flame check for gas leaks at the test points Rinnai UK RHFE-559T Manual...
Page 30
DISMANTLING for SERVICE Rinnai UK RHFE-559T Manual...
Page 31
DISMANTLING for SERVICE Rinnai UK RHFE-559T Manual...
Page 32
DISMANTLING for SERVICE Rinnai UK RHFE-559T Manual...
Page 33
DISMANTLING for SERVICE Rinnai UK RHFE-559T Manual...
Page 34
DISMANTLING for SERVICE Rinnai UK RHFE-559T Manual...
Page 35
DISMANTLING for SERVICE Rinnai UK RHFE-559T Manual...
Page 36
DISMANTLING for SERVICE Rinnai UK RHFE-559T Manual...
Page 37
DIAGNOSTIC POINTS Rinnai UK RHFE-559T Manual...
Date of Installation: __________________________________ Limited Warranty Energysaver Space Heaters Item Period of Coverage Heat Exchanger 10 years from date of purchase All Other Parts 5 years from date of purchase Reasonable Labor 2 years from date of purchase Rinnai UK RHFE-559T Manual...
What will Rinnai do? Rinnai will repair or replace the covered product or any part or component that is defective in materials or workmanship as set forth. Rinnai will pay reasonable labor charges associated with the repair or replacement of any such part or component. All repair parts must be genuine Rinnai parts. All repairs or replacements must be performed by an individual or servicing company that is properly trained, state qualified or licensed to do the type of repair.
Page 48
V. 1 - 130806 RHF559-1476(00) Rinnai UK RHFE-559T Manual...