Management Operations; Transport And Checking On Receipt - ABB Sace Emax 2 Installation, Operation And Maintenance Instructions
Emax e1.2 low voltage air circuit-breakers
Hide thumbs
Also See for Sace Emax 2:
Table of Contents
Advertisement
Management operations
1 - Transport and checking on receipt
Introduction The SACE Emax 2 circuit-breakers, on account of their weight, require special attention during transport
Weight of the circuit-breakers
with packaging
Transport of the packaged
circuit-breaker
7 | © 2022 ABB | 1SDH000999R0002 - ECN000297030
and handling.
They are distributed with following packages:
• one package for fixed circuit-breaker
• two packages for withdrawable circuit-breakers (one package for the fixed part and one for the
mobile part).
WARNING! comply with the following instructions during each transport phase:
• The movable part of the circuit-breaker must be removed from the switchgear and/or
from the relative fixed part even if this latter is not installed in the switchgear.
• The circuit-breaker must be in the open position.
• The circuit-breaker must be protected and fastened in its original packing.
• The closing springs of the circuit-breaker must be completely discharged.
The following table specifies the weights of the circuit-breakers with packaging:
Fixed
III
16 Kg / 35
E1.2
lbs
16 Kg / 35
E1.2-A
lbs
NOTE:
• weights are indicated with reference to the basic circuit-breakers including protection trip
unit and its sensors, without terminals and without accessories.
• the weights of the fixed part of withdrawable circuit-breakers refer to the version with
horizontal rear terminals.
Consult the table "Weight of the circuit-breakers with packaging" before proceeding with the transport.
WARNING! improper lifting can result in death, serious injury to persons and damage to
the equipment. Never lift a circuit-breaker and/or a fixed part above other people.
IMPORTANT: The trained personnel in charge of handling and lifting must use appropriate
safety equipment.
Moving part of withdra-
wable device
IV
III
18 Kg / 39
20 Kg / 44
lbs
lbs
18 Kg / 39
22 Kg / 48
lbs
lbs
ABB | SACE Emax 2
Fixed part of withdra-
wable device
IV
III
23 Kg / 51
23 Kg / 51
lbs
lbs
25.5 Kg / 56
24 Kg / 52
lbs
lbs
Management operations
1 - Transport and checking on receipt
IV
26 Kg / 57
lbs
27 Kg / 59
lbs
Advertisement
Table of Contents
